2003 Chevrolet Silverado 2500

TL*- THE CONTACT OWNS A 2003 CHEVROLET SILVERADO K2500HD. THE CONTACT STATED THAT CORROSION IN THE BREAK LINE OF HIS VEHICLE CAUSED BREAK FLUID LEAKAGE. BREAK FAILURE INCREASES THE RISK OF VEHICLE CRASH. HE IS IN THE PROCESS OF TAKING THE VEHICLE TO THE DEALER FOR INSPECTION. HE FILED A COMPLAINT WITH THE MANUFACTURER.THE CURRENT AND FAILURE MILEAGES WERE 80,000.

THE ANTI-LOCK BRAKES ACTIVATE AT LOW SPEEDS WHEN THE BRAKES ARE APPLIED, WHICH INCREASES THE STOPPING DISTANCE. THIS HAPPENS ABOUT HALF THE TIME THAT I BRAKE AND AT OTHER TIMES THE BRAKES OPERATE NORMALLY. YOU HAVE TO ASSUME THAT THE ANTI-LOCK BRAKES ARE GOING TO KICK IN EACH TIME THAT YOU APPLY THE BRAKES TO AVOID HITTING ANOTHER CAR IN THE REAR OR GOING INTO AN INTERSECTION. *TR

2003 CHEVROLET SILVERADO 2500HD, 6.0 4WD LS. CURRENT MILEAGE: 94,000 MILES. VEHICLE IS WELL OUT OF WARRANTY. IN IOWA. 1ST OWNER. BRAKE FAILURE OR REALLY SPONGY BRAKES. REQUIRES MULTIPLE PEDAL PUMPS TO SLOW VEHICLE DOWN OR APPLYING BRAKE PEDAL TO THE FLOOR TO STOP AT STOP SIGN IN CITY DRIVING. I REMOVED THE FRONT TIRES AND INSPECTED THE PADS AND ROTORS. FRONT PADS HAD 75%+ MATERIAL ON THEM. THE INSIDE OF EACH ROTOR HAD 50% CONTACT SURFACE ON THEM. I TOOK THEM INTO O'REILLYS IN COUNCIL BLUFFS, IOWA WHERE THEY TURNED THEM DOWN ENOUGH TO CLEAN UP BOTH SIDES OF ROTORS. ROTOR WERE RUSTING AND FLAKING. I HAVE NOT INSPECTED REAR ROTORS OR PADS AS OF YET. WAS TOLD BY TECHNICIAN THAT CHEVROLET HAD PROBLEMS WITH ROTOR. AFTER REPLACING TURNED ROTOR AND INSTALLING NEW PADS BRAKES GO UNCHANGED. INSPECTION OF REAR ROTORS AND PADS WILL OCCUR 22 JUNE 2009. WITH NUMEROUS COMPLAINTS CONCERNING A MAJOR SAFETY ISSUE, GM/CHEVROLET SHOULD INVEST IN DEALING WITH CORRECTING THIS ISSUE TO AVOID LOSING THEIR LOYAL CUSTOMERS. I UNDERSTAND THAT A FEW HERE AND THERE, BUT WHEN MULTIPLE CHEVY SITE SAY THE EXACT SAME THING....HOW MANY OF US SILVERADO OWNERS HAVEN'T POSTED ON HERE??? I LOVE MY SILVERADO AND WILL TRY TO KEEP IT UNTIL THE WHEELS FALL OFF...OK WRONG CHOICE OF WORDS....BUT IF THERE IS A MEANS TO CORRECT THIS, WHETHER IF IT IS ON THE 1500 TO THE 3500HD, ESPECIALLY BRAKE SYSTEM, GM/CHEVROLET NEEDS TO ROGER UP AND FIX THIS! HAVING BRAKES ARE IMPORTANT, UNLESS YOUR A CRASH TEST DUMMY!!!! *TR

TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. THE CONTACT STARTED THE VEHICLE AND NOTICED THAT THE ABS LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. HE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE ABS ELECTRONIC BRAIN FAILED. THE REPAIR COST WAS QUOTED AT $1,300. THE FAILURE MILEAGE WAS 83,000 AND CURRENT MILEAGE WAS 83,400. UPDATED 05/26/09 *BF UPDATED 05/28/09.*JB

