IllustrationWHILE DRIVING O RINGS BLEW OUT, CAUSING LOSS OF STEERING AND BRAKES.*AK
2002 Chevrolet Silverado 2500
Owner reports · Recalls · Investigations
More warning signs than most Silverado 2500 years
Owner complaints for the 2002 Chevrolet Silverado 2500 are substantially higher than the model-year median of 81.
About this comparison →How this year compares
Owner complaints by model year
Compare all Silverado 2500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
4325–50K
7450–75K
6175–100K
72100–150K
42150K+
307 reports with mileage · 44 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 117 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 88 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
21 crash reports6 fire reports7 injury reports
Fuel System, Gasoline complaints
12 reportsPURCHASED VEHICLE 8-25-01- BRAKES WHERE UNALBE TO STOP VEHICLE. *AK
Official recalls
101V220000 · Interior Lighting
Jun 26, 2001
VEHICLE DESCRIPTION: CERTAIN PICKUP TRUCKS EQUIPPED WITH 6.6L DIESEL ENGINES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THESE VEHICLES HAVE A BRAKE SYSTEM WARNING LIGHT IN THE INSTRUMENT CLUSTER THAT MAY NOT ILLUMINATE WHEN THE BRAKE FLUID IS LOW. IN ADDITION, WHEN THE BRAKE FLUID IS LOW, THE VEHICLE MAY NOT MEET THE PARTIAL SYSTEM REQUIREMENTS OF FMVSS NO. 105.
Consequence & remedy
Consequence: THESE CONDITIONS COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD LEAD TO A CRASH.
Remedy: DEALERS WILL CHANGE THE LOCATION OF A WIRE CONNECTION IN THE UNDERHOOD BUSSED ELECTRICAL CENTER. OWNER NOTIFICATION BEGAN JULY 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA07013 · Trailer Hitch Receiver Failure
Opened Sep 14, 2007 · Closed Sep 12, 2008
Status: closed (inferred from source dates) · Trailer Hitches
COMPLAINT REPORTS ALLEGE POOR WELD QUALITY AND/OR BENDING OF THE SUBJECT VEHICLE ORIGINAL EQUIPMENT TRAILER HITCH RECEIVER.THE AGENCY'S INVESTIGATION INCLUDED ANALYSIS OF MANUFACTURER AND AGENCY INCIDENT REPORTS, REVIEW OF POLICE REPORTS, ANALYSIS OF THE AGENCY'S FATAL ANALYSIS REPORTING SYSTEM, A VEHICLE OWNER SURVEY, INSPECTION OF TOW VEHICLES/HITCHES AND ANALYSIS OF FAILED PARTS.INCIDENTS OF WELD FAILURE WERE RARE AND ASSOCIATED WITH VERY LOW-SPEED DRIVING (TURNING, BACKING AND SUDDEN STOPPING).INCIDENTS OF BENDING WERE ASSOCIATED WITH IMPROPER TRAILER HITCH ADJUSTMENT OR OVERLOADING. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT SEARCH FILE FOR ADDITION INFORMATION.
PE07025 · Trailer Hitch Receiver Failure
Opened May 14, 2007 · Closed Sep 14, 2007
Status: closed (inferred from source dates) · Trailer Hitches
GM PROVIDED ADDITIONAL DATA REGARDING ALLEGATIONS OF FAILURE OF THE TRAILER HITCH.ODI REVIEWED THAT AS WELL AS OTHER DATA PROVIDED BY PEER MANUFACTURERS.BASED ON OUR REVIEW, ODI FINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.THIS PRELIMINARY EVALUATION IS UPGRADED TO AN ENGINEERING ANALYSIS (EA07-013) FOR FURTHER ASSESSMENT AND STUDY OF THIS ISSUE.
EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
PE04004 · Hydraulic Pump Shaft Failures
Opened Jan 8, 2004 · Closed Apr 30, 2004
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Additional source detail variants (5)
Service Brakes, Hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist:hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist System
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.