NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
57 reportsClear category filterMileage unknown · Mar 3, 2021
Electrical SystemUnknown Or Other
WATER LEAK ON HEADLINER AT SUN VISOR OR OVERHEAD CONSOLE AREAS. HAVE REACHED OUT TO CHEVROLET DEALERSHIP TO ADDRESS CONCERN OF ISSUE THAT I WAS ABLE TO LOCATE SAME THING HAPPENING TO THIS YEAR VEHICLE WHERE TSBS HAVE BEEN IDENTIFIED TO BE TOLD MY VIN # IS NOT LISTED. THIS WOULD REQUIRE ME TO HAVE A WATER SPECIALIST COME OUT T…
Read full complaint
WATER LEAK ON HEADLINER AT SUN VISOR OR OVERHEAD CONSOLE AREAS. HAVE REACHED OUT TO CHEVROLET DEALERSHIP TO ADDRESS CONCERN OF ISSUE THAT I WAS ABLE TO LOCATE SAME THING HAPPENING TO THIS YEAR VEHICLE WHERE TSBS HAVE BEEN IDENTIFIED TO BE TOLD MY VIN # IS NOT LISTED. THIS WOULD REQUIRE ME TO HAVE A WATER SPECIALIST COME OUT TO THE DEALERSHIP TO ASSESS THE ISSUE BEFORE ANY REPAIRS CAN BE MADE TO VEHICLE SINCE THERE IS NO TSB LISTED. NHTSA TSB # 10137374 & 10089829.
NHTSA ODI #11398965
Mileage unknown · Mar 3, 2021
Electrical SystemUnknown Or Other
WATER LEAK ON HEADLINER AT SUN VISOR OR OVERHEAD CONSOLE AREAS, RESULT OF SHARK FIN ANTENNA. VEHICLE NOT LISTED UNDER VINS FOR NHTSA TSB # 10089829 & 10089829. VEHICLE HAS PREVIOUSLY HAD DEAD BATTERY WHICH DEALER CLAIMED IT WAS OLD BATTERY, AND THEREFORE REPLACED MY TERMINALS AND I PURCHASED A NEW BATTERY. MY TRUCK IS A 2…
Read full complaint
WATER LEAK ON HEADLINER AT SUN VISOR OR OVERHEAD CONSOLE AREAS, RESULT OF SHARK FIN ANTENNA. VEHICLE NOT LISTED UNDER VINS FOR NHTSA TSB # 10089829 & 10089829. VEHICLE HAS PREVIOUSLY HAD DEAD BATTERY WHICH DEALER CLAIMED IT WAS OLD BATTERY, AND THEREFORE REPLACED MY TERMINALS AND I PURCHASED A NEW BATTERY. MY TRUCK IS A 2015 CHEVROLET SILVERADO 2500 CREW CAB AND IS EXPERIENCING THE SAME ISSUE AS THIS SERVICE BULLETIN IS LISTING. THEREFORE DEALER HAS STATED IT WOULD BE $120 TO HAVE OUTSIDE COMPANY COME IN TO INSPECT VEHICLE BEFORE AND ADDITIONAL WRITE UP COULD BE DONE AND REPAIR WOULD BE OUT OF POCKET.
NHTSA ODI #11398963
Mileage unknown · Dec 3, 2020
Electrical SystemForward Collision AvoidanceService Brakes
THE TRAILER BRAKE IT BEEN MISS UP AND EVER BODY I TALK THAT HAS THE SAME YEAR MODEL AND EVERYTHING LIKE MY TRUCK HAS HAD THIS PROBLEM IT KEEP MY LOG DOWN IT THINK IT HAS A TRAILER ON IT AT ALL TIME
NHTSA ODI #11377612
106,000 miles · Oct 17, 2020
Electrical SystemStructure
MY BATTERY WAS DEAD THIS MORNING, SO I JUMP STARTED MY TRUCK. I LET IT RUN STATIONARY FOR 10 MINUTES AND THE BATTERY EXPLODED. IT SOUNDED LIKE A BOMB WENT OFF. IT BLEW THE BATTERY INTO PIECES, ELECTRONICS AND THE COOLANT RESIVOIR. IT SPRAYED BATTERY ACID, COOLANT EVERYWHERE. MY EARS WERE RINGING AS I WAS 10 FEET FROM IT. IT ALS…
Read full complaint
MY BATTERY WAS DEAD THIS MORNING, SO I JUMP STARTED MY TRUCK. I LET IT RUN STATIONARY FOR 10 MINUTES AND THE BATTERY EXPLODED. IT SOUNDED LIKE A BOMB WENT OFF. IT BLEW THE BATTERY INTO PIECES, ELECTRONICS AND THE COOLANT RESIVOIR. IT SPRAYED BATTERY ACID, COOLANT EVERYWHERE. MY EARS WERE RINGING AS I WAS 10 FEET FROM IT. IT ALSO DENTED THE FENDER ON MY TRUCK. I CONTACTED THE LOCAL CHEVY DEALERSHIP AND WAS BLOWN OFF, WAS TOLD I WOULD BE CALLED BACK BUT WAS NOT. THEY SAID THEY HAD NO INFORMATION ON PROBLEMS WITH THOSE BATTERIES AND SAID THEY COULDN'T GET A RESIVOIR FOR 3 DAYS. WE ARE TRAVELING AND STOPPED HERE IN LEBANON TN FOR THE WEEKEND. I HAVE MANY MORE PICTURES, BUT THEY ARE TOO LARGE TO ADD.
NHTSA ODI #11364847
59,567 miles · Jun 16, 2020
Electrical System
WHEN STARTING AND DRIVING THE VEHICLE THE INFOTAINMENT SYSTEM DOESN'T COMPLETELY BOOT UP. IT IS ACRATIC AND HAPPEN MORE THEN 50% OF THE TIME THEN OPERATING THE VEHICLE. THIS AFFECTS ALL AUDIO IN THE VEHICLE, WHICH INCLUDES TURN SIGNALS AUDIO, FLASHERS AUDIO, HANDS FREE VOICE RECOGNITION (GIVING & HEARING VOICE COMMAND), RECEIVI…
Read full complaint
WHEN STARTING AND DRIVING THE VEHICLE THE INFOTAINMENT SYSTEM DOESN'T COMPLETELY BOOT UP. IT IS ACRATIC AND HAPPEN MORE THEN 50% OF THE TIME THEN OPERATING THE VEHICLE. THIS AFFECTS ALL AUDIO IN THE VEHICLE, WHICH INCLUDES TURN SIGNALS AUDIO, FLASHERS AUDIO, HANDS FREE VOICE RECOGNITION (GIVING & HEARING VOICE COMMAND), RECEIVING CALLS VIA BLUE TOOTH, CALLING VIA BLUETOOTH, VOICE COMMANDS CALLING ONSTAR, RECEIVING ONSTAR CALLS AND THIS INCLUDES ALL MEDIA CD RADIO ETC. THIS MAKES THIS VEHICLE UNSAFE BECAUSE OF THE FOLLOWING: UNABLE TO HEAR TURNS SIGNALS, UNABLE TO USE HAND FREE BLUETOOTH WHEN RECEIVING AND MAKING CALLS INCLUDING 911 AND ONSTAR. *TR
NHTSA ODI #11329275
44,000 miles · Dec 14, 2019
Electrical System
T TRUCK SHUTS OFF WILE DRIVING MAKING ME LOSE ALL POWER STEERING AND POWER BRAKES. THIS HAPPENS WILE DRIVING. GM KNOWES THERE IS A PROBLEM , THEY ALLREADY BUILT A REPLACEMENT PART.
NHTSA ODI #11288988
35,000 miles · Nov 22, 2019
Electrical System
TL* THE CONTACT OWNS A 2015 CHEVROLET SILVERADO 2500. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE LOST POWER AND PROCEEDED TO ROLL OUT OF CONTROL. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO RELIABLE CHEVROLET (972-201-9240, LOCATED AT 800 N. CENTRAL EXPY, RICHARDSON, TX 75080), BUT THE CAUSE OF THE F…
Read full complaint
TL* THE CONTACT OWNS A 2015 CHEVROLET SILVERADO 2500. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE LOST POWER AND PROCEEDED TO ROLL OUT OF CONTROL. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO RELIABLE CHEVROLET (972-201-9240, LOCATED AT 800 N. CENTRAL EXPY, RICHARDSON, TX 75080), BUT THE CAUSE OF THE FAILURE COULD NOT BE DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE PERFORMED AS EXPECTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 35,000.
NHTSA ODI #11281746
40,000 miles · Feb 27, 2019
Electrical SystemEngineFire
TRUCK WAS PARKED AND TURNED OFF, A FIRE STARTED UNDER HOOD CAUSING DAMAGE TO ENGINE COMPARTMENT, USAA INSURANCE NOTIFIED, TRUCK TAKEN TO MASTER GMC IN AUGUSTA GA, AROUND 40,000 MILES AND ALL STOCK NO MODIFICATIONS MADE
NHTSA ODI #11182862
68,000 miles · Dec 13, 2018
Electrical System
WHEN LIFTING THE SNOWPLOW, RANDOMLY THE DASHBOARD CLUSTER AND RADIO SYSTEM WILL GO BLANK. GM HAS ADMITTED TO THIS FLAW IN THEIR 1500 MODEL FOR THE SAME YEAR TRUCK, HAS OFFERED A FIX AT THEIR EXPENSE, HOWEVER WILL NOT OFFER THE SAME FIX FOR THE 2500 MODEL, EVEN THOUGH IT HAS THE EXACT SAME ISSUE. (GM BULLETIN ATTACHED FOR 1500 …
Read full complaint
WHEN LIFTING THE SNOWPLOW, RANDOMLY THE DASHBOARD CLUSTER AND RADIO SYSTEM WILL GO BLANK. GM HAS ADMITTED TO THIS FLAW IN THEIR 1500 MODEL FOR THE SAME YEAR TRUCK, HAS OFFERED A FIX AT THEIR EXPENSE, HOWEVER WILL NOT OFFER THE SAME FIX FOR THE 2500 MODEL, EVEN THOUGH IT HAS THE EXACT SAME ISSUE. (GM BULLETIN ATTACHED FOR 1500 MODEL). I SPOKE TO A MCKAYLA (SUPERVISOR) IN THE WARRANTY DEPARTMENT. SHE SAID GM WILL NOT COVER IT AND IT IS AN OUT OF POCKET EXPENSE. SHE FURTHER STATED IF AT A TIME GM DECIDES IT IS A FAULT OF THEIRS IN THE FUTURE, I WOULD AT THAT TIME BE REIMBURSED. I HAVE INCLUDED THE DEALER REPAIR SLIP THAT SHOWS HARNESS NEEDED REPLACEMENT AND THE COST OF REPAIR.
