IllustrationSEVERAL TIMES THE VEHICLE WOULD LOOSE POWER AND SHUT DOWN THE POWER STEERING WHILE ATTEMPTING TO PARK OR TURN AROUND IN DRIVEWAY.. ON TIMES,ONLY WARNINGS WOULD FLASH UP ON THE INFORMATION DISPLAY ABOUT LOSE OF SYSTEMS AND THE DOOR LOCKS WOULD CYCLE. OCCASIONALLY, THE TURN SIGNALS WOULD SHUT OFF THE CRUSE CONTROL.
2014 Chevrolet Silverado 1500
Owner reports · Recalls · Investigations
More warning signs than most Silverado 1500 years
Owner complaints for the 2014 Chevrolet Silverado 1500 are substantially higher than the model-year median of 525.
About this comparison →How this year compares
Owner complaints by model year
Compare all Silverado 1500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1690–25K
20525–50K
27650–75K
19375–100K
144100–150K
42150K+
1,029 reports with mileage · 405 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 406 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 341 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 269 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
61 crash reports18 fire reports30 injury reports
Steering complaints
406 reportsTL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 20 MPH, THE STEERING SEIZED WHEN THE BRAKE PEDAL WAS DEPRESSED. ALSO, THE STABILITRAK WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT CALLED VANDERGRIFF CHEVROLET (LOCATED AT 1200 W INTERSTATE 20, ARLINGTON, AR…
Read full complaint
TL* THE CONTACT OWNS A 2014 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 20 MPH, THE STEERING SEIZED WHEN THE BRAKE PEDAL WAS DEPRESSED. ALSO, THE STABILITRAK WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT CALLED VANDERGRIFF CHEVROLET (LOCATED AT 1200 W INTERSTATE 20, ARLINGTON, ARLINGTON, TEXAS 76017) WHO STATED THAT THE REMEDY WAS NOT AVAILABLE. THE VIN WAS ASSOCIATED WITH A STEERING RECALL. THE NHTSA CAMPAIGN NUMBER WAS NOT AVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 63,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
STARTED EXPERIENCING A POPPING SOUND AND POPPING /CLICKING FEELING IN THE STEERING WHEEL WHEN DRIVING AT SLOW SPEEDS ,WHEN TURNING THE STEERING WHEEL IN EITHER DIRECTION.THIS WOULD USUALLY OCCUR IN TIGHT SPACES SUCH AS PARKING LOTS ,GAS STATIONS ETC. AND AFTER THE TRUCK WAS DRIVEN FOR AWHILE ,20 PLUS MILES AFTER A FEW WEEKS S…
Read full complaint
STARTED EXPERIENCING A POPPING SOUND AND POPPING /CLICKING FEELING IN THE STEERING WHEEL WHEN DRIVING AT SLOW SPEEDS ,WHEN TURNING THE STEERING WHEEL IN EITHER DIRECTION.THIS WOULD USUALLY OCCUR IN TIGHT SPACES SUCH AS PARKING LOTS ,GAS STATIONS ETC. AND AFTER THE TRUCK WAS DRIVEN FOR AWHILE ,20 PLUS MILES AFTER A FEW WEEKS STARTED NOTICING THAT FRONT TIRES WERE WEARING RAPIDLY AND CLICK/POPPING SOUND HAD PROGRESSED AND SO WE SCHEDULED APPOINTMENT WITH DEALERSHIP, AND MET WITH SERVICE TECH ,AFTER A BRIEF DIAGNOSIS I WAS INFORMED THAT IT WAS A FAULTY RACK AND PINION AND WOULD NEED TO BE REPLACED, THIS IS A MAJOR DISAPPOINTMENT ON A FAIRLY NEW TRUCK WITH LESS THEN 68000 MILES
I BOUGHT THIS TRUCK ONE MONTH AGO AND WAS TOLD THERE WERE NO RECALLS. WHEN I WENT IN FOR SERVICE THREE RECALLS WERE FOUND. I WAS LIED TO BY THE CAR DEALER AND I FEEL MY LIFE IS IN DANGER.