ON MY 2003 CHEVY SILVERADO 2500HD WITH VORTEC 8100 (496 IN3) ENGINE, THE POWER STEERING PUMP ALSO ACTS AS THE POWER SOURCE FOR THE BRAKE BOOSTER (I BELIEVE). THUS, MANY TIMES WHEN I HAVE MY FOOT ON THE BRAKE THERE'S A PARTIAL LOSS OF POWER STEERING. IN ORDER TO FULLY REGAIN THE POWER STEERING, I HAVE TO LET MY FOOT UP OFF THE BRAKE PEDAL. THIS POWER-STEERING-PUMP-AS-BRAKE-BOOSTER SET-UP IS UNIQUE TO THIS ENGINE. SO FAR, I HAVE BEEN ABLE TO GET BY WITHOUT EXPERIENCING A CRITICAL SITUATION. THE LOSS OF POWER STEERING WAS WORSE BEFORE I REPLACED THE SERPENTINE BELT TWO YEARS AGO (<10,000 MILES). I HAD GOODYEAR INSTALL A HIGH-QUALITY BELT THEY MANUFACTURE THEMSELVES. COLD WEATHER START-UP CONDITIONS ARE THE WORSE; THUS IN COLD WEATHER I PREFER TO LET THE ENGINE WARM UP TO ELIMINATE THE POTENTIAL FOR LOSS OF POWER STEERING. I JUST THINK THAT OWNERS OF THIS VEHICLE (WITH THE 8100 ENGINE) SHOULD BE FULLY AWARE OF THIS PROBLEM. *TR

TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT THE TRANSFER CASE WAS DESIGNED WITH A DEFECT. AS A RESULT, THE PUMP IN THE TRANSFER CASE WORE A HOLE FROM THE INSIDE TO THE OUTSIDE OF THE TRANSFER CASE. THIS ALLOWED THE OIL IN THE TRANSFER CASE TO PUMP OUT THE HOLE AND CAUSED THE TRANSFER CASE TO RUN DRIVE. THE DEALER STATED THAT THE VEHICLE WAS OUT OF WARRANTY AND THE CONTACT WOULD HAVE TO PAY FOR THE REPAIR. THE FAILURE MILEAGE WAS 130,000. UPDATED 3/16/09 *CN THE POWER STEERING STARTED LEAKING FLUID. THE DEALER INFORMED THE CONSUMER THE POWER STEERING FLUID LEAK WAS COMING FROM THE HYDRO BOOSTER ONTO THE POWER STEERING GEAR. THE CONSUMER LOST HIS BRAKES. IT WAS DISCOVERED THE BOOSTER ROD WAS MISSING. THE PARKING BRAKE DID NOT WORK AND THE INSTRUMENT CLUSTER FAILED AS WELL. THE SPEEDOMETER DID NOT WORK IT WAS READING 60 MPH EVEN WHEN THE VEHICLE WAS PARKED. UPDATED 03/18/09. *JB

2003 CHEVY SILVERADO TRUCK. BRAKE ROTORS ROTTED AND RUSTED AND REPLACED AT 9,000 MILES AND 3 YEARS OLD. VERY DANGEROUS SITUATION. AT 5 YEARS OLD AND 13,000 MILES ALL BRAKE LINES RUSTED AND FAILED ALMOST LEADING TO A CRASH. BOTH REPAIRS VERY COSTLY. TRUCK IS A HUNK OF JUNK, I WANT TO SELL IT BUT FEEL BAD STICKING THE NEXT GUY WITH THIS JUNK. SOMETHING SHOULD BE DONE. *TR

BRAKE LINES RUPTURED CAUSING FAILURE OF BRAKING SYSTEM ON MY 2003 CHEVROLET SILVERADO 2500HD. THIS TRUCK HAS ONLY 45,000 MILES ON IT. CHEVROLET TOLD ME THAT THIS WAS NORMAL WEAR. I THEN ASKED THEM IF IT WAS NORMAL FOR A PERSON WHO BOUGHT ONE OF THEIR VEHICLES TO EXPECT A LIFE ENDANGERING SITUATION AFTER ONLY 45,000 MILES, AND THEY SAID YES. THIS IS ON TAPE, AS THEY ASKED ME IF THEY COULD TAPE MY PHONE CALL, AND I AGREED. *TR

TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. WHILE DRIVING AT ANY SPEED, THE BRAKE PEDAL WOULD PULSATE. THE DEALER STATED THAT ALL OF THE BRAKES, ABS SENSORS, FRONT AND REAR ROTORS, AND FRONT WHEEL BEARINGS NEEDED TO BE REPLACED. IN ADDITION, THE BRAKE LINE AND TRANSMISSION NEEDED TO BE FLUSHED. THE CURRENT MILEAGE WAS 36,400 AND FAILURE MILEAGE WAS 35,700.

INFERIOR BRAKE PERFORMANCE OF CHEVY. 2500 TRUCKS. THE BRAKES ARE INADEQUATE AND WEAR OUT PRE-MATURELY, CAUSING UN-SAFE BRAKING PERFORMANCE. CONTACTED G.M. CUSTOMER SERVICE AND THEY AGREED TO TAKE CARE OF PROBLEM: WHICH WAS APPROVED AND DENIED TWICE. CONTACTED AREA DISTRICT SERVICE REP FOR G.M. AND HE ALSO DENIED A PROBLEM WITH BRAKES. SPOKE WITH DEALER SERVICE MANAGER AND HE SAID IT IS AN ONGOING PROBLEM WITH G.M. BRAKES; THE MANUFACTURE WILL NOT ADMIT A DEFECT IN INFERIOR BRAKE QUALITY. THE BRAKES DEGRADE GRADUALLY, WITH VERY FEW MILES: 15,000- 20,000 MILES. *TR