Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 50 of 373 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 145 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports6 fire reports2 injury reports
What owners actually said
373 reports
Mileage unknown · May 28, 2025
Power Train
Valve Body failed - truck currently at dealership The valve body failed as I was pulling out of a gas station - emergency brake immediately engaged and kept re-engaging as I was trying to make it across the street into the parking lot. Truck could not go more than 5 mph and I was stuck and almost hit. Problem has been confirmed…
Read full complaint
Valve Body failed - truck currently at dealership The valve body failed as I was pulling out of a gas station - emergency brake immediately engaged and kept re-engaging as I was trying to make it across the street into the parking lot. Truck could not go more than 5 mph and I was stuck and almost hit. Problem has been confirmed by the dealer after it was towed directly there. Unknown if component has been inspected outside of service department. Truck initially would not remote start using key fob, but then made it to gas station fine without any further symptoms. After gas station, car started severely shaking then emergency brake engaged and would not accelerate.
NHTSA ODI #11663562
Mileage unknown · May 27, 2025
Engine And Engine Cooling
The contact owns a 2023 Chevrolet Silverado 1500. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time fo…
Read full complaint
The contact owns a 2023 Chevrolet Silverado 1500. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA ODI #11663200
54,000 miles · May 23, 2025
Electrical System
The contact owns a 2023 Chevrolet Silverado 1500. The contact stated while driving at an undisclosed speed, the instrument cluster failed to function as intended. The contact stated that the instrument cluster displayed a black screen. The vehicle was taken to the dealer where the ICP was reprogrammed. The vehicle was repaired; …
Read full complaint
The contact owns a 2023 Chevrolet Silverado 1500. The contact stated while driving at an undisclosed speed, the instrument cluster failed to function as intended. The contact stated that the instrument cluster displayed a black screen. The vehicle was taken to the dealer where the ICP was reprogrammed. The vehicle was repaired; however, the failure reoccurred. The contact stated that the failure had reoccurred several minutes after the vehicle was released by the dealer. The dealer was made aware of the failure. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 54,000.
NHTSA ODI #11662785
Mileage unknown · May 20, 2025
Engine And Engine Cooling
The contact owns a 2023 Chevrolet Silverado 1500. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time fo…
Read full complaint
The contact owns a 2023 Chevrolet Silverado 1500. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and denied buy back assistance. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA ODI #11662180
Mileage unknown · May 18, 2025
Electrical SystemService BrakesUnknown Or Other
GM Case#[XXX] #1 A- On [XXX] vehicle sensors disabled breaks while driving on [XXX]. B- Driver Displayed Alert. a- BRAKE SYSTEM FAILURE 62 MHP TOP SPEED. b- TRAILER BRAKES DISABLED SERVICE REQUIRED. c- SERVICE ESC. C- Concerned by alerts proceeded to exit highway, the breaks where unresponsive. This required pressing break pedal…
Read full complaint
GM Case#[XXX] #1 A- On [XXX] vehicle sensors disabled breaks while driving on [XXX]. B- Driver Displayed Alert. a- BRAKE SYSTEM FAILURE 62 MHP TOP SPEED. b- TRAILER BRAKES DISABLED SERVICE REQUIRED. c- SERVICE ESC. C- Concerned by alerts proceeded to exit highway, the breaks where unresponsive. This required pressing break pedal to the floor. It took over 400ft for the vehicle to come to a complete stop. Fortunately no other vehicles were on the exit ramp, a major accident was avoided. D- On 10/30/2024 took vehicle to Bomnin Chevrolet West Kendall and explained break failure and provided pictures of driver alert messages. E- On 11/1/2024, 3 days after, Bomnin Chevrolet West Kendall Technician communicated that vehicle was mechanically fine and were unable to duplicate the problem. I accepted the vehicle back with 5,901 miles of use. #2 A- On [XXX] vehicle sensors disabled breaks again while driving on Miami city street. B- Driver Digital Displayed flashed following Alert Messages. a- SERVICE TRAILER BREAK SYSTEM. b- SERVICE TRACTION CONTROL. c- SERVICE ESC. d- CHECK ENGINE LIGHT WENT ON. C- Having experienced this back in October, I knew what to expect. Unresponsive breaks, fortunately on 2nd occasion I was driving slower on a city street and was able to coast to a stop. D- On 4/10/2025 took vehicle back to Bomnin Chevrolet West Kendall for the same problem, break failure. I once again explained to Technician what happened, showed them pictures of the Alert Messages. E- Vehicle as of today, 5/18/2025, remains at Bomnin Chevrolet West Kendall for a total of 39 days and is yet to be repaired. Given the severity/danger of defective break sensors defects there is “nonconformity” that under the Lemon Law is defined as a defect or condition that substantially impairs use , value, or safety of the vehicle. These 2 incidents make this vehicle unsafe for drivers, passengers, and general public in proximity. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11661710
Mileage unknown · May 15, 2025
Unknown Or Other
My onstar module stopped working on my 23 chevy silverado. I am planning a vacation and with out onstar I risk being stranded without this service. My WiFi does not work I can not see the speed limit I am unable to contact onstar for help if needed whether that be for directions, or help if I have and emergency. I can not…
Read full complaint
My onstar module stopped working on my 23 chevy silverado. I am planning a vacation and with out onstar I risk being stranded without this service. My WiFi does not work I can not see the speed limit I am unable to contact onstar for help if needed whether that be for directions, or help if I have and emergency. I can not use the handsfree google assistant I took it to my dealer and when I took it I was 400 miles past the warranty. I was not aware of the issue until I tried the handsfree google assistant and if did not work.
NHTSA ODI #11661140
Mileage unknown · May 12, 2025
Engine And Engine Cooling
The contact owns a 2023 Chevrolet Silverado 1500. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer …
Read full complaint
The contact owns a 2023 Chevrolet Silverado 1500. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA ODI #11660369
Mileage unknown · May 10, 2025
EnginePower Train
This is the third time since the purchase date of July 2023, that my Diesel 1500 Silverado has gone into "Reduced Engine Power" while driving. The first date was August 2024, while traveling down the interstate. The check engine light came on. My maximum speed was reduced to 50mph, and the transmission shifting was very jerky. …
Read full complaint
This is the third time since the purchase date of July 2023, that my Diesel 1500 Silverado has gone into "Reduced Engine Power" while driving. The first date was August 2024, while traveling down the interstate. The check engine light came on. My maximum speed was reduced to 50mph, and the transmission shifting was very jerky. This was extremely dangerous with the flow of traffic traveling 70+ mph. I returned to the dealer where the vehicle sat on the lot for approximately 60 days awaiting the part (Valve Body) from GM. Components were repaired through warranty. Fast forward to February 2025, "Reduced Engine Power" notification came on again with the code P0747, P700. Returned to dealer, and after a week of sitting on the lot, the technician could not duplicate the code. I requested that a new fuel filter be replaced for piece of mind. Today, 3 mos. later, as I was backing out of my driveway, my truck did not shift/engage into Reverse. I was able to roll into the road & put it in Drive, however it went into "Reduced Engine Power." The vehicle will have to be towed, at my expense, I'm sure, to further diagnose the cause. The truck does not move when shifted into Reverse, and pressure is applied to the pedal. It is extremely concerning knowing a national recall on identical GM components has been reported, and yet I have had identical issues without resolution. Despite the known problems and safety risks, especially with a child in the vehicle during each failure, I’ve been left without consistent or timely support. I am requesting immediate assistance in diagnosing and repairing this vehicle, as well as a formal explanation of why this recurring issue has not triggered a broader response or replacement. At this point, I’m also considering pursuing further action through GM corporate or a consumer protection agency if a permanent resolution is not reached.
NHTSA ODI #11660100
Mileage unknown · May 9, 2025
Power Train
While driving at ~30 mph the rear wheels locked up momentarily with no warning and without applying the breaks. The back of the vehicle fish-tailed while the tires slid. Following the incident the check engine light came on and the vehicle went into limp mode and would not go more than about 25 - 30 mph. I immediately took it…
Read full complaint
While driving at ~30 mph the rear wheels locked up momentarily with no warning and without applying the breaks. The back of the vehicle fish-tailed while the tires slid. Following the incident the check engine light came on and the vehicle went into limp mode and would not go more than about 25 - 30 mph. I immediately took it to the Chevrolet Dealer. The dealer indicated that the codes showed an issue with the transmission control module. It is currently at the dealer to be repaired. The vehicle has 51917 miles and is still under power train warranty. There was no warning or indication something was about to happen prior to the incident. The truck is a 2023 Silverado 1500 with the 2.7 liter Turbo engine with the GM 8 speed transmission.
NHTSA ODI #11660094
Mileage unknown · May 6, 2025
Service BrakesStructureUnknown Or OtherFire
Fire in firewall dash possibly brake control, battery and electrical fuse box
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2023 Chevrolet Silverado 1500 Problems, Complaints & Recalls | Skip That Year
Illustration