Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
270–25K
3725–50K
5550–75K
5275–100K
53100–150K
31150K+
255 reports with mileage · 45 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports3 fire reports4 injury reports
What owners actually said
300 reports
26,120 miles · Oct 2, 2003
Engine And Engine Cooling
ENGINE KNOCKS ON STARTUP AND WHEN WARM, WHICH SOUNDS LIKE THAT OF THE LIFTER. CONSUMER WENT TO THE DEALER AND WAS TOLD THAT THIS IS NORMAL. IT'S HARD TO THINK THAT GM WOULD MAKE A GAS ENGINE TO MAKE THIS KIND OF NOISE. THE NEW 6.0 DON'T MAKE THIS TYPE OF NOISE ON START UP. I FOUND OUT FROM THE DEALER THAT THE OLDER 6.0 HAVE …
Read full complaint
ENGINE KNOCKS ON STARTUP AND WHEN WARM, WHICH SOUNDS LIKE THAT OF THE LIFTER. CONSUMER WENT TO THE DEALER AND WAS TOLD THAT THIS IS NORMAL. IT'S HARD TO THINK THAT GM WOULD MAKE A GAS ENGINE TO MAKE THIS KIND OF NOISE. THE NEW 6.0 DON'T MAKE THIS TYPE OF NOISE ON START UP. I FOUND OUT FROM THE DEALER THAT THE OLDER 6.0 HAVE MADE THIS KIND OF NOISE. GM PULLED THE ENGINES FOR INSPECTION. IT SEEMS LIKE THEY FOUND THE PROBLEM AND FIXED IT ON THE NEW MODELS AND WON'T FIX THE MISTAKE OF THE OLD ONES. *LA
NHTSA ODI #10041136
9,167 miles · Sep 17, 2003
Visibility
THE DRIVER AND PASSENGER SIDE REAR VIEW WINDOW DEVELOPED STREAKS THAT WERE VERY DISTRACTING. THE DRIVER SAID THE STREAKS WERE LETTING OFF FALSE IMAGES. PLEASE DESCRIBE FURTHER. *NLM
NHTSA ODI #10040123
Mileage unknown · Aug 28, 2003
Tires
I HAVE MY CHEVY 2500HD IN TO CHECK ALL 4 FIRESTONE STEELTEX AT OEM TIRES BECAUSE OF SIDEWALL SEPARATION CONCERN. I HAVE 26,000 MILES ON THESE TIRES AND ALL ARE CONSISTENT MAYBE BECAUSE OF RECOMMENDED TIRE ROTATIONS. I HOPE I DON'T HAVE TO FOLLOW UP ON THIS PROBLEM FOR A RESOLUTION AFTER THE VISIT TO THE DEALER TODAY.
NHTSA ODI #10036744
22,200 miles · Aug 26, 2003
Vehicle Speed Control
ENGINE IDLE INCREASES TO 2000- 5300 RPM WHEN STOPPED OR SLOWING WITH FOOT ON BRAKE PEDAL. IDLE SOMETIMES RETURNS TO NORMAL BY ITS SELF OR MAY REQUIRE SHUTTING OFF AND RESTARTING ENGINE. *NLM
NHTSA ODI #10033518
39,000 miles · Aug 19, 2003
Engine And Engine Cooling
TURCK ENGINE HAS A KNOCK THAT I WAS TOLD BY THE DEALER AND GM THAT IT WAS SIMPLY A COLD START KNOCK. HOWEVER, I WAS TOLD BY A PERSONAL FRIEND AT THE GM TECH CENTER THAT IT IS REALLY A PISTON SLAP, AND IS A RESULT OF THE PISTONS BEING TOO SMALL FOR THE BORE WHICH COULD LEAD TO ENGINE SEIZURE/FAILURE, AND THAT GM IS AWARE OF IT! …
Read full complaint
