Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 50 of 373 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 145 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports6 fire reports2 injury reports
What owners actually said
373 reports
Mileage unknown · Apr 22, 2025
EnginePower Train
At 383 miles the engine started a ticking noise. Around the same mileage the transmission would also start make hard down shifts, especially into 1st gear. At around 27000 miles transmission would also shutter at light loads and low speeds. Attempted to take it to dealer 2 different times, but they had no loaner cars and needed …
Read full complaint
At 383 miles the engine started a ticking noise. Around the same mileage the transmission would also start make hard down shifts, especially into 1st gear. At around 27000 miles transmission would also shutter at light loads and low speeds. Attempted to take it to dealer 2 different times, but they had no loaner cars and needed it for more than a day. At milage 28,251 I drove to the dealership an insisted that it needed to be fixed. They were able to provide loaner car at that time. Engine ticking noise was cylinder number 7 lifter stuck closed. Transmission was unable to be checked due to engine needing repair. The Dealer replace all 8 lifters on drivers side of engine. Upon the fix they test drove for the transmission problem and noticed noise coming from the water pump. Replaced the water pump and was told transmission needed a new valve body. Those parts were on back order for over 3 months. They found a service bulletin to reprogram the transmission so they could release the truck to me instead of hold months for parts. After more than 30 days in shop picked up truck. After driving around for a few hours noticed engine noise again but different. Like a bearing? Dealer had already closed so took it back the next day. Couple days later was informed that the head gasket was installed wrong? REALLY. Went to the dealer's new car manager and asked to be traded out of it and into a new truck. Dealer offered me 10,000 below blue book for trade in! They didn't even want their own product back. Picked up truck couple days later and drove straight to Toyota and traded it in I needed a reliable truck. The dealer's service department was great with the problem. But it's the product that really [XXX] and had the potential to be very dangerous. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11656204
Mileage unknown · Apr 18, 2025
Power Train
Transmission shutters and shakes and dealer said it’s normal for the silverados to shake and shutter at highway speeds even though it’s brand new . and then got treated horribly for getting it towed in
NHTSA ODI #11655339
15,121 miles · Apr 15, 2025
Engine
The contact owns a 2023 Chevrolet Silverado 1500. The contact stated that while driving 45 MPH and depressing the accelerator pedal, the engine seized, and the vehicle lost all power. The contact stated that the vehicle was stuck in the right lane. The vehicle was towed to dealer, where it was diagnosed with engine failure. The …
Read full complaint
The contact owns a 2023 Chevrolet Silverado 1500. The contact stated that while driving 45 MPH and depressing the accelerator pedal, the engine seized, and the vehicle lost all power. The contact stated that the vehicle was stuck in the right lane. The vehicle was towed to dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced or rebuilt. The contact stated that the timing chain was replaced on two separate occasions. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The approximate failure mileage was 15,121.
NHTSA ODI #11654803
Mileage unknown · Apr 14, 2025
Engine
On [XXX] around [XXX], I was driving my Silverado down [XXX] near the Cottonwood Mall in Albuquerque, NM. Without warning, the engine died in the center lane of this busy highway. I turned on the emergency flashers, then while trying to call for emergency help on my phone, I stood behind the truck, waving traffic to the side la…
Read full complaint
On [XXX] around [XXX], I was driving my Silverado down [XXX] near the Cottonwood Mall in Albuquerque, NM. Without warning, the engine died in the center lane of this busy highway. I turned on the emergency flashers, then while trying to call for emergency help on my phone, I stood behind the truck, waving traffic to the side lanes in an effort to prevent being rear ended. After about 10 minutes, luckily, an emergency fire department truck spotted my distress and doubled back, parked behind me and engaged his emergency lights. A good Samaritan stopped an attempted to toe strap me to the shoulder of the road. However, the poor design of this truck didn't allow me to put the transmission in neutral unless the vehicle is running. So, after about an hour, the tow truck driver was able to drag the Silverado on the back of his flatbed. After my truck was at the dealer for a week, they were able to determine that the engine main bearings seized and spun a couple of rod bearings. This is a well maintained vehicle, with the oil changes done on time and documented at the dealership. My Silverado has a 6.2 liter V 8.engine with only 21,532 miles on it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11654578
Mileage unknown · Apr 9, 2025
Engine
While driving my 2023 Chevrolet Silverado ZR2 with the 6.2L engine (approx. 22,000 miles) on a busy interstate in another state, the vehicle suddenly lost power and shifted into neutral without warning. I was towing a 5,000-pound camper and had my wife and three children in the truck. We were traveling on a slight incline when t…
Read full complaint
While driving my 2023 Chevrolet Silverado ZR2 with the 6.2L engine (approx. 22,000 miles) on a busy interstate in another state, the vehicle suddenly lost power and shifted into neutral without warning. I was towing a 5,000-pound camper and had my wife and three children in the truck. We were traveling on a slight incline when the truck unexpectedly disengaged. There were no warning lights, no messages, and no sounds indicating engine failure—just a sudden loss of drive. All displays remained illuminated, but I had no power to the wheels. By the grace of God, I was able to maneuver to the median before the truck and camper came to a complete stop. It was a terrifying and dangerous situation that could have resulted in a major accident given the speed of traffic, the weight of the trailer, and the total lack of warning. The truck was towed to a Chevrolet dealer across the state line. After running diagnostics, I was told the engine had failed and would need to be replaced under warranty. However, I have yet to receive a clear explanation of what exactly failed internally. I was informed that a replacement engine is back-ordered by several months, leaving me without a vehicle and unsure when it will be repaired. The incident has not yet been investigated by the manufacturer, insurance, or law enforcement. This experience was frightening not just because of the mechanical failure, but because it happened with zero indication. I hope others don’t have to go through something like this. I understand thousands of these trucks may never see a failure like this—but for us, it happened suddenly, with our entire family on board, and it nearly ended in disaster.
NHTSA ODI #11653793
Mileage unknown · Apr 8, 2025
Engine
While traveling in a funeral possession noticed an engine stall with a blast of smoke coming from rear exhaust.
NHTSA ODI #11653473
Mileage unknown · Apr 7, 2025
Service Brakes
While driving going 40 mph a ‘Brake System Failure’ warning came on and brakes stopped working. Thankfully there were no cars ahead allowing me to continue until the car came to a stop. At that point I engaged the emergency brake and put the car in park and out of gear. I then had the truck towed to a Chevy dealership. I still d…
Read full complaint
While driving going 40 mph a ‘Brake System Failure’ warning came on and brakes stopped working. Thankfully there were no cars ahead allowing me to continue until the car came to a stop. At that point I engaged the emergency brake and put the car in park and out of gear. I then had the truck towed to a Chevy dealership. I still do not have a response to what the issue is.
NHTSA ODI #11653306
Mileage unknown · Apr 2, 2025
Power Train
At 19k miles the transmission had a shifting problem and went into limp mode forcing a deceleration while on a highway. Had to unhook the battery and hook it back up to clear the code to get to a safe point for towing. Had to do this 3 times. Once at the dealer they could not recreate the problem. One week later it went into lim…
Read full complaint
At 19k miles the transmission had a shifting problem and went into limp mode forcing a deceleration while on a highway. Had to unhook the battery and hook it back up to clear the code to get to a safe point for towing. Had to do this 3 times. Once at the dealer they could not recreate the problem. One week later it went into limp mode again. Took it to the deal and was informed that the valve body in the transmission would need to be replace. There is a supply shortage on parts and I am now without a truck for who knows how long.
NHTSA ODI #11652336
Mileage unknown · Apr 1, 2025
Power Train
While accelerating from a traffic signal the transmission shifted very hard and caused the vehicle to suddenly lunge forward.
NHTSA ODI #11651937
Mileage unknown · Mar 24, 2025
Power Train
During gear down-shift the rear wheels briefly lock up. This event can be duplicated easily at around 45mph, by slowing due to uphill grade or slowing traffic, then upon normal application of throttle to resume course the transmission shifts to next lowest gear (3 or 4, not sure) there occurs a brief and sudden horrendous jerk …
Read full complaint
During gear down-shift the rear wheels briefly lock up. This event can be duplicated easily at around 45mph, by slowing due to uphill grade or slowing traffic, then upon normal application of throttle to resume course the transmission shifts to next lowest gear (3 or 4, not sure) there occurs a brief and sudden horrendous jerk as the rear wheels lock & skid. The event lasts less than 1/4 sec, but happens multiple times per day as that speed/load condition is frequent. On occasion, the same can occur in a parking lot ~10mph, but isn't as violent. The first occurrence was at mileage 38,000; the vehicle now has 45,000 miles. This appears to be the same issue as NHTSA Recall No 24V-797, which does not include my vehicle's production year.
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2023 Chevrolet Silverado 1500 Problems, Complaints & Recalls | Skip That Year
Illustration