NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
176 reportsMileage unknown · Mar 3, 2021
Electrical SystemUnknown Or Other
WATER LEAK ON HEADLINER AT SUN VISOR OR OVERHEAD CONSOLE AREAS. HAVE REACHED OUT TO CHEVROLET DEALERSHIP TO ADDRESS CONCERN OF ISSUE THAT I WAS ABLE TO LOCATE SAME THING HAPPENING TO THIS YEAR VEHICLE WHERE TSBS HAVE BEEN IDENTIFIED TO BE TOLD MY VIN # IS NOT LISTED. THIS WOULD REQUIRE ME TO HAVE A WATER SPECIALIST COME OUT T…
Read full complaint
WATER LEAK ON HEADLINER AT SUN VISOR OR OVERHEAD CONSOLE AREAS. HAVE REACHED OUT TO CHEVROLET DEALERSHIP TO ADDRESS CONCERN OF ISSUE THAT I WAS ABLE TO LOCATE SAME THING HAPPENING TO THIS YEAR VEHICLE WHERE TSBS HAVE BEEN IDENTIFIED TO BE TOLD MY VIN # IS NOT LISTED. THIS WOULD REQUIRE ME TO HAVE A WATER SPECIALIST COME OUT TO THE DEALERSHIP TO ASSESS THE ISSUE BEFORE ANY REPAIRS CAN BE MADE TO VEHICLE SINCE THERE IS NO TSB LISTED. NHTSA TSB # 10137374 & 10089829.
NHTSA ODI #11398965
Mileage unknown · Mar 3, 2021
Electrical SystemUnknown Or Other
WATER LEAK ON HEADLINER AT SUN VISOR OR OVERHEAD CONSOLE AREAS, RESULT OF SHARK FIN ANTENNA. VEHICLE NOT LISTED UNDER VINS FOR NHTSA TSB # 10089829 & 10089829. VEHICLE HAS PREVIOUSLY HAD DEAD BATTERY WHICH DEALER CLAIMED IT WAS OLD BATTERY, AND THEREFORE REPLACED MY TERMINALS AND I PURCHASED A NEW BATTERY. MY TRUCK IS A 2…
Read full complaint
WATER LEAK ON HEADLINER AT SUN VISOR OR OVERHEAD CONSOLE AREAS, RESULT OF SHARK FIN ANTENNA. VEHICLE NOT LISTED UNDER VINS FOR NHTSA TSB # 10089829 & 10089829. VEHICLE HAS PREVIOUSLY HAD DEAD BATTERY WHICH DEALER CLAIMED IT WAS OLD BATTERY, AND THEREFORE REPLACED MY TERMINALS AND I PURCHASED A NEW BATTERY. MY TRUCK IS A 2015 CHEVROLET SILVERADO 2500 CREW CAB AND IS EXPERIENCING THE SAME ISSUE AS THIS SERVICE BULLETIN IS LISTING. THEREFORE DEALER HAS STATED IT WOULD BE $120 TO HAVE OUTSIDE COMPANY COME IN TO INSPECT VEHICLE BEFORE AND ADDITIONAL WRITE UP COULD BE DONE AND REPAIR WOULD BE OUT OF POCKET.
NHTSA ODI #11398963
116,390 miles · Feb 2, 2021
Steering
MY 2015 SILVERADO 2500HD PICK UP'S POWER STEERING OCCASIONALLY STOPS WORKING ALL TOGETHER AT LOW SPEED RIGHT HAND TURNS. THE LATEST INCIDENT WAS LAST NIGHT AT 116390 MILES I WAS TURNING OFF THE MAIN ROAD INTO A GAS STATION AND I CAME VERY CLOSE TO HITTING A CAR THAT WAS EXITING AT THE SAME 2 LANE EXIT/ENTRANCE. SCARRY!!
NHTSA ODI #11394311
Mileage unknown · Dec 21, 2020
Exterior Lighting
STOCK LOW BEAM HEADLIGHTS ARE SO DIM AND HAVE A SHARP CUTOFF LINE THAT IT IS NEARLY IMPOSSIBLE TO SEE DRIVING AT NIGHT . I WANT TO BE ABLE TO SEE THE LINES WHEN IM DRIVING AND CARS COMING THE OTHER WAY, BUT IT IS ALMOST IMPOSSIBLE IF ROAD IS DARK AND CARS COMING OTHER WAY. PLEASE FIND A STOCK 2015 CHEVY 2500HD WORK TRUCK AND CHE…
Read full complaint
STOCK LOW BEAM HEADLIGHTS ARE SO DIM AND HAVE A SHARP CUTOFF LINE THAT IT IS NEARLY IMPOSSIBLE TO SEE DRIVING AT NIGHT . I WANT TO BE ABLE TO SEE THE LINES WHEN IM DRIVING AND CARS COMING THE OTHER WAY, BUT IT IS ALMOST IMPOSSIBLE IF ROAD IS DARK AND CARS COMING OTHER WAY. PLEASE FIND A STOCK 2015 CHEVY 2500HD WORK TRUCK AND CHECK LOW BEAM. HIGH BEAMS ARE WONDERFUL, BUT CAN'T DRICE WITH THEM ON, ALTHOUGH LOOKING AT EVERY OTHER CAR ON ROAD AND HOW BRIGHT SOME ARE I PROBABLY CAN.
NHTSA ODI #11384428
80,000 miles · Dec 17, 2020
VisibilityFire
TL* THE CONTACT OWNS A 2015 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THE REAR WINDOW DEFROSTER SYSTEM STARTED SMOKING AND THE REAR WINDOW SHATTERED. THE CONTACT STATED THAT THE VEHICLE WAS NOT TAKEN TO A DEALER NOR AN INDEPENDENT MECHANIC TO BE DIAGNOSED OR INSPECTED. THE VEHICLE WAS …
Read full complaint
TL* THE CONTACT OWNS A 2015 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THE REAR WINDOW DEFROSTER SYSTEM STARTED SMOKING AND THE REAR WINDOW SHATTERED. THE CONTACT STATED THAT THE VEHICLE WAS NOT TAKEN TO A DEALER NOR AN INDEPENDENT MECHANIC TO BE DIAGNOSED OR INSPECTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
NHTSA ODI #11383951
Mileage unknown · Dec 3, 2020
Electrical SystemForward Collision AvoidanceService Brakes
THE TRAILER BRAKE IT BEEN MISS UP AND EVER BODY I TALK THAT HAS THE SAME YEAR MODEL AND EVERYTHING LIKE MY TRUCK HAS HAD THIS PROBLEM IT KEEP MY LOG DOWN IT THINK IT HAS A TRAILER ON IT AT ALL TIME
NHTSA ODI #11377612
106,000 miles · Oct 17, 2020
Electrical SystemStructure
MY BATTERY WAS DEAD THIS MORNING, SO I JUMP STARTED MY TRUCK. I LET IT RUN STATIONARY FOR 10 MINUTES AND THE BATTERY EXPLODED. IT SOUNDED LIKE A BOMB WENT OFF. IT BLEW THE BATTERY INTO PIECES, ELECTRONICS AND THE COOLANT RESIVOIR. IT SPRAYED BATTERY ACID, COOLANT EVERYWHERE. MY EARS WERE RINGING AS I WAS 10 FEET FROM IT. IT ALS…
Read full complaint
MY BATTERY WAS DEAD THIS MORNING, SO I JUMP STARTED MY TRUCK. I LET IT RUN STATIONARY FOR 10 MINUTES AND THE BATTERY EXPLODED. IT SOUNDED LIKE A BOMB WENT OFF. IT BLEW THE BATTERY INTO PIECES, ELECTRONICS AND THE COOLANT RESIVOIR. IT SPRAYED BATTERY ACID, COOLANT EVERYWHERE. MY EARS WERE RINGING AS I WAS 10 FEET FROM IT. IT ALSO DENTED THE FENDER ON MY TRUCK. I CONTACTED THE LOCAL CHEVY DEALERSHIP AND WAS BLOWN OFF, WAS TOLD I WOULD BE CALLED BACK BUT WAS NOT. THEY SAID THEY HAD NO INFORMATION ON PROBLEMS WITH THOSE BATTERIES AND SAID THEY COULDN'T GET A RESIVOIR FOR 3 DAYS. WE ARE TRAVELING AND STOPPED HERE IN LEBANON TN FOR THE WEEKEND. I HAVE MANY MORE PICTURES, BUT THEY ARE TOO LARGE TO ADD.
NHTSA ODI #11364847
127,000 miles · Oct 7, 2020
Power Train
TRUCK HAS 120,000 MILES AND ON THE WAY HOME FROM SHOPPING ALL THE SUDDEN MY TRUCK WOULDN'T SHIFT PASS 3 RPM'S AND BARLEY MADE IT THE HILL. AFTER STOPPING TWICE TO LET THE TRUCK REST I MADE IT HOME. THE DTC CODE WAS P0796 PRESSURE CONTROL SOLENOID 'C' PERFORMANCE OR STUCK OFF OBD-II TROUBLE CODE. SEVERAL OTHER REPORTS ARE FOUND W…
Read full complaint
TRUCK HAS 120,000 MILES AND ON THE WAY HOME FROM SHOPPING ALL THE SUDDEN MY TRUCK WOULDN'T SHIFT PASS 3 RPM'S AND BARLEY MADE IT THE HILL. AFTER STOPPING TWICE TO LET THE TRUCK REST I MADE IT HOME. THE DTC CODE WAS P0796 PRESSURE CONTROL SOLENOID 'C' PERFORMANCE OR STUCK OFF OBD-II TROUBLE CODE. SEVERAL OTHER REPORTS ARE FOUND WITH THE SAME ISSUE SOME BELIEVE IT'S THE TORQUE CONVERTER. I REALLY USE TO STAND BEHIND GM BUT MY DISAPPOINTMENT ON THIS EXPENSIVE TRUCK HAS REALLY CHANGED MY OPINION.
NHTSA ODI #11363313
5,000 miles · Aug 4, 2020
Air Bags
AIR BAG WARNING LIGHT AND BEEPER REPEATEDLY GOES OFF INTERMITTINGLY.
NHTSA ODI #11343117
Mileage unknown · Jul 14, 2020
Power Train
WAS ON A TRIP AND THE ENGINE LIGHT CAME ON, WE STOPPED AND CHECKED EVERYTHING AND CAME UP WITH NOTHING. TOOK IT TO THE GARAGE AND WAS TOLD THEY PUT IT ON THE MACHINE AND IT CAME UP THE TRANSMISSION, THE GARAGE PULLED THE TRANSMISSION PAN AND SAID IT HAD METAL SHAVINGS IN THE PAN. IT HAS 64,000 ON IT AND THEY SAY THERE IS NO WARR…
Read full complaint
WAS ON A TRIP AND THE ENGINE LIGHT CAME ON, WE STOPPED AND CHECKED EVERYTHING AND CAME UP WITH NOTHING. TOOK IT TO THE GARAGE AND WAS TOLD THEY PUT IT ON THE MACHINE AND IT CAME UP THE TRANSMISSION, THE GARAGE PULLED THE TRANSMISSION PAN AND SAID IT HAD METAL SHAVINGS IN THE PAN. IT HAS 64,000 ON IT AND THEY SAY THERE IS NO WARRANTY AND WE ARE PRETTY SURE WE BOUGHT AN EXTENDED WARRANTY BUT PAPERS ARE IN THE TRUCK WHICH WE DON'T HAVE ACCESS TO- EITHER WAY IT SHOULD BE COVERED WHETHER OR NOT WE HAVE A WARRANTY WHICH THEY SAY EXPIRED IN MARCH. THE TRUCK HAS NO SIGNS OF TRANSMISSION FAILURE. IT IS AT THE GARAGE GETTING A NEW TRANSMISSION IN IT WHICH IS 4600, WHICH I FEEL WE SHOULD GET SOME KIND OF REIMBURSEMENT SINCE IT SHOULD BE COVERED. THE GARAGE HAS THE TRUCK AND WE DON'T HAVE THE PAPERWORK YET-THIS IS ALSO THE DEALERSHIP WHERE WE PURCHASED THE TRUCK.
NHTSA ODI #11339416
Official recalls
6Jul 1, 2021
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Interim owner notification letters informing owners of the safety risk were mailed on August 18, 2021. Owners will receive a second notice when the remedy is available. Phase I owner notification letters were mailed on May 5, 2022. Phase II owner notification letters are expected to be mailed on May 31, 2022. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. This recall supersedes NHTSA recall number 20V-736. GM's number for this recall is N202324251.
Nov 25, 2020
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500 and Chevrolet Silverado 1500 and 2015 GMC Sierra 2500 and 3500, and Chevrolet Silverado 2500 and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator.
Consequence & remedy
Consequence: If the end cap separates from the inflator, the compressed gas will escape and the end cap can be propelled into the vehicle, increasing the risk of injury or a crash.
Remedy: GM will notify owners, and dealers will replace the RRAB modules on the left and/or right side, free of charge. Interim owner notification letters were mailed on December 22, 2020. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. Note: GM filed a new recall, number 21V-504 that supersedes this recall. All vehicles previously recalled under 20V-736 will now be repaired under the new recall number 21V-504. GM's numbers for this recall are N202309680, N202309681, and N202309682.
Aug 30, 2018
General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 2500, 3500, 1500 Crew Cab Special Service, Tahoe Police Pursuit/Special Service, GMC Sierra 2500, and 3500 vehicles. The brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Consequence & remedy
Consequence: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Remedy: GM will notify owners, and dealers will add adhesive to the nut and reinstall the nut with increased tightness, free of charge. The recall began October 3, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18278. Note: The vehicles in this recall need this additional remedy despite being covered by recall 16V069 for brake pedal loosening.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Feb 5, 2016
General Motors LLC (GM) is recalling certain model year 2015-2016 Chevrolet Silverado 1500, 2500, and 3500 heavy duty trucks manufactured October 1, 2013, to February 1, 2016, 2015-2016 Chevrolet Tahoe Police Pursuit Vehicles (PPV) manufactured March 1, 2014, to February 1, 2016, and 2015-2016 GMC Sierra 2500 and 3500 heavy duty trucks manufactured October 29, 2013, to February 1, 2016. On the affected vehicles, the brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Consequence & remedy
Consequence: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Remedy: GM will notify owners, and dealers will add adhesive to the brake pedal pivot nut and reinstall with an increased torque, free of charge. The recall began on March 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 20760.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration