NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
365 reportsClear category filterMileage unknown · Apr 7, 2026
Engine
I own a 2019 Chevrolet Silverado with approximately 84,000 miles. Prior to the engine failure, I noticed abnormal engine ticking noise, especially during cold starts. I reported this concern to the dealership during a service visit. The technician verified the engine noise but stated that the noise was normal and no repairs were…
Read full complaint
I own a 2019 Chevrolet Silverado with approximately 84,000 miles. Prior to the engine failure, I noticed abnormal engine ticking noise, especially during cold starts. I reported this concern to the dealership during a service visit. The technician verified the engine noise but stated that the noise was normal and no repairs were performed. Over time the condition worsened and the vehicle began experiencing engine misfires and internal engine damage. Diagnostic inspection later revealed oil contamination and cylinder wall scoring requiring full engine replacement. Additionally, while driving on a public street, the serpentine belt suddenly came off the engine without warning. This created an immediate safety concern because the belt powers critical systems such as power steering and engine cooling. Losing these systems while driving could cause loss of vehicle control. At the time of the incident, my children were in the vehicle and there were pedestrians and other drivers on the road. The sudden mechanical failure created a dangerous situation that could have resulted in a crash or injury. No warning lights or messages appeared on the dashboard prior to the engine failure, and the check engine light never illuminated. Because the engine concern had previously been reported and dismissed as normal, the problem continued to worsen until catastrophic engine damage occurred. I am submitting this complaint because I am concerned that this may not be an isolated issue and that similar engine failures could pose a safety risk to other drivers.
NHTSA ODI #11729662
Mileage unknown · Apr 6, 2026
Engine
Bearing and Engine failure, Had to pay out of pocket for a new engine at 78,000 miles. The problem was diagnosed by my local dealer Denoyer Chevrolet in holland Mi. There was no warning lamps, messages, nor symptoms. Dealer had all the info on date, inspection and repair. Engine failures like this are very dangerous as they can …
Read full complaint
Bearing and Engine failure, Had to pay out of pocket for a new engine at 78,000 miles. The problem was diagnosed by my local dealer Denoyer Chevrolet in holland Mi. There was no warning lamps, messages, nor symptoms. Dealer had all the info on date, inspection and repair. Engine failures like this are very dangerous as they can cause catastrophic injury or damage. General Motors should be held accountable and made to pay back customers for there damaged products.
NHTSA ODI #11729497
Mileage unknown · Apr 2, 2026
Engine
Driving down road Truck quit, no warning. Left granddaughter stranded on road. Towed to gm dealership. Diagnosis was complete engine failure. Vehicle is there now waiting for decision to repair.
NHTSA ODI #11728768
Mileage unknown · Mar 24, 2026
Engine
motor only has 41000 miles and uses 1 quart of oil every 700 miles
NHTSA ODI #11726740
Mileage unknown · Mar 23, 2026
Engine
Oil cooler line leak.
NHTSA ODI #11726562
Mileage unknown · Mar 22, 2026
Electrical SystemEngineFuel/propulsion System
I’d like to report a serious, ongoing safety concern with my 2019 Chevrolet Silverado (5.3 V8 53,028 mi) since Dec 2025. Over the last 4 months, I have experienced at least 20 engine failures/loss of power, with no engine light illuminated after restarting truck. These failures result in a complete loss of power, including stee…
Read full complaint
I’d like to report a serious, ongoing safety concern with my 2019 Chevrolet Silverado (5.3 V8 53,028 mi) since Dec 2025. Over the last 4 months, I have experienced at least 20 engine failures/loss of power, with no engine light illuminated after restarting truck. These failures result in a complete loss of power, including steering and braking, posing a significant risk of a crash. Chevy said it would be hard to diagnose with no engine warning light on. Feb 24th, engine failure, warning light stayed on and towed truck to Chevy. Truck on standby, repaired Mar 10th, replacing 2 oxygen sensors per Diagnostics. Picked it up on March 11th, but engine shutdown again the same day and 4 additional failures while driving in my neighborhood, making the truck undrivable. I reached out to Chevy service supervisor, Juliana, but have received no response for the last 10 days. I urge NHTSA to investigate this defect as it poses a severe safety risk. Thank you for your urgent attention.
NHTSA ODI #11726217
103,000 miles · Mar 19, 2026
Engine
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated on three occasions while driving at various speeds, there was a clunking or clicking sound coming from the engine compartment, before the vehicle lost power. The vehicle was taken to a dealer where it was diagnosed with engine rod bearing failure. The contact w…
Read full complaint
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated on three occasions while driving at various speeds, there was a clunking or clicking sound coming from the engine compartment, before the vehicle lost power. The vehicle was taken to a dealer where it was diagnosed with engine rod bearing failure. The contact was informed that the rod bearings and engine block needed to be replaced. The vehicle was not repaired and was taken to the residence and parked. Less than a week later, the vehicle was taken back to the same dealer for the repairs. The vehicle was repaired, but the failure reoccurred approximately five months later. The vehicle was taken back to the same dealer where it was diagnosed with an exhaust manifold leak. The contact was informed that the exhaust manifold needed to be replaced. The vehicle was repaired, but the failure reoccurred approximately two months later. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was approximately 103,000.
NHTSA ODI #11725555
Mileage unknown · Mar 17, 2026
EngineFuel/propulsion SystemSuspension
VECHILE CONTINUES TO FAIL OIL CONSUMPTION TEST, TEST BEGAN 09/2023, AND CONTINUES TO BE THE ISSUE PRESENT DAY. ENGINE WAS REPLACED 2025, 3-4 MONTHS LATER TRANMISSION WENT OUT. TRANSMISSION REPLACED 2025. OIL CONSUMPTION CONTINUES TO FAIL. DEALERSHIP CHUCK HUTTON 2471 MT. MORIAH ROAD, MEMPHIS, TN 38115 PERFORMED ALL THESE SERVICE…
Read full complaint
VECHILE CONTINUES TO FAIL OIL CONSUMPTION TEST, TEST BEGAN 09/2023, AND CONTINUES TO BE THE ISSUE PRESENT DAY. ENGINE WAS REPLACED 2025, 3-4 MONTHS LATER TRANMISSION WENT OUT. TRANSMISSION REPLACED 2025. OIL CONSUMPTION CONTINUES TO FAIL. DEALERSHIP CHUCK HUTTON 2471 MT. MORIAH ROAD, MEMPHIS, TN 38115 PERFORMED ALL THESE SERVICES. SAFETY CONCERN IS THAT THE LEAKING OIL POLLUTION IS CAUSING HARM TO ME AND MY FAMILY AS WELL AS LEAVING OIL RESIDUE IN THE DRIVEWAY. NO WARNING MESSAGES EXCEPT FOR WHEN IT SAYS ADD OIL, THAT'S WHEN I'M PUT ON NOTICE THAT THE VECHILE IS LOSING OIL. DUE TO THE LEAKING OIL, OIL IS NOW MIXING WITH GASOLINE, INDICATING THERE TO BE AN ISSUE WITH THE FUEL PUMP. NOW BEIND DIRECTED TO REPLACE THE FUEL PUMP. THIS HAS BECOME VERY COSTLY FOR ME AND MY FAMILY AND CONTINUES TO BE AN ON-GOING PROBLEM
NHTSA ODI #11725060
Mileage unknown · Mar 10, 2026
EngineUnknown Or Other
I am reporting a catastrophic internal engine failure in a 2019 Chevrolet Silverado 1500 at 87,600 miles. Prior to this event, there were NO warning lights or symptoms. While traveling alone during the holiday on a remote, one-lane road with no shoulder, the vehicle suddenly suffered a loss of power. Every warning light on the …
Read full complaint
I am reporting a catastrophic internal engine failure in a 2019 Chevrolet Silverado 1500 at 87,600 miles. Prior to this event, there were NO warning lights or symptoms. While traveling alone during the holiday on a remote, one-lane road with no shoulder, the vehicle suddenly suffered a loss of power. Every warning light on the dashboard illuminated at once, followed by shaking, misfiring, and loud knocking from the engine. Because I was on a one-lane road with no place to pull over, this created an immediate safety hazard for me and oncoming traffic. I had the car towed to the dealership ( where I bought the truck) confirmed the failure was a collapsed lifter and scored camshaft (which i found out to be a known design flaw in the 5.3L DFM engine). The dealer said it was not under warranty. I felt held over a barrel by the dealership; they initially provided an inflated quote and told me it would cost approximately $1,200, not including tax and shop fees, just to put the engine back together if I wanted to tow it elsewhere for a second opinion. I was forced to pay over $8,395 under protest just to regain use of my primary vehicle after 42 days of downtime. Upon completion, the dealer provided a "Lifetime Warranty" on the replacement parts. This is a tacit admission that these components were never intended to fail during the life of the vehicle. GM refuses to include this vehicle in its coverage list, treating a dangerous engine stall as a simple "out of warranty" repair. This is a systemic safety defect that requires a mandatory recall expansion before it results in a terrible accident. My understanding is that a Class Action lawsuit, Harrison vs. General Motors, for this same thing, but they say my car is not in it, i should have been put on notice for this so I could protect myself.
NHTSA ODI #11723279
Mileage unknown · Mar 7, 2026
Engine
My husband, [XXX] son, my [XXX] mother-in-law, and I were traveling on the expressway at approximately 70 miles per hour in our 2019 Chevrolet Silverado 1500 with the 5.3L engine when the dashboard suddenly lit up with warning lights and alarms. My husband looked in the rear-view mirror and saw a large amount of smoke coming fr…
Read full complaint
My husband, [XXX] son, my [XXX] mother-in-law, and I were traveling on the expressway at approximately 70 miles per hour in our 2019 Chevrolet Silverado 1500 with the 5.3L engine when the dashboard suddenly lit up with warning lights and alarms. My husband looked in the rear-view mirror and saw a large amount of smoke coming from the truck. We immediately had to cross two lanes of heavy traffic to reach the shoulder and get off the roadway safely. When I opened my door, I could see that engine oil was pouring from the truck and running down the expressway. We were stranded on the side of the expressway for over an hour before my brother was able to come pick us up. The tow truck company advised that it would take several hours before they could arrive. During that time, vehicles continued traveling at highway speeds and did not slow down despite our disabled truck being on the shoulder. The truck was shaking from the wind and force of cars and trucks passing by at high speeds. This created an extremely dangerous situation, particularly with our [XXX] child and my elderly mother-in-law in the vehicle. The truck was eventually towed to a local repair shop, where the mechanic determined that the engine oil cooler line had broken at the crimp, causing a significant oil leak. The repair required replacement of the oil cooler lines and related components at a cost of $2,109.92. Had we continued driving even briefly, the engine likely could have been severely damaged or destroyed due to the rapid loss of oil. This appears to match the known issue described in GM Customer Satisfaction Program N212326940 regarding oil cooler lines detaching from the crimp on 2019 Chevrolet Silverado trucks. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11722678
Official recalls
10Dec 16, 2021
General Motors (GM) is recalling certain 2019-2021 GMC Sierra 1500 and Silverado 1500 vehicles equipped with certain accessory road tires and a 17" spare tire. The 17" spare tire provided with the vehicle is not compatible for use with the accessory wheels, which can cause the anti-lock brake system (ABS) to not function properly under certain conditions.
Consequence & remedy
Consequence: An ABS system that does not function properly can increase the risk of a crash.
Remedy: Dealers will provide a new 17" spare tire and wheel assembly that is compatible with the accessory wheels, free of charge. Dealers will also apply a new spare tire information label, and provide owners with an owner's manual insert clarifying which spare tire to use with the accessory road tires and with the 17" original tires. Owner notification letters were mailed February 7, 2022. Owners may contact GM customer service at 1-800-462-8782 or GMC customer service at 1-800-462-8782. GM's number for this recall is N212346510.
Jun 3, 2021
General Motors, LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The affected tires were cured for too long during production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers inspect and replace the tires as necessary, free of charge, free of charge. Owner notification letters were mailed on June 25, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N212336230.
Additional source detail variants (2)
Tires:sidewall
General Motors, LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The affected tires were cured for too long during production.
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers inspect and replace the tires as necessary, free of charge, free of charge. Owner notification letters were mailed on June 25, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N212336230.
Tires
General Motors, LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The affected tires were cured for too long during production.
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers inspect and replace the tires as necessary, free of charge, free of charge. Owner notification letters were mailed on June 25, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N212336230.
Feb 25, 2021
General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT4, XT5, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, Traverse, GMC Yukon, Yukon XL, 2018-2021 Chevrolet Express, GMC Savana, 2019-2020 Chevrolet Blazer, Silverado 1500, GMC Acadia, Sierra 1500, and certain Continental tires sold to the aftermarket for various model year 2018-2021 vehicles. The affected tires were cured for too long during production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will inspect the tires, replacing them as necessary, free of charge. The recall began March 22, 2021. Owners may contact GMC customer service at 1-888-988-7267, Buick customer service at 1-866-608-8080, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212329050.
Dec 17, 2020
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
Consequence & remedy
Consequence: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Additional source detail variants (2)
Seat Belts:critical Fasteners
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
Consequence: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Seat Belts
General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
Consequence: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.
Oct 22, 2020
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500 and 2020 Chevrolet Silverado 2500 trucks. One of the driveshaft joints may not have been properly welded, causing the driveshaft to separate while the vehicle is moving.
Consequence & remedy
Consequence: If the driveshaft separates, there may be a loss of propulsion, increasing the risk of crash.
Remedy: GM will notify owners, and dealers will replace the driveshaft, free of charge. The recall is expected to begin December 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N202314870.
Jan 30, 2020
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. These vehicles received updated software for the Electronic Brake Control Module (EBCM). This software has an error, and as a result, the vehicle's electronic brake assist may be disabled. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: A loss of electronic brake assist can increase the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 24, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268091.
Dec 12, 2019
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500 trucks. The battery positive (B+) cable rings may have been manufactured with excessive glue, potentially causing an intermittent electrical connection between the B+ cable and alternator.
Consequence & remedy
Consequence: An intermittent electrical connection between the B+ battery cable and the alternator could cause the vehicle to stall, increasing the risk of a crash. The intermittent connection could also lead to electrical arcing, which could generate sufficient heat to damage surrounding material, increasing the risk of a fire.
Remedy: GM will notify owners, and dealers will inspect for the presence of glue or other contamination at the B+ cable attachment to the alternator and clean the connection and reattach the B+ cable connection, as necessary. If arcing has damaged the cable, nut, or alternator, the dealer will replace the damaged components. All services will be performed free of charge. GM issued owners an interim notification on February 4, 2020. GM issued second notice and the recall began March 9, 2019. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192273510.
Dec 12, 2019
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:abs Warning Light
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500, Cadillac CT6, and GMC Sierra 1500 vehicles. Due to an Electronic Brake Control Module (EBCM) software error, the vehicle's Electronic Stability Control (ESC) and Antilock Brake System (ABS) may become disabled. Furthermore, if this specific error occurs, the vehicle's diagnostics will not illuminate the instrument cluster ESC and ABS malfunction warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control" and 135, "Light Vehicle Brake Systems."
Consequence: If the driver operates the vehicle unaware that ESC and ABS are not functioning, there is an increased risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began February 4, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-333-4223, or GMC customer service at 1-888-988-7267. GM's number for this recall is N192268090.
Nov 14, 2019
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2020 Silverado 2500, Silverado 3500, Sierra 2500, and Sierra 3500 vehicles equipped with carpet floor covering. When the front seat belt pretensioners deploy, hot gas may vent through an opening in the pretensioner bracket, possibly igniting the carpet.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: GM will notify owners, and dealers will close off the opening in the pretensioner bracket, free of charge. The recall began December 13, 2019. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192270600.
Dec 6, 2018
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 1500 Crew Cab and GMC Sierra 1500 Crew Cab vehicles. The passenger-side frontal air bag module may have been damaged during assembly, possibly resulting in the air bag not inflating properly in the event of a crash.
Consequence & remedy
Consequence: In the event of a crash, an air bag that does not inflate properly can increase the risk of injury.
Remedy: GM will notify owners, and dealers will replace the passenger side air bag module, free of charge. The recall began on December 18, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is N182198820.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration