← New search

2011 Chevrolet Silverado 1500

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2011 Chevrolet Silverado 1500 do not stand out strongly from the model-year median of 525.

About this comparison →

When problems were reported

Mileage at the reported incident

263 reports with mileage · 300 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Air Bags. Review the 306 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Structure. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

22 crash reports4 fire reports6 injury reports

Air Bags complaints

306 reports
Clear category filter
Mileage unknown · Nov 15, 2017
Air Bags

TL* TAKATA RECALL. THE CONTACT OWNS A 2011 CHEVROLET SILVERADO 1500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED CASTR…

Read full complaint

TL* TAKATA RECALL. THE CONTACT OWNS A 2011 CHEVROLET SILVERADO 1500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED CASTRIOTA CHEVROLET AT (727) 819-5300 (12930 US-19, HUDSON, FL 34667) WHERE IT WAS CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE/PARTS DISTRIBUTION DISCONNECT. *BF UPDATED 8/9/18*JB

NHTSA ODI #11046274

Mileage unknown · Nov 15, 2017
Air Bags

TAKATA RECALL. GM RECALL NOTICE 2049151 WAS ISSUED ON MAY 27, 2016. AS OF NOVEMBER 15, 2017, GM IS STATING THAT THEY STILL HAVE NO REMEDY. WOULDN'T A REMEDY BE TO REPLACE THE FAULTY AIRBAG? IS IT SAFE TO CONTINUE DRIVING WITH THE FAULTY AIRBAG?

NHTSA ODI #11046271

33,000 miles · Nov 15, 2017
Air Bags

TAKATA RECALL , I CARRIED MY VEHICLE TO CHEVROLET DEALERSHIP SEVERAL TIMES TO HAVE RECALL REPAIRS MADE AND THEY SAY THE AIR BAGS NEEDED FOR THE REPAIRS ARE NOT AVAILABLE.

NHTSA ODI #11046210

Mileage unknown · Nov 12, 2017
Air Bags

TAKATA RECALL-RECEIVED A RECALL LETTER IN JULY 2016 STATING THE AIRBAGS ARE DEFECTIVE AND THAT GM WILL CONDUCT A RECALL IF THEY ARE NOT ABLE TO PROVE TO NHTSA THEY ARE SAFE. GM RECALL 49151. NOVEMBER 2017 RECEIVED NOTICE OF TAKATA BANKRUPTCY PROCEEDINGS. FOLLOWING NOTICE I PHONED THE DEALER WHO SOLD ME THE VEHICLE AND WAS GIV…

Read full complaint

TAKATA RECALL-RECEIVED A RECALL LETTER IN JULY 2016 STATING THE AIRBAGS ARE DEFECTIVE AND THAT GM WILL CONDUCT A RECALL IF THEY ARE NOT ABLE TO PROVE TO NHTSA THEY ARE SAFE. GM RECALL 49151. NOVEMBER 2017 RECEIVED NOTICE OF TAKATA BANKRUPTCY PROCEEDINGS. FOLLOWING NOTICE I PHONED THE DEALER WHO SOLD ME THE VEHICLE AND WAS GIVEN VOICEMAIL. I LEFT A MESSAGE BUT THEY DID NOT RETURN MY CALL. SUBSEQUENTLY PHONED GM TO INQUIRE INTO STATUS OF RECALL. I WAS TOLD MY VEHICLE WAS SAFE TO DRIVE AND THAT GM WAS STILL WORKING WITH NHTSA. I WAS TOLD I WOULD BE NOTIFIED IF THE AIRBAGS NEEDED TO BE REPLACED. MY COMPLAINT IS THAT THERE SHOULD BE A DECISION BY NOW. OTHER MANUFACTURERS HAVE ALREADY COMPLETED RECALLS AND REPAIRS. WITH TAKATA FILING FOR BANKRUPTCY AND GM NOT MAKING REPAIRS WHO WILL TAKE RESPONSIBILITY FOR THE REPAIRS OR ANY ASSOCIATED INJURIES/DEATHS?

NHTSA ODI #11045474

Mileage unknown · Nov 9, 2017
Air Bags

1/08/2017- BAKERSFIELD, CA. PASSENGER SIDE AIRBAG, FOR MY MODEL IT HAS BEEN IDENTIFIED AS DEFECTIVE. RECEIVED LEGAL NOTICE THIS DATE FROM TK HOLDINGS INC, MONROE WI. THEY ARE DEBTORS, WHO FILED CHAPTER 11 FOR TAKATA CORPORATION. THEY STATED TAKE YOUR VEHICLE TO LOCAL DEALERSHIP IMMEDIATELY TO SCHEDULE A FREE REPAIR ON A DEFECTI…

Read full complaint

1/08/2017- BAKERSFIELD, CA. PASSENGER SIDE AIRBAG, FOR MY MODEL IT HAS BEEN IDENTIFIED AS DEFECTIVE. RECEIVED LEGAL NOTICE THIS DATE FROM TK HOLDINGS INC, MONROE WI. THEY ARE DEBTORS, WHO FILED CHAPTER 11 FOR TAKATA CORPORATION. THEY STATED TAKE YOUR VEHICLE TO LOCAL DEALERSHIP IMMEDIATELY TO SCHEDULE A FREE REPAIR ON A DEFECTIVE OR POTENTIALLY DEFECTIVE AIRBAG INFLATOR. I'VE KNOWN ABOUT THIS ISSUE FOR OVER A YEAR NOW. GENERAL MOTORS, TAKATA CORPORATION ARE IN A LEGAL BATTLE OVER THIS AIRBAG ISSUE. IN THE MEAN TIME CITIZENS OF OUR GREAT COUNTRY ARE GOING TO BE IMPACTED BY THIS CONTINUE DELAY, AND COST OF ALL PARTIES INVOLVED TO PREVAIL IN COURT. THE FEDERAL GOVT. NATL. TRANSPORTATION SAFETY BOARD NEEDS TO INTERVENE, AND STOP THIS AIRBAG CRISIS. I WOULD CLASSIFY THIS MATTER AS A NATL. SECURITY & SAFETY THREAT BECAUSE LIVES WILL BE LOSS. EVERYONE INVOLVED ARE NOT ACCEPTING RESPONSIBILITY FOR THIS SERIOUS DILEMMA, DUE TO ONGOING LITIGATION. I VERY RARELY ALLOW ANYONE NOW IN MY TRUCK, MINOR FENDER-BENDER, AIRBAG DEPLOYMENT, EXTRACTION METAL SHRAPNEL. MAYBE I CAN GET OUR WASHINGTON DC SENATOR OF OUR DISTRICT APPLY A LITTLE PRESSURE ON THIS MATTER, ELECTION TIME IN 2018, LOOK WHAT HAPPENED ON 10/07/17, STATE OF VIRGINIA , STATE OF NEW JERSEY, BOTH REPUBLICANS LOSS TO DEMOCRATS. THIS IS NOT TIME FOR POLITICS. LIVES ARE AND WILL BE LOSS.

NHTSA ODI #11044769

83,000 miles · Nov 8, 2017
Air BagsCrash

TL* TAKATA RECALL. THE CONTACT OWNS A 2011 CHEVROLET SILVERADO 1500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS); HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. WHILE IDLING AT A STO…

Read full complaint

TL* TAKATA RECALL. THE CONTACT OWNS A 2011 CHEVROLET SILVERADO 1500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS); HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. WHILE IDLING AT A STOP LIGHT, ANOTHER VEHICLE SUDDENLY DROVE THROUGH A RED LIGHT AND GOT T-BONED AND PUSHED INTO THE CONTACT'S VEHICLE. THE CONTACT'S VEHICLE WAS SEVERELY DAMAGED ON THE FRONT DRIVER'S SIDE. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE OTHER TWO VEHICLES INVOLVED IN THE CRASH WERE TOTALED. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED PRIOR TO THE CRASH. THE CONTACT TOOK THE VEHICLE TO AN UNKNOWN INDEPENDENT REPAIR SHOP IN ST. GEORGE, UTAH WHERE IT WAS DIAGNOSED THAT THE RIMS, GRILL, TIRES, AND HEADLIGHT CAPSULE NEEDED TO BE REPLACED. THE PARTS WERE REPLACED AND THE AIR BAG SENSOR SYSTEM WAS REPROGRAMMED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI #11044410

65,000 miles · Nov 8, 2017
Air Bags

TAKATA RECALL-MANUFACTURER HAS NOT REMEDIED

NHTSA ODI #11044394

Mileage unknown · Nov 7, 2017
Air Bags

TL* THE CONTACT OWNS A 2011 CHEVROLET SILVERADO 1500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED A LOCAL DEALER (SCOGGINS CHEV…

Read full complaint

TL* THE CONTACT OWNS A 2011 CHEVROLET SILVERADO 1500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED A LOCAL DEALER (SCOGGINS CHEVROLET BUICK, 1424 N YOUNG BLVD, CHIEFLAND, FL 32626 352-493-4263) AND WAS INFORMED THAT THE PARTS WERE ON BACKORDER. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. *TT CONSUMER STATED PART IS NOT ON BACKORDER IT SIMPLY IS NOT AVAIBLABLE. UPDATED 8/7/18*JB

NHTSA ODI #11044161

Mileage unknown · Nov 7, 2017
Air Bags

TAKATA RECALL - RECALL WAS ISSUED 5/27/16 AND CHEVROLET DEALER IN OCALA AND RECALL WEBSITE TOLD ME THERE IS NO REMEDY YET. I THINK SINCE MORE THAN 1 1/2 YEARS HAVE PASSED THAT THIS IS AN EXCESSIVE PERIOD OF TIME TO HAVE COME UP WITH A REMEDY WHEN MY SAFETY IS AT RISK AND DOES THIS AFFECT THE VALUE OF MY VEHICLE FOR TRADE-IN OR …

Read full complaint

TAKATA RECALL - RECALL WAS ISSUED 5/27/16 AND CHEVROLET DEALER IN OCALA AND RECALL WEBSITE TOLD ME THERE IS NO REMEDY YET. I THINK SINCE MORE THAN 1 1/2 YEARS HAVE PASSED THAT THIS IS AN EXCESSIVE PERIOD OF TIME TO HAVE COME UP WITH A REMEDY WHEN MY SAFETY IS AT RISK AND DOES THIS AFFECT THE VALUE OF MY VEHICLE FOR TRADE-IN OR RESALE?

NHTSA ODI #11044134

Mileage unknown · Nov 3, 2017
Air Bags

TAKATA RECALL GMC HILLTOP. CONTINUES TO INFORM ME THERE IS NO RESOLUTION FOR REPLACING THE AIRBAG

NHTSA ODI #11043067

Official recalls

4

21V050000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.

21V054000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.

11V007000 · Suspension:rear:axle:spindle

Jan 6, 2011

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, COLORADO, EXPRESS, SILVERADO, SUBURBAN, TAHOE; AND GMC CANYON, SIERRA, SAVANA, YUKON AND YUKON XL VEHICLES. THE REAR AXLE CROSS PINS WERE NOT PROPERLY HEAT TREATED AND COULD FRACTURE AND BECOME DISPLACED WITHIN THE REAR AXLE. SHOULD THE PIN SHIFT OUT OF POSITION, IT COULD CREATE AN INTERFERENCE CONDITION AND CAUSE THE REAR AXLE TO LOCK.

Consequence & remedy

Consequence: THE DRIVER MAY NOT BE ABLE TO MAINTAIN DIRECTIONAL CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.

Remedy: DEALERS WILL INSTALL A NEW REAR AXLE CROSS PIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

10V643000 · Suspension:rear:axle:spindle

Dec 17, 2010

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC ESCALADE EXT, CHEVROLET AVALANCHE, SILVERADO LD AND GMC SIERRA LD VEHICLES. THE REAR AXLE CROSS PINS WERE NOT PROPERLY HEAT TREATED AND COULD FRACTURE AND BECOME DISPLACED WITHIN THE REAR AXLE. SHOULD THE PIN SHIFT OUT OF POSITION, IT COULD CREATE AN INTERFERENCE CONDITION AND CAUSE THE REAR AXLE TO LOCK.

Consequence & remedy

Consequence: THE DRIVER MAY NOT BE ABLE TO MAINTAIN DIRECTIONAL CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.

Remedy: DEALERS WILL INSTALL A NEW REAR AXLE CROSS PIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.