NHTSA ODI #11161137
60,000 miles · Oct 2, 2018
Electrical SystemService Brakes
WINDSHIELD WIPERS INTERMINGLING TO THE POINT I HAVE TO PUT THE FUSE OUT OF THE FUSE BOX TO GET THEM TO SHUT OFF EVEN WHEN THE VEHICLE IS SHUT OFF WHILE INTERMINTING NO HIGH BEAMS WILL WORK UNLESS YOU HOLD THE WIPER/TURN SIGNAL LEVER FORWARD. SO TO USE WINDSHIELD WIPER I HAVE TO PUT THE FUSE IN TDUSE BOX THEN PUT IT OUT WHEN I'…
Read full complaint
WINDSHIELD WIPERS INTERMINGLING TO THE POINT I HAVE TO PUT THE FUSE OUT OF THE FUSE BOX TO GET THEM TO SHUT OFF EVEN WHEN THE VEHICLE IS SHUT OFF WHILE INTERMINTING NO HIGH BEAMS WILL WORK UNLESS YOU HOLD THE WIPER/TURN SIGNAL LEVER FORWARD. SO TO USE WINDSHIELD WIPER I HAVE TO PUT THE FUSE IN TDUSE BOX THEN PUT IT OUT WHEN I'M AT MY DESTINATION. WHILE THE WIPERS ARE INTERMINTING THE TRAILER BREAK SERVICE INDACTER DING AND KEEP POPPING UP ON THE SERVICE SCREEN SAYING EITHER SERVICE OR IT JUST POP UP TRAILER BREAK INDACTER AS IF I PUT THE TRAILER BOTTOM TO ADD MORE BREAK NO TRAILER IS ATTACHED WHEN THIS IS HAPPENING DRIVING DOWN THE ROAD IT JUST KEEP DING OR POPING UP ON THE SCREEN
NHTSA ODI #11132865
Official recalls
6Jul 1, 2021
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Interim owner notification letters informing owners of the safety risk were mailed on August 18, 2021. Owners will receive a second notice when the remedy is available. Phase I owner notification letters were mailed on May 5, 2022. Phase II owner notification letters are expected to be mailed on May 31, 2022. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. This recall supersedes NHTSA recall number 20V-736. GM's number for this recall is N202324251.
Nov 25, 2020
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500 and Chevrolet Silverado 1500 and 2015 GMC Sierra 2500 and 3500, and Chevrolet Silverado 2500 and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator.
Consequence & remedy
Consequence: If the end cap separates from the inflator, the compressed gas will escape and the end cap can be propelled into the vehicle, increasing the risk of injury or a crash.
Remedy: GM will notify owners, and dealers will replace the RRAB modules on the left and/or right side, free of charge. Interim owner notification letters were mailed on December 22, 2020. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. Note: GM filed a new recall, number 21V-504 that supersedes this recall. All vehicles previously recalled under 20V-736 will now be repaired under the new recall number 21V-504. GM's numbers for this recall are N202309680, N202309681, and N202309682.
Aug 30, 2018
General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 2500, 3500, 1500 Crew Cab Special Service, Tahoe Police Pursuit/Special Service, GMC Sierra 2500, and 3500 vehicles. The brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Consequence & remedy
Consequence: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Remedy: GM will notify owners, and dealers will add adhesive to the nut and reinstall the nut with increased tightness, free of charge. The recall began October 3, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18278. Note: The vehicles in this recall need this additional remedy despite being covered by recall 16V069 for brake pedal loosening.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Feb 5, 2016
General Motors LLC (GM) is recalling certain model year 2015-2016 Chevrolet Silverado 1500, 2500, and 3500 heavy duty trucks manufactured October 1, 2013, to February 1, 2016, 2015-2016 Chevrolet Tahoe Police Pursuit Vehicles (PPV) manufactured March 1, 2014, to February 1, 2016, and 2015-2016 GMC Sierra 2500 and 3500 heavy duty trucks manufactured October 29, 2013, to February 1, 2016. On the affected vehicles, the brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Consequence & remedy
Consequence: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Remedy: GM will notify owners, and dealers will add adhesive to the brake pedal pivot nut and reinstall with an increased torque, free of charge. The recall began on March 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 20760.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration