2006 Chevrolet Silverado 1500

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500 EQUIPPED WITH CAPITOL PRECISION TRAC II TIRES, SIZE: 265/70R17 (NA). WHILE DRIVING 65 MPH, THE VEHICLE FAILED TO REMAIN IN POSITION AND THE STEERING WHEEL VIBRATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE THREAD ON THE FRONT PASSENGER SIDE TIRE HAD SEPARATED AND NEEDED TO BE REPLACED. THE TIRE WAS REPLACED WITH THE SPARE TIRE. THE TIRE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 14T013000 (TIRES), BUT THE TIRE WAS NOT INCLUDED. THE VEHICLE FAILURE MILEAGE WAS 100,000 AND THE TIRE FAILURE MILEAGE WAS 20,000.

BRAKE LINES ARE RUSTING AWAY. I NOTICED A SOFT BRAKE PEDAL, ON MY WAY BACK TO ST. LOUIS FROM ATLANTA, GA. I NOTICED FLUID UNDER THE TRUCK IN MY DRIVEWAY AFTER I GOT HOME. I STARTED LOOKING AROUND THE TRUCK. THE MASTER CYLINDER WAS LOW ON FLUID. NO WARNING LIGHT CAME ON. I NOTICED FLUID UNDER THE DRIVERS SIDE DOOR. IT WAS BRAKE FLUID COMING FROM A RUSTED THRU BRAKE LINE. AFTER INSPECTION, ALL OF THE OTHER BRAKE LINES WERE BADLY RUSTED. THE REPAIR(REICHERS AUTO AND TIRE-WASHINGTON, MO) SHOP IS REPLACING ALL OF THE BRAKE LINES DUE TO HEAVY RUST. COST IS GOING TO BE OVER $800.

REAR BRAKE LINE RUSTED COMPLETELY THROUGH DURING NORMAL DRIVING OPERATION WHICH RESULTED IN A BRAKE FLUID SPILL AND REDUCED BRAKING CAPACITY OF THE VEHICLE. VEHICLE WAS ON A CITY STREET TURNING ONTO A HIGHWAY WHEN THE INCIDENT HAPPENED. FURTHER INSPECTION FOUND THAT ALL BRAKE LINES ON THE VEHICLE HAD EXTENSIVE CORROSION AND HAD TO BE REPLACED. VEHICLE HAD 120,000 MILES ON IT WITH NO ACCIDENT HISTORY.

AS I COME TO A STOP, THE BRAKE PEDAL PULSATES FROM ABS ACTIVATION INCREASING BRAKING TIME AND DISTANCE. THE GROUND IS DRY WHILE THIS HAPPENS. AFTER A WHILE THE AND LIGHT COMES ON. WAS TOLD BY A DEALER MECHANIC IT WAS A BAD ABS SENSOR AND TO REPLACE HUB. I DID AND NOW, TWO YEARS LATER, IT IS HAPPENING AGAIN. NOW I'M BEING TOLD IT IS A PROBLEM WITH ELEMENTS IN MY AREA, BEING IN A SNOWBELT STATE, GETTING INTO WHEEL SPEED SENSOR AND BLOCKING SIGNAL. SAME EXACT SYMPTOMS AS LAST TIME, DIFFERENT DIAGNOSIS. NEITHER TIME DID THEY PLUG INTO MY TRUCK FOR CODES. BOTH TIMES, I HAVE TO OPEN MY WALLET FOR FAULTY PRODUCTS.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD AN ABNORMAL GRINDING NOISE COMING FROM THE WHEEL AREA. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HUB ASSEMBLY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07E106000 (WHEELS). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 104,649.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. AS SOON AS THE VEHICLE WAS STARTED, THE DRIVER'S SEAT HEATED UP AUTOMATICALLY. WHEN THE VEHICLE WAS TURNED OFF, THE SEAT HEATER ACTIVATED ON HIGH. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED AND REMAINED ON FOR THE PAST TWO WEEKS. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 105,647.

THERE WERE TWO INCIDENTS WITH THE 2006 SILVERADO AND BOTH RELATED TO THE STEEL BRAKE LINES. A) DURING INNER CITY DRIVING, THE REAR BRAKES FAILED. CAUSE WAS A BROKEN STEEL BRAKE LINE FROM THE ABS MODULE TO THE REAR 'Y' BLOCK. BELIEVE THE LEAK WAS CLOSER TO THE REAR AXLE. NEW STAINLESS STEEL LINE WAS INSTALLED. B) AGAIN DURING INNER CITY DRIVING, THE FRONT BRAKES FAILED. ONE OF THE STEEL LINES FAILED. IT LOOKED LIKE THE ISSUE WAS NEAR THE ABS MODULE. BUT IN REMOVING ALL OF THE REMAINING BRAKE LINES IT WAS HARD TO TELL WHAT WAS THE EXACT FAILURE POINT. WITH THE EXCEPTION OF THE COATED STEEL LINES ON THE REAR AXLE; ALL OF THE ORIGINAL GENERAL MOTORS LINES WERE IN RUSTED/CORRODED STATE. ALL STEEL BRAKE LINES HAVE BEEN REPLACED WITH STAINLESS STEEL LINES. THE TRUCK BELONGS TO MY FATHER [XXX] AND WAS DRIVING IT BOTH INSTANCES. HIS EMAIL IS: [XXX]@AOC.GOV INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *JB