STEERING ASSIST ERROR, SERVICE STABILITRAC ERROR,- STEERING WHEEL JERKED OUT OF HAND WHILE TURNING , LOSS OF STEERING. ELECTRICAL LOSS- ALL GAUGES AND LIGHTING BLANK WHILE DRIVING ON HIGHWAY
I HAVE A 2014 CHEVY SILVERADO PICK UP TRUCK. I HAVE BEEN EXTREMELY PLEASED WITH THIS TRUCK UNTIL YESTERDAY!!!! AT 22,000 MILES THE TRUCK MALFUNCTIONED TWICE WITHIN A SHORT DISTANCE. THE TRUCK SOME WHAT STALLED WITH OUT WARNING AND ALL THE DASH LIGHTS WENT CRAZY AND TRUCK LOST POWER. LESS THAN A HALF MILE LATER WHILE TURNING …
Read full complaint
I HAVE A 2014 CHEVY SILVERADO PICK UP TRUCK. I HAVE BEEN EXTREMELY PLEASED WITH THIS TRUCK UNTIL YESTERDAY!!!! AT 22,000 MILES THE TRUCK MALFUNCTIONED TWICE WITHIN A SHORT DISTANCE. THE TRUCK SOME WHAT STALLED WITH OUT WARNING AND ALL THE DASH LIGHTS WENT CRAZY AND TRUCK LOST POWER. LESS THAN A HALF MILE LATER WHILE TURNING LEFT IN A CUL DE SAC THE TRUCK WENT CRAZY, STALLED, DASH LIT UP, THE STEERING WHEEL VIOLENTLY TURNED TO THE RIGHT AS I WAS ATTEMPTING TO TURN LEFT. IMMEDIATELY TOOK IT INTO SERVICE. 4 DAYS PAST WARRANTY EXPIRATION. CHEVY/JESSUP AUTO GRP WON'T FIX IT. KEVIN IN SERVICE SAID HE WOULD CALL ME ON WED AT 4 WITH UPDATE. THURS AT 11AM STILL NO WORD. DROPPED BY SERVICE DEPT. FOR UPDATE WITH KEVIN. HE SAID THEY DIDN'T HAVE PRICE READY FOR REPAIR. DENIED COVERAGE UNDER RECENTLY EXPIRED WARRANTY. WHEN I SHOWED HIM A LIST OF SERIOUS COMPUTER MALFUNCTIONS AND SAFETY ISSUES FROM ONLINE CHEVY TRUCK OWNERS HE TOLD ME HE WASN'T INTERESTED AND HE HAD OTHER PEOPLE TO TEND TO. HE ALSO SAID I DROPPED BY WITHOUT AN APPOINTMENT. IN OTHER WORDS, I NO LONGER WAS A PRIORITY. WHEN ASKED FOR SERVICE DEPT GENERAL MGR. ---OH-HE IS NOT AVAILABLE. SO NOW MY LOW MILEAGE TRUCK SITS WITH NO REPAIR, APPEARS TO BE A HAZARD TO DRIVE, GM NOT STANDING BEHIND NOR HAS A FIX FOR THE COMPUTER MALFUNCTIONS THAT HAS BEEN REPORTED WIDESPREAD ON CARCOMPLAINTS.COM , LEAVES ME WITH A VERY EXPENSIVE PAPER WEIGHT THAT I AM FEARFUL TO DRIVE. IT'S ANOTHER IGNITION KEY GM COVER UP AND UNTIL ENOUGH PEOPLE DIE AND THE FEDS GET INVOLVED -- IT APPEARS I AM DRIVING A TRUCK THAT IS A DANGER TO THE ROAD AND JESSUP COULD CARE LESS !!
SO FAR IT HAS ONLY DONE THIS UNDER LOW SPEED MAKING A TIGHT TURN LIKE UP TO A GAS PUMP OR INTO A PARKING SPACE THE DASH AND DISPLAY CENTER WILL FLASH ON AND OFF AND THE STEERING WHEEL WILL JERK THE OTHER DIRECTION SO VIOLENTLY IT PULLS THE STEERING WHEEL OUT OF YOUR HAND. ALSO ON THE HIGHWAY WHILE DRIVING ABOUT 20 MPH I GOT A WA…
Read full complaint
SO FAR IT HAS ONLY DONE THIS UNDER LOW SPEED MAKING A TIGHT TURN LIKE UP TO A GAS PUMP OR INTO A PARKING SPACE THE DASH AND DISPLAY CENTER WILL FLASH ON AND OFF AND THE STEERING WHEEL WILL JERK THE OTHER DIRECTION SO VIOLENTLY IT PULLS THE STEERING WHEEL OUT OF YOUR HAND. ALSO ON THE HIGHWAY WHILE DRIVING ABOUT 20 MPH I GOT A WARNING SOMETHING TO THE EFFECT THAT STEERING ASSIST HAD BEEN REDUCED DRIVE WITH CAUTION. EVEN UNDER LOW SPEED IT COULD HAVE BEEN DANGEROUS BUT I'M AFRAID AT SOME POINT THIS WILL OCCUR AT A HIGHER SPEED. WE BOUGHT THE VEHICLE USED, THE FACTORY WARRANTY IS GONE BUT I HAVE AN EXTENDED WARRANTY. I CONTACTED MY LOCAL CHEVY DEALER BECAUSE I CONSIDERED A SAFETY DEFECT THAT SHOULD BE TAKEN CARE OF BEYOND THE WARRANTY BUT THEY CLAIM THEY KNOW NOTHING ABOUT THIS AS A PROBLEM DESPITE THE FACT I HAVE SEEN MANY COMPLAINTS ABOUT THIS PROBLEM DOCUMENTED, THAT'S WHAT PROMPTED ME TO FILE A COMPLAINT. THE VEHICLE IS CURRENTLY AT MY MECHANIC HOPING THEY CAN FIND A CAUSE/SOLUTION BUT I THINK THIS IS SOMETHING GM/CHEVY SHOULD BE DOING A RECALL ON AND FIXING INSTEAD OF PEOPLE HAVING TO PAY OUT OF POCKET OR PRIVATE AFTER MARKET WARRANTY COMPANIES HAVING TO PAY FOR. I HAVE A VIDEO OF IT DOING IT ON MY IPHONE BUT DIDN'T KNOW IF I COULD INCLUDE VIDEO AND IT'S CURRENTLY ON MY PHONE AND NOT MY LAPTOP. I USED 02/01/2017 AS OCCURRENCE DATE BUT I'M NOT SURE OF THAT WAS THE FIRST TIME OR NOT, WE'VE HAD VEHICLE SINCE 12/2016 AND IT'S HAPPENED NUMEROUS TIMES.
TRAVELING AT APPROX. 65MPH ON US17 A DIVIDED FOUR LANE HIGHWAY IN TRAFFIC WHEN THE ENGINE SHUT OFF WITH NO WARNING WHICH RESULTED IN COMPLETE LOSS OF LIGHTS, SIGNALS, FLASHERS, HORN, AND THE STEERING WHEEL WENT INTO LOCKED POSITION. I WAS ABLE TO SAFELY BRING THE TRUCK TO A STOP IN THE GRASS MEDIAN. AFTER COLLECTING MY THOUGHTS …
Read full complaint
TRAVELING AT APPROX. 65MPH ON US17 A DIVIDED FOUR LANE HIGHWAY IN TRAFFIC WHEN THE ENGINE SHUT OFF WITH NO WARNING WHICH RESULTED IN COMPLETE LOSS OF LIGHTS, SIGNALS, FLASHERS, HORN, AND THE STEERING WHEEL WENT INTO LOCKED POSITION. I WAS ABLE TO SAFELY BRING THE TRUCK TO A STOP IN THE GRASS MEDIAN. AFTER COLLECTING MY THOUGHTS I TRIED TO RESTART THE TRUCK BUT THERE WAS NO RESPONSE AND ALL ELECTRICAL FUNCTIONS WOULD NOT OPERATE. ABOUT 10 MINUTES LATER WHILE I WAS ON MY CELL PHONE WITH A TOW SERVICE THE INTERIOR LIGHTS CAM ON ALONG WITH THE RADIO. THE TRUCK STARTED UP AND AFTER CALLING THE CLOSEST GM DEALER WHICH HAPPEN TO BE ONLY A FEW MILES AWAY I MADE MY WAY TO THE DEALERSHIP SERVICE DEPT. THEY WERE QUICKLY ABLE TO IDENTIFY THE PROBLEM AS GM HAD ISSUED A SERVICE BULLETIN #PIT5405C ON THIS TYPE OF ISSUE. IT WAS CAUSED BY DASHBOARD FABRIC TRIM BEING CAUGHT UNDER A GROUND POST DURING ASSEMBLY THAT RESULTED IN LOSS OF ALL ELECTRICAL SERVICE. THE TRUCK HAD APPROX. 40,000 MILES AT THE TIME OF THE EVENT AND IT SEEMS IT TOOK EITHER TWO YEARS OR THAT REASONABLY LOW MILEAGE BEFORE THE PROBLEM SURFACED. THE DEALER REPAIRED THE PROBLEM BY SIMPLY LOSING A GROUND POST AND TRIMMING OUT THE FABRIC INTRUSION. THEY WERE GREAT AND APOLOGIZED FOR WHAT THEY SAW AS CLEARLY A DEFECT IN MANUFACTURING. THEY DID CHARGE AS THE TRUCK WAS OUT OF THE 36,000 MILE WARRANTY BUT SAID I SHOULD CONTACT GM CUSTOMER SERVICE FOR HELP WITH THE COST. GM REFUSED BUT IT WAS ONLY ABOUT $100.00 SO THAT IS NOT THE ISSUE. HOW CAN A COMPANY ALLOW THIS PROBLEM TO EXIST AND BE AWARE OF IT ( TECHNICAL BULLETIN ISSUED). IT IS A WONDER THAT I OR ANOTHER MOTORIST ON THE ROAD WITH ME WAS NOT HURT OR WORSE. THIS NOT LIKE A TRUCK NOT STARTING BUT TOTAL LOSS OF CONTROL AT HIGHWAY SPEED. THANKS [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
EVENT #1: STOPPED AT STOPLIGHT ON CITY STREET TO TURN LEFT; LIGHT CHANGES; TUNED STEERING WHEEL RAPIDLY TO THE LEFT & ACCELERATED; CROSSING IN FRONT OF TRAFFIC, THE STEERING WHEEL JERKED VIOLENTLY TO THE RIGHT OUT OF MY HANDS 3 TIMES TILL I BRAKED THE VEHICLE TO A STOP & SAT STILL FOR 5 SECONDS; COULD THEN STEER & DRIVE NORMALL…
Read full complaint
EVENT #1: STOPPED AT STOPLIGHT ON CITY STREET TO TURN LEFT; LIGHT CHANGES; TUNED STEERING WHEEL RAPIDLY TO THE LEFT & ACCELERATED; CROSSING IN FRONT OF TRAFFIC, THE STEERING WHEEL JERKED VIOLENTLY TO THE RIGHT OUT OF MY HANDS 3 TIMES TILL I BRAKED THE VEHICLE TO A STOP & SAT STILL FOR 5 SECONDS; COULD THEN STEER & DRIVE NORMALLY. EVENT # 2: VERY NEXT DAY; BACKING SLOWLY OUT OF DRIVEWAY; STOPPED ON STREET; TURNED STEERING WHEEL SLOWLY TO LEFT TO PROCEED DOWN STREET; STEERING WHEEL JERKS VIOLENTLY TO THE RIGHT; AFTER BRAKING & SITTING FOR 5 SECONDS WITH THE ENGINE IDLING AGAIN, WAS ABLE TO PROCEED. EVENT # 3: 15 MINUTES AFTER EVENT #2; AGAIN BACKING SLOWLY TO THE LEFT TO TURN AROUND, & THEN TURNING THE STEERING WHEEL TO THE RIGHT TO PROCEED FORWARD, STEERING WHEEL JERKS VIOLENTLY TO THE LEFT OUT OF MY HANDS. AGAIN AFTER BRAKING TO A STOP & SITTING AT IDLE FOR 5 SECONDS WAS ABLE TO PROCEED. DURING ALL 3 EVENTS, THE SCREEN DISPLAYED "SERVICE STABILITRAK". THIS ISSUE "STEERING WHEEL JERKED VIOLENTLY OUT OF MY HANDS" & "STEERING LOCKS UP (VIDEO INCLUDED) WHEN TURNING" IS FREQUENTLY DISCUSSED ON GM FORUMS BY OWNERS. ONE OWNER APPEARS TO HAVE SOLVED IT BY FIXING A POOR ELECTRICAL GROUND UNDER THE DASH.
TRAVELING APPX. 60 MPH CT RTE 8 WHEN DEER APPEARED SWERVED TO AVOID DIRECT IMPACT LOST STEERING CONTROL STRUCK UNKNOWN WENT AIRBORNE LANDED HARD STRUCK UNKNOWN NO INJURIES HOWEVER NO AIRBAG DEPLOYMENT EITHER OCCURRED 4/07/17 APPX. 2200 HRS YOUTHFUL DRIVER W/ONE PASSENGER BOTH SEATBELTED SUFFERED FRONT END & SUBFRAME DAMAGE CAU…
Read full complaint
TRAVELING APPX. 60 MPH CT RTE 8 WHEN DEER APPEARED SWERVED TO AVOID DIRECT IMPACT LOST STEERING CONTROL STRUCK UNKNOWN WENT AIRBORNE LANDED HARD STRUCK UNKNOWN NO INJURIES HOWEVER NO AIRBAG DEPLOYMENT EITHER OCCURRED 4/07/17 APPX. 2200 HRS YOUTHFUL DRIVER W/ONE PASSENGER BOTH SEATBELTED SUFFERED FRONT END & SUBFRAME DAMAGE CAUSING MOTOR TO MOVE TOWARD CABIN CURRENTLY AT BODY SHOP TO DETERMINE REPAIRABLITY.
Official recalls
621V245000 · Seat Belts:front
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2014-2016 Chevrolet Silverado 1500, 2015-2016 Chevrolet Tahoe, and 2014-2015 GMC Sierra 1500 vehicles that may have received an incorrect replacement tensioner cable assembly as part of a previous recall remedy or a subsequent repair. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
Consequence & remedy
Consequence: A broken pretensioner cable reduces the effectiveness of the driver's seat belt, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the driver seat belt lap pretensioner, free of charge. The recall began on May 5, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212330040.
19V761000 · Electronic Stability Control (esc); Service Brakes; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor/tone Ring
Oct 24, 2019
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence & remedy
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Additional source detail variants (3)
Service Brakes
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:wheel Speed Sensor/tone Ring
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Consequence: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
19V645000 · Service Brakes, Hydraulic:power Assist:vacuum
Sep 6, 2019
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
Consequence & remedy
Consequence: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
17V437000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
17V414000 · Steering:electric Power Assist System
Jun 29, 2017
General Motors LLC (GM) is recalling certain 2014 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The vehicles may have a temporary loss of electric power steering (EPS) assist, especially during low-speed turning maneuvers.
Consequence & remedy
Consequence: If EPS assist is lost and then returns, the driver might lose temporary control of the steering wheel, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will update the EPS module software, free of charge. The recall began on August 10, 2017. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-432-8782. GM's number for this recall is 17276.
16V651000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.