TURCK ENGINE HAS A KNOCK THAT I WAS TOLD BY THE DEALER AND GM THAT IT WAS SIMPLY A COLD START KNOCK. HOWEVER, I WAS TOLD BY A PERSONAL FRIEND AT THE GM TECH CENTER THAT IT IS REALLY A PISTON SLAP, AND IS A RESULT OF THE PISTONS BEING TOO SMALL FOR THE BORE WHICH COULD LEAD TO ENGINE SEIZURE/FAILURE, AND THAT GM IS AWARE OF IT! THE TRUCK KNOCKS EVEN WHEN ENGINE IS WARM. I HAVE BEGGED FOR A REPAIR UNDER THE TRUCKS WARRANTY BUT HAVE BEEN DENIED. I AM CONCERNED THAT AT SOME POINT THE ENGINE COULD SEIZE AND CAUSE A SERIOUS ACCIDENT AND HARM TO MYSELF AND OTHERS. GM SEEMS TO THINK IF THEY PRETEND IT IS A DIFFERENT PROBLEM, AND IF THEY CROSS THEIR FINGERS THEY WILL SAVE MONEY AND AVOID A RECALL. THE DEALER INDICATED TO ME THAT THEY KNOW WHAT THE PROBLEM IS AND SO DOES GM BUT THERE IS NOTHING THEY CAN DO FOR ME. AT ONE POINT GM WAS OFFERING TO EXTEND MY WARRANTY BUT RENIGD BECAUSE I WAS THE SECOND OWNER, EVEN THOUGH I PAID FOR THEIR EXTENDED WARRANTY. PLEASE INVESTIGATE BEFORE SOMEONE OWNING ONE OF THESE TRUCKS DOES HAVE THE ENGINE SIEZE AND INNOCENT PEOPLE ARE HURT! INCIDENT DATE IS APPROXIMATE AS I HAVE TAKEN THE TRUCK TO THE DEALER MANY TIMES ON MANY DATES IN HOPES OF GETTING THIS PROBLEM FIXED BECAUSE THEY WANT ME TO GO AWAY. *AK
NHTSA ODI #10033144
Mileage unknown · Jul 24, 2003
Tires
WHILE DRIVING THE LEFT REAR TIRE EXPERIENCED TREAD SEPARATION WHILE TRAVELING 70MPH ON THE HIGHWAY, CAUSING DAMAGE TO THE LEFT REAR FENDER.TIRE INFORMATION:FIRESTONE, STEELTEX R4S,R45/75R16, 28000 MILES ON TIRES. *AK ORIGINAL LEFT REAR
NHTSA ODI #10030133
Mileage unknown · Jul 12, 2003
Tires
REAR PASSENGER TREAD DELAMINATED FROM TIRE WHILE TRAVELING AT SPEED LIMIT ON FREEWAY. VEHICLE PULLED OVER TO SIDE OF ROAD. THE TIRE WAS COMPLETELY INFLATED...JUST THE TREAT HAD SEPERATED FROM TIRE CAUSING MAJOR DAMAGE TO VEHICLE. HAD NOT RUN OVER ANYTHING IN ROADWAY TO CAUSE THIS EVENT.....LOOKED UP ROAD AND FOUND SAFER AND WI…
Read full complaint
REAR PASSENGER TREAD DELAMINATED FROM TIRE WHILE TRAVELING AT SPEED LIMIT ON FREEWAY. VEHICLE PULLED OVER TO SIDE OF ROAD. THE TIRE WAS COMPLETELY INFLATED...JUST THE TREAT HAD SEPERATED FROM TIRE CAUSING MAJOR DAMAGE TO VEHICLE. HAD NOT RUN OVER ANYTHING IN ROADWAY TO CAUSE THIS EVENT.....LOOKED UP ROAD AND FOUND SAFER AND WIDER SPOT TO CHANGE TIRE....IN PROCESS OF SLOWLY APPROACHING OTHER AREA.....TIRE EXPLODED. TIRE WAS NOT AT HOT TEMPERATURE. THIS APPEARS TO BE A TIRE DEFECT.*AK
NHTSA ODI #10025929
10,000 miles · May 4, 2003
Engine And Engine Cooling
ENGINE USES OIL AND KNOCKS. *JB
NHTSA ODI #10016986
19,468 miles · Mar 10, 2003
Fuel System, Diesel
FUEL BLEW INTO THE ENGINE, WHICH COULD HAVE RESULTED IN A FIRE.*JB
NHTSA ODI #10011184
9,000 miles · Feb 12, 2003
Power Train
REAR END NOISE CLUNK/BANG IN OFF HIWAY USE DEALER STATES OPERATES AS DESIGNED TAKEN TRUCK IN 3 TIMES NO RESOLVE CONCERNED WITH RELIABILTY
NHTSA ODI #10005772
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA06016 · Crank Position Sensor Failure - Stall
Opened Sep 14, 2006 · Closed Nov 9, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine
IN A LETTER DATED NOVEMBER 7, 2007, GENERAL MOTORS (GM) REPORTED TO THE OFFICE OF DEFECTS INVESTIGATION (ODI) THAT IT WILL CONDUCT A SAFETY RECALL (07V-521) TO REPLACE THE CRANK POSITION SENSOR (CKP) IN APPROXIMATELY 12,000 MODEL YEAR (MY) 2001 CHEVROLET SILVERADO AND GMC SIERRA VEHICLES EQUIPPED WITH 8.1 LITER ENGINES MANUFACTURED ON OR BEFORE NOVEMBER 15, 2000.ACCORDING TO GM, THE CKP CAN FAIL INTERMITTENTLY OR PERMANENTLY.A PERMANENT CKP FAILURE WOULD RESULT IN AN ENGINE STALL WITHOUT RESTART.AN INTERMITTENT CKP FAILURE COULD CAUSE THE SERVICE ENGINE SOON LIGHT TO ILLUMINATE, THE VEHICLE TO RUN ROUGH OR THE ENGINE TO STALL BUT ALLOWS RESTART.AS A REMEDY, AN IMPROVED CKP WILL BE INSTALLED IN THE SUBJECT VEHICLES.THE RECALL CAMPAIGN WILL START IN DECEMBER 2007. DURING THE PRELIMINARY EVALUATION (PE06-016), AND THIS EA INVESTIGATION, GM AND ODI INDEPENDENTLY CONDUCTED DETAILED REVIEWS OF CERTAIN FIELD DATA TO UNDERSTAND THE NATURE AND RATE OF SUBJECT VEHICLE STALLING DUE TO CKP FAILURES.GM AND ODI REVIEWED GM'S WARRANTY CLAIMS FOR THE CKP WITH THE OBJECTIVE OF ASCERTAINING AN ESTIMATE OF THOSE CLAIMS REPRESENTING AN ENGINE STALL WHILE DRIVING.THE CKP WARRANTY CLAIMS WITHOUT VERBATIM TEXT WERE THE LARGEST SEGMENT OF WARRANTY CLAIMS.USING THOSE CLAIMS, GM SURVEYED VEHICLE OWNERS TO GATHER ADDITIONAL INFORMATION TO DETERMINE IF THE CLAIM WAS ASSOCIATED WITH A STALL WHILE DRIVING EVENT.BASED ON THE SURVEY, GM ESTIMATED THAT APPROXIMATELY 49% OF ALL WARRANTY REPAIRS FOR THE CKP INVOLVED A STALL WHILE DRIVING.ODI?S REVIEW OF GM'S SURVEY DATA PRODUCED A HIGHER ESTIMATE (71%) FOR STALL WHILE DRIVING.GM FURTHER ESTIMATED THE RATE OF STALL WHILE DRIVING FOR THE SUBJECT VEHICLES OVER TIME.IT ESTIMATED STALLING WHILE DRIVING RATES OF 1.6%, 4.6% AND 8.9% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY.ODI'S REVIEW OF THE GM'S SURVEY DATA FINDS HIGHER ESTIMATED STALL WHILE DRIVING RATES OF 2.2%, 6.8% AND 13% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY. ODI ALSO CONDUCTED A SURVEY OF VEHICLE OWNERS USING CONSUMER COMPLAINTS REPORTED TO BOTH ODI AND GM.THE OBJECTIVE WAS TO ASCERTAIN THE POTENTIAL SAFETY CONSEQUENCES OF AN ENGINE STALL DUE TO THE ALLEGED DEFECT.WITH RESPECT TO THE ABILITY TO RESTART THE VEHICLE AFTER A STALL, 11% REPORTED IMMEDIATE RESTART, 69% REPORTED DELAYED RESTART AND 20% REPORTED NO RESTART.OVER HALF NOTED AT LEAST ONE ENGINE STALL INCIDENT AT SPEEDS IN EXCESS OF 40MPH. ABOUT ONE-THIRD NOTED THE VEHICLE WAS STRANDED EITHER PARTIALLY OR FULLY IN A LANE OF TRAFFIC AFTER THE ENGINE STALL.ALL OF THE CONSUMERS SURVEYED NOTED MULTIPLE STALLING EVENTS PRIOR TO PROPER DIAGNOSIS AND REPLACEMENT OF THE CKP.BASED ON GM'S DECISION TO CONDUCT A SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Engine And Engine Cooling:engine
IN A LETTER DATED NOVEMBER 7, 2007, GENERAL MOTORS (GM) REPORTED TO THE OFFICE OF DEFECTS INVESTIGATION (ODI) THAT IT WILL CONDUCT A SAFETY RECALL (07V-521) TO REPLACE THE CRANK POSITION SENSOR (CKP) IN APPROXIMATELY 12,000 MODEL YEAR (MY) 2001 CHEVROLET SILVERADO AND GMC SIERRA VEHICLES EQUIPPED WITH 8.1 LITER ENGINES MANUFACTURED ON OR BEFORE NOVEMBER 15, 2000.ACCORDING TO GM, THE CKP CAN FAIL INTERMITTENTLY OR PERMANENTLY.A PERMANENT CKP FAILURE WOULD RESULT IN AN ENGINE STALL WITHOUT RESTART.AN INTERMITTENT CKP FAILURE COULD CAUSE THE SERVICE ENGINE SOON LIGHT TO ILLUMINATE, THE VEHICLE TO RUN ROUGH OR THE ENGINE TO STALL BUT ALLOWS RESTART.AS A REMEDY, AN IMPROVED CKP WILL BE INSTALLED IN THE SUBJECT VEHICLES.THE RECALL CAMPAIGN WILL START IN DECEMBER 2007. DURING THE PRELIMINARY EVALUATION (PE06-016), AND THIS EA INVESTIGATION, GM AND ODI INDEPENDENTLY CONDUCTED DETAILED REVIEWS OF CERTAIN FIELD DATA TO UNDERSTAND THE NATURE AND RATE OF SUBJECT VEHICLE STALLING DUE TO CKP FAILURES.GM AND ODI REVIEWED GM'S WARRANTY CLAIMS FOR THE CKP WITH THE OBJECTIVE OF ASCERTAINING AN ESTIMATE OF THOSE CLAIMS REPRESENTING AN ENGINE STALL WHILE DRIVING.THE CKP WARRANTY CLAIMS WITHOUT VERBATIM TEXT WERE THE LARGEST SEGMENT OF WARRANTY CLAIMS.USING THOSE CLAIMS, GM SURVEYED VEHICLE OWNERS TO GATHER ADDITIONAL INFORMATION TO DETERMINE IF THE CLAIM WAS ASSOCIATED WITH A STALL WHILE DRIVING EVENT.BASED ON THE SURVEY, GM ESTIMATED THAT APPROXIMATELY 49% OF ALL WARRANTY REPAIRS FOR THE CKP INVOLVED A STALL WHILE DRIVING.ODI?S REVIEW OF GM'S SURVEY DATA PRODUCED A HIGHER ESTIMATE (71%) FOR STALL WHILE DRIVING.GM FURTHER ESTIMATED THE RATE OF STALL WHILE DRIVING FOR THE SUBJECT VEHICLES OVER TIME.IT ESTIMATED STALLING WHILE DRIVING RATES OF 1.6%, 4.6% AND 8.9% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY.ODI'S REVIEW OF THE GM'S SURVEY DATA FINDS HIGHER ESTIMATED STALL WHILE DRIVING RATES OF 2.2%, 6.8% AND 13% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY. ODI ALSO CONDUCTED A SURVEY OF VEHICLE OWNERS USING CONSUMER COMPLAINTS REPORTED TO BOTH ODI AND GM.THE OBJECTIVE WAS TO ASCERTAIN THE POTENTIAL SAFETY CONSEQUENCES OF AN ENGINE STALL DUE TO THE ALLEGED DEFECT.WITH RESPECT TO THE ABILITY TO RESTART THE VEHICLE AFTER A STALL, 11% REPORTED IMMEDIATE RESTART, 69% REPORTED DELAYED RESTART AND 20% REPORTED NO RESTART.OVER HALF NOTED AT LEAST ONE ENGINE STALL INCIDENT AT SPEEDS IN EXCESS OF 40MPH. ABOUT ONE-THIRD NOTED THE VEHICLE WAS STRANDED EITHER PARTIALLY OR FULLY IN A LANE OF TRAFFIC AFTER THE ENGINE STALL.ALL OF THE CONSUMERS SURVEYED NOTED MULTIPLE STALLING EVENTS PRIOR TO PROPER DIAGNOSIS AND REPLACEMENT OF THE CKP.BASED ON GM'S DECISION TO CONDUCT A SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
IN A LETTER DATED NOVEMBER 7, 2007, GENERAL MOTORS (GM) REPORTED TO THE OFFICE OF DEFECTS INVESTIGATION (ODI) THAT IT WILL CONDUCT A SAFETY RECALL (07V-521) TO REPLACE THE CRANK POSITION SENSOR (CKP) IN APPROXIMATELY 12,000 MODEL YEAR (MY) 2001 CHEVROLET SILVERADO AND GMC SIERRA VEHICLES EQUIPPED WITH 8.1 LITER ENGINES MANUFACTURED ON OR BEFORE NOVEMBER 15, 2000.ACCORDING TO GM, THE CKP CAN FAIL INTERMITTENTLY OR PERMANENTLY.A PERMANENT CKP FAILURE WOULD RESULT IN AN ENGINE STALL WITHOUT RESTART.AN INTERMITTENT CKP FAILURE COULD CAUSE THE SERVICE ENGINE SOON LIGHT TO ILLUMINATE, THE VEHICLE TO RUN ROUGH OR THE ENGINE TO STALL BUT ALLOWS RESTART.AS A REMEDY, AN IMPROVED CKP WILL BE INSTALLED IN THE SUBJECT VEHICLES.THE RECALL CAMPAIGN WILL START IN DECEMBER 2007. DURING THE PRELIMINARY EVALUATION (PE06-016), AND THIS EA INVESTIGATION, GM AND ODI INDEPENDENTLY CONDUCTED DETAILED REVIEWS OF CERTAIN FIELD DATA TO UNDERSTAND THE NATURE AND RATE OF SUBJECT VEHICLE STALLING DUE TO CKP FAILURES.GM AND ODI REVIEWED GM'S WARRANTY CLAIMS FOR THE CKP WITH THE OBJECTIVE OF ASCERTAINING AN ESTIMATE OF THOSE CLAIMS REPRESENTING AN ENGINE STALL WHILE DRIVING.THE CKP WARRANTY CLAIMS WITHOUT VERBATIM TEXT WERE THE LARGEST SEGMENT OF WARRANTY CLAIMS.USING THOSE CLAIMS, GM SURVEYED VEHICLE OWNERS TO GATHER ADDITIONAL INFORMATION TO DETERMINE IF THE CLAIM WAS ASSOCIATED WITH A STALL WHILE DRIVING EVENT.BASED ON THE SURVEY, GM ESTIMATED THAT APPROXIMATELY 49% OF ALL WARRANTY REPAIRS FOR THE CKP INVOLVED A STALL WHILE DRIVING.ODI?S REVIEW OF GM'S SURVEY DATA PRODUCED A HIGHER ESTIMATE (71%) FOR STALL WHILE DRIVING.GM FURTHER ESTIMATED THE RATE OF STALL WHILE DRIVING FOR THE SUBJECT VEHICLES OVER TIME.IT ESTIMATED STALLING WHILE DRIVING RATES OF 1.6%, 4.6% AND 8.9% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY.ODI'S REVIEW OF THE GM'S SURVEY DATA FINDS HIGHER ESTIMATED STALL WHILE DRIVING RATES OF 2.2%, 6.8% AND 13% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY. ODI ALSO CONDUCTED A SURVEY OF VEHICLE OWNERS USING CONSUMER COMPLAINTS REPORTED TO BOTH ODI AND GM.THE OBJECTIVE WAS TO ASCERTAIN THE POTENTIAL SAFETY CONSEQUENCES OF AN ENGINE STALL DUE TO THE ALLEGED DEFECT.WITH RESPECT TO THE ABILITY TO RESTART THE VEHICLE AFTER A STALL, 11% REPORTED IMMEDIATE RESTART, 69% REPORTED DELAYED RESTART AND 20% REPORTED NO RESTART.OVER HALF NOTED AT LEAST ONE ENGINE STALL INCIDENT AT SPEEDS IN EXCESS OF 40MPH. ABOUT ONE-THIRD NOTED THE VEHICLE WAS STRANDED EITHER PARTIALLY OR FULLY IN A LANE OF TRAFFIC AFTER THE ENGINE STALL.ALL OF THE CONSUMERS SURVEYED NOTED MULTIPLE STALLING EVENTS PRIOR TO PROPER DIAGNOSIS AND REPLACEMENT OF THE CKP.BASED ON GM'S DECISION TO CONDUCT A SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
PE04004 · Hydraulic Pump Shaft Failures
Opened Jan 8, 2004 · Closed Apr 30, 2004
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Additional source detail variants (5)
Service Brakes, Hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist:hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist System
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
2001 Chevrolet Silverado 2500 Problems, Complaints & Recalls | Skip That Year
Illustration