NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
57 reportsClear category filter60,000 miles · Nov 14, 2017
Electrical System
THE HMI IN THE TRUCK WILL SHOW THE RADIO INFO OR BACK-UP CAMERA PICTURE, ETC. BUT, AT DIFFERENT RANDOM TIMES, EVEN THOUGH THERE IS A VISUAL OF RADIO OR BACK-UP PICTURE, THERE IS NO SOUND.FOR RADIO, BLINKERS, SEAT BELT, IF YOUR ARE GOING TO HIT SOMETHING BEHIND YOU,ETC. THIS ALL HAPPENS RANDOMLY. WHETHER PARKED, DRIVING ON HIGH…
Read full complaint
THE HMI IN THE TRUCK WILL SHOW THE RADIO INFO OR BACK-UP CAMERA PICTURE, ETC. BUT, AT DIFFERENT RANDOM TIMES, EVEN THOUGH THERE IS A VISUAL OF RADIO OR BACK-UP PICTURE, THERE IS NO SOUND.FOR RADIO, BLINKERS, SEAT BELT, IF YOUR ARE GOING TO HIT SOMETHING BEHIND YOU,ETC. THIS ALL HAPPENS RANDOMLY. WHETHER PARKED, DRIVING ON HIGHWAY, STREETS OR TURNING. THE OTHER PROBLEM WHICH MAY NOT BE RELATED TO ABOVE, IS THAT EVEN THOUGH ALL FOUR DOORS LOCK WHEN YOU USE THE KEY FOB, MANUALLY LOCK THEM OR START DRIVING THE TRUCK, ONE OF THE REAR DOORS WILL OPEN LIKE IT WAS NEVER LOCKED.
NHTSA ODI #11046085
40,200 miles · Jul 24, 2017
Electrical SystemService BrakesStructure
TAKATA PROBLEMS, CLUTCH IN AIR CONDIIONING UNITS..FREEZING UP , EATS BELTS THEIR IS A FLAW IT WILL CAUSE YOU TO HAVE ASMA ATTACK FROM RUSH OF HOT AIR IN VEHICLE..DANGEROUS.,..BREAKS ARE SQUEEKING WHEN PULLING OUT N DRIVING..NOTICE TREAD LOOKS UNEVEN IN FRONT. PEELING PAINT ON DOORS
NHTSA ODI #11010394
12,000 miles · Feb 17, 2017
Electrical SystemCrash
I BOUGHT THIS TRUCK 14 MONTHS AGO AND WAS TALKED INTO A GPS SYSTEM. THE DOCUMENTATION STATED IT WAS THE LATEST AND GREATEST AND UP TO DATE. IT WAS BOTHERSOME THAT THE SYSTEM COULD NOT KNOW ABOUT MY 7 YEAR OLD SUBDIVISION AND LARGE INTERSECTION SUCH AS THE NEW I 65 INTERCHANGE ON THE SOUTH SIDE OF INDY. THEN I PULLED A TRAILER TO…
Read full complaint
I BOUGHT THIS TRUCK 14 MONTHS AGO AND WAS TALKED INTO A GPS SYSTEM. THE DOCUMENTATION STATED IT WAS THE LATEST AND GREATEST AND UP TO DATE. IT WAS BOTHERSOME THAT THE SYSTEM COULD NOT KNOW ABOUT MY 7 YEAR OLD SUBDIVISION AND LARGE INTERSECTION SUCH AS THE NEW I 65 INTERCHANGE ON THE SOUTH SIDE OF INDY. THEN I PULLED A TRAILER TO TEXAS AND WAS ALMOST KILLED IN A HEAD ON BECAUSE THE GPS SYSTEM IN MY NEW TRUCK THINKS ALL FRONTAGE ROADS IN TX ARE 2 WAY WHEN MOST ARE ONE WAY IN THE SAME DIRECTION AS THE TRAVEL LANES FOR THE INTERSTATE. IT WAS ABOUT 10 PM AND RAINING. I WAS DIRECTED TO EXIT THE FREEWAY AND CROSS UNDER AND TURN RIGHT AND GO 1 MILE TO MY DESTINATION. I MADE THE TURN AND WAS UP TO ABOUT 50 MPH WHEN AN 18 WHEELER CAME DOWN THE EXIT RAMP HEADED STRAIGHT FOR ME. WE BOTH HAD TO MAKE SOME WILD MANEUVERS TO AVOID THE COLLISION. I ENDED UP HAVING TO REPLACE THE TRUCK BED FROM DAMAGE ON TH SIDE FROM A SEMI JACKKNIFE. I CONTACTED CHEVY AND SPENT MANY CALLS WITH THEIR ENTERTAINMENT DEPT TO TRY AND FIX THIS ISSUE. CHEVY REFUSES TO FIX THIS ISSUE AND WANTS ME TO BUY AN UPDATE. I WON'T DO THAT AS IT WOULD ERASE THE ORIGINAL SOFTWARE AND I WOULD NOT BE ABLE TO PROVE WHAT HAPPENED. IF YOU HAVE ANY WRONG WAY HEAD ONS IN TX IN A GM PRODUCT IS WAS MOST LIKELY THE GPS THAT CAUSED THE WRECK. I'M FRUSTRATED THAT THERE SEEMS TO BE NO INTEREST IN THIS PROBLEM. LUCKILY THE GPS IN MY PHONE WORKS FINE AND I CAN GET TO MY DESTINATIONS SAFELY FOR ALMOST FREE INSTEAD OF THE $850.00 CHEVY SYSTEM THAT HAS TRIED TO KILL ME TWICE BEFORE I STOPPED USING IT. I HAVE TALKED TO SEVERAL CHEVY MECHANICS AND THEY HAVE ALSO SEEN THE PROBLEM IN BOTH CUSTOMER CARS AND WHEN THEY HAVE RENTED A GM PRODUCT. DATE IS A GUESS AS IT HAS BEEN AWHILE, NOTE: I DELIVER RV'S AND KEEP LOGBOOKS AND CAN GET THE EXACT DATE IF NEEDED. HD LONG BED CREW CAB 4X4 SINGLEHTTPS://WWW-ODI.NHTSA.DOT.GOV/VEHIC TIRE PU
NHTSA ODI #10955213
15,000 miles · Nov 23, 2016
Electrical SystemSteering
TL* THE CONTACT OWNS A 2015 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A LOSS OF POWER STEERING AND A LOSS OF POWER WHILE DRIVING AT LOW SPEEDS. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE STEERING POSITION SENSORS AND THE GEAR BOX WERE …
Read full complaint
TL* THE CONTACT OWNS A 2015 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A LOSS OF POWER STEERING AND A LOSS OF POWER WHILE DRIVING AT LOW SPEEDS. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE STEERING POSITION SENSORS AND THE GEAR BOX WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURES RECURRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000. THE VIN WAS NOT PROVIDED.
NHTSA ODI #10927719
13,000 miles · Apr 14, 2016
Electrical SystemExterior LightingPower Train
THE HEAD LIGHTS ON A DARK RAINY NIGHT ARE SO POOR IT IS A HAZARD TO DRIVE, IF YOU MEET ANOTHER AUTOMOBILE JUST HOLD ON AND HOPE YOU DO NOT HIT EACH OTHER, AS YOU CAN'T TELL YOU ARE GOING TO. I HAVE HAD IT BACK FOR REPAIR BUT THEY TELL ME THERE IS NO FIX FOR A CHEVY, IF I HAD A GMC THERE IS A FIX. MY RADIO WILL NOT WORK WHEN ITS …
Read full complaint
THE HEAD LIGHTS ON A DARK RAINY NIGHT ARE SO POOR IT IS A HAZARD TO DRIVE, IF YOU MEET ANOTHER AUTOMOBILE JUST HOLD ON AND HOPE YOU DO NOT HIT EACH OTHER, AS YOU CAN'T TELL YOU ARE GOING TO. I HAVE HAD IT BACK FOR REPAIR BUT THEY TELL ME THERE IS NO FIX FOR A CHEVY, IF I HAD A GMC THERE IS A FIX. MY RADIO WILL NOT WORK WHEN ITS REALLY COLD OUT. MY TRANSMISSION SHIFTS HARSHLY AND ENGINE FLUTTERS BETWEEN GEARS. WHEN I SLOW DOWN COMING INTO TOWN I FEEL A HARD DOWN SHIFT, ALSO IF GOING SLOW AND CLIMBING A HILL THAT IS WHEN IT FEELS AS IF THE ENGINE HAS A SMALL SKIP BUT IT IS THE TRANSMISSION NOT SHIFTING INTO A LOWER GEAR. THERE IS ALSO NO FIX FOR POOR SHIFTING.
NHTSA ODI #10855585
2,000 miles · Feb 11, 2016
Electrical SystemEnginePower Train
I BOUGHT THIS TRUCK BRAND NEW. I STARTED HAVING PROBLEMS ABOUT 2000 MI. THE TRUCK HAS A MISS AND JERKS UNDER LOAD. IT HAS BEEN TO THE DEALER TWICE AND THEY TELL ME THE COMPUTER DOESN'T SHOW ANY TROUBLE CODES SO THERE IS NOTHING THEY CAN DO. ALSO ON OCCASION THE IGNITION KEY IS HOT TO THE TOUCH. NOW I HAVE TO TAKE IT IN AGAIN BE…
Read full complaint
I BOUGHT THIS TRUCK BRAND NEW. I STARTED HAVING PROBLEMS ABOUT 2000 MI. THE TRUCK HAS A MISS AND JERKS UNDER LOAD. IT HAS BEEN TO THE DEALER TWICE AND THEY TELL ME THE COMPUTER DOESN'T SHOW ANY TROUBLE CODES SO THERE IS NOTHING THEY CAN DO. ALSO ON OCCASION THE IGNITION KEY IS HOT TO THE TOUCH. NOW I HAVE TO TAKE IT IN AGAIN BECAUSE THE BRAKE PETAL MIGHT FALL OFF. WHAT A GREAT PRODUCT...GM I THINK BUILDS A LOT OF THESE PROBLEMS IN TO SAVE MONEY WITHOUT A CARE FOR THE CUSTOMER. NOW I HAVE TO DRIVE A $46,000 PIECE OF CRAP THATS BROKEN. OUR HANDS ARE TIED AND AT THE MERCY OF BIG BUSINESS. HOPE YOU CAN HELP. STEVE
NHTSA ODI #10825714
23,000 miles · Feb 9, 2016
Electrical SystemService Brakes
WHILE TOWING, BREAK WARNING LIGHT CAME ON. HAD NO TRAILER BREAKS AND HAD TO STOP PULL OFF ROAD. SHUT DOWN AS PER MANUEL AND RESTART. THAT CORRECTED THE PROBLEM. THIS COULD HAVE BEEN A SERIOUS ISSUE IF WE HAD BEEN ON A STEEP DOWNHILL GRADE!
NHTSA ODI #10825086
4,000 miles · Jan 11, 2016
Electrical System
FACTORY TRAILER BRAKE CONNECTOR PLUG IS LOOSE AND CAUSES TRAILER BRAKES TO BECOME INOPERATIVE WHEN THE TRAILER MALE PLUG JIGGLES INSIDE THE TRUCK FEMALE PLUG. I BELONG TO SEVERAL RV RELATED SITES ON THE INTERNET, AND THIS ISSUE IS COMING UP MORE OFTEN WITH PEOPLE THINKING IT IS JUST THEIR PLUG OR CONNECTOR. MINE FIT FINE IN MY…
Read full complaint
FACTORY TRAILER BRAKE CONNECTOR PLUG IS LOOSE AND CAUSES TRAILER BRAKES TO BECOME INOPERATIVE WHEN THE TRAILER MALE PLUG JIGGLES INSIDE THE TRUCK FEMALE PLUG. I BELONG TO SEVERAL RV RELATED SITES ON THE INTERNET, AND THIS ISSUE IS COMING UP MORE OFTEN WITH PEOPLE THINKING IT IS JUST THEIR PLUG OR CONNECTOR. MINE FIT FINE IN MY 2004 TAHOE, BUT IS VERY LOOSE ON THE NEW TRUCK. OTHERS ARE SAYING THEIRS ALSO FIT OTHER BRANDS OF PREVIOUS OWNED TRUCKS OR EARLIER CHEVY YEAR MODELS. THIS IS A HUGE SAFETY ISSUE, AS GOING DOWN A MOUNTAIN OR THROUGH AN INTERSECTION WITH NO TRAILER BRAKES IS GOING TO GET PEOPLE HURT AND KILLED. THE PLUG WAS NOT MANUFACTURED WITH THE PROPER TOLERANCE FOR A GOOD SNUG FIT. THE LITTLE SAFETY DOOR WITH THE TAB ON IT HELPS TO HOLD IT IN PLACE, BUT THE FIT IS STILL SO LOOSE THAT THE CONNECTION IS LOST TO LIGHTS AND BRAKES. IT IS LOOSE WHEN YOU SLIDE IT IN, BUT THE BUMPINESS AND THE MOVEMENT OF THE VEHICLES MAKES IT LOSE THE CONNECTION. I BROUGHT THIS UP TO THE DEALER THAT I PURCHASED THE TRUCK FROM, BUT IT SEEMED TO BE A NON ISSUE WITH THEM. I THINK IT NEEDS TO BE ADDRESSED WITH GM AND QUICKLY. WE ALL KNOW OF THEIR RECORD ON FAULTY SWITCHES ETC. THESE PLUGS NEED TO BE REPLACED WITH PROPER FITTING ONES. THANK YOU *TR
NHTSA ODI #10819514
150 miles · Aug 10, 2015
Electrical SystemService Brakes
A WARNING MESSAGE COMES ON THE DASH TELLING THE DRIVER THERE IS A ISSUE WITH THE TRAILER BRAKES, OR WIRING SYSTEM. THE TRAILER BRAKES BECOME INOPERABLE WHEN THIS COMES ON. WE HAVE CONTACTED GM WITH THE ISSUE, BOTH AT THE DEALER LEVEL AND AT THE CORPORATE LEVEL; AND THEY INSIST IT IS A PROBLEM WITH OUR TRAILERS. THE SAME TRAILERS…
Read full complaint
A WARNING MESSAGE COMES ON THE DASH TELLING THE DRIVER THERE IS A ISSUE WITH THE TRAILER BRAKES, OR WIRING SYSTEM. THE TRAILER BRAKES BECOME INOPERABLE WHEN THIS COMES ON. WE HAVE CONTACTED GM WITH THE ISSUE, BOTH AT THE DEALER LEVEL AND AT THE CORPORATE LEVEL; AND THEY INSIST IT IS A PROBLEM WITH OUR TRAILERS. THE SAME TRAILERS ARE USED WITH OLDER CHEVROLET TRUCKS WITHOUT INCIDENT. WE HAVE ALSO BEEN INFORMED BY GM THAT THE 2015 SILVERADO 2500'S ARE EQUIPPED WITH A MORE SENSITIVE TRAILERING SYSTEM. WHEN THE CONNECTION BECOMES WET DURING INCLEMENT WEATHER, OR THE TRUCK HITS A BUMP; AND THE CONNECTOR LOSES CONTACT MOMENTARILY THE MESSAGE WILL ILLUMINATE. RESULTING IN THE LOSS OF TRAILER BRAKES. THIS IS A SERIOUS SAFETY ISSUE.
NHTSA ODI #10747560
130 miles · Aug 10, 2015
Electrical SystemService Brakes
A WARNING MESSAGE COMES ON THE DASH TELLING THE DRIVER THERE IS A ISSUE WITH THE TRAILER BRAKES, OR WIRING SYSTEM. THE TRAILER BRAKES BECOME INOPERABLE WHEN THIS COMES ON. WE HAVE CONTACTED GM WITH THE ISSUE, BOTH AT THE DEALER LEVEL AND AT THE CORPORATE LEVEL; AND THEY INSIST IT IS A PROBLEM WITH OUR TRAILERS. THE SAME TRAILERS…
Read full complaint
A WARNING MESSAGE COMES ON THE DASH TELLING THE DRIVER THERE IS A ISSUE WITH THE TRAILER BRAKES, OR WIRING SYSTEM. THE TRAILER BRAKES BECOME INOPERABLE WHEN THIS COMES ON. WE HAVE CONTACTED GM WITH THE ISSUE, BOTH AT THE DEALER LEVEL AND AT THE CORPORATE LEVEL; AND THEY INSIST IT IS A PROBLEM WITH OUR TRAILERS. THE SAME TRAILERS ARE USED WITH OLDER CHEVROLET TRUCKS WITHOUT INCIDENT. WE HAVE ALSO BEEN INFORMED BY GM THAT THE 2015 SILVERADO 2500'S ARE EQUIPPED WITH A MORE SENSITIVE TRAILERING SYSTEM. WHEN THE CONNECTION BECOMES WET DURING INCLEMENT WEATHER, OR THE TRUCK HITS A BUMP; AND THE CONNECTOR LOSES CONTACT MOMENTARILY THE MESSAGE WILL ILLUMINATE. RESULTING IN THE LOSS OF TRAILER BRAKES. THIS IS A SERIOUS SAFETY ISSUE.
NHTSA ODI #10747555
Official recalls
6Jul 1, 2021
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Interim owner notification letters informing owners of the safety risk were mailed on August 18, 2021. Owners will receive a second notice when the remedy is available. Phase I owner notification letters were mailed on May 5, 2022. Phase II owner notification letters are expected to be mailed on May 31, 2022. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. This recall supersedes NHTSA recall number 20V-736. GM's number for this recall is N202324251.
Nov 25, 2020
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500 and Chevrolet Silverado 1500 and 2015 GMC Sierra 2500 and 3500, and Chevrolet Silverado 2500 and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator.
Consequence & remedy
Consequence: If the end cap separates from the inflator, the compressed gas will escape and the end cap can be propelled into the vehicle, increasing the risk of injury or a crash.
Remedy: GM will notify owners, and dealers will replace the RRAB modules on the left and/or right side, free of charge. Interim owner notification letters were mailed on December 22, 2020. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. Note: GM filed a new recall, number 21V-504 that supersedes this recall. All vehicles previously recalled under 20V-736 will now be repaired under the new recall number 21V-504. GM's numbers for this recall are N202309680, N202309681, and N202309682.
Aug 30, 2018
General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 2500, 3500, 1500 Crew Cab Special Service, Tahoe Police Pursuit/Special Service, GMC Sierra 2500, and 3500 vehicles. The brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Consequence & remedy
Consequence: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Remedy: GM will notify owners, and dealers will add adhesive to the nut and reinstall the nut with increased tightness, free of charge. The recall began October 3, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18278. Note: The vehicles in this recall need this additional remedy despite being covered by recall 16V069 for brake pedal loosening.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Feb 5, 2016
General Motors LLC (GM) is recalling certain model year 2015-2016 Chevrolet Silverado 1500, 2500, and 3500 heavy duty trucks manufactured October 1, 2013, to February 1, 2016, 2015-2016 Chevrolet Tahoe Police Pursuit Vehicles (PPV) manufactured March 1, 2014, to February 1, 2016, and 2015-2016 GMC Sierra 2500 and 3500 heavy duty trucks manufactured October 29, 2013, to February 1, 2016. On the affected vehicles, the brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Consequence & remedy
Consequence: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Remedy: GM will notify owners, and dealers will add adhesive to the brake pedal pivot nut and reinstall with an increased torque, free of charge. The recall began on March 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 20760.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration