Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 109 of 469 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Visibility. Review the 113 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
62 crash reports8 fire reports33 injury reports
What owners actually said
469 reports
Mileage unknown · May 25, 2001
Visibility
WINDSHIELD WIPERS COMES ON INTERMITTENTLY. DEALERSHIP IS AWARE OF PROBLEM.*AK CONSUMER STATESHE CONTACTED THREE DEALERS FOR THE PART, TWO OF THEM STATED THE PARTS WERE ON BACK ODER, CONSUMER WAS TOLD BY MANUFACTURER THAT BECUASE HIS VEHICLE WAS BILT AT A CERTAIN PLANT, THERE IS NO RECALL, HOWEVER THERE ARE RECALLS FOR THE PA…
Read full complaint
WINDSHIELD WIPERS COMES ON INTERMITTENTLY. DEALERSHIP IS AWARE OF PROBLEM.*AK CONSUMER STATESHE CONTACTED THREE DEALERS FOR THE PART, TWO OF THEM STATED THE PARTS WERE ON BACK ODER, CONSUMER WAS TOLD BY MANUFACTURER THAT BECUASE HIS VEHICLE WAS BILT AT A CERTAIN PLANT, THERE IS NO RECALL, HOWEVER THERE ARE RECALLS FOR THE PART BUT VEHICLE HAD TO BUILT AT A CERTAIN PLANT IN ODER FOR RECALL TO APPLY TO CONSUMER'S VEHICLE.*JB
NHTSA ODI #889201
Mileage unknown · May 22, 2001
Air Bags
WHILE TRAVELING ON HIGHWAY, VEHICLE DROPPED OFF THE PAVEMENT INTO THE GRAVELS CAUSING VEHICLE TO TURN SIDEWAYS BACK ONTO THE PAVEMENT AND HITTING AN ENBANKMENT ON THE OTHER SIDE OF THE ROAD AND THEN TURNING THE VEHICLE ON ITS SIDE ONTO THE HIGHWAY IN WHICH AIR BAG DID NOT DEPLOY. *JB
NHTSA ODI #561298
Mileage unknown · May 10, 2001
Visibility
NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK
NHTSA ODI #745154
Mileage unknown · May 3, 2001
Engine And Engine CoolingFuel System, Gasoline
INTAKE GASKET BURNED OUT AND ALLOWED ANTI-FREEZE IN ENGINE OIL. ENGINE HAD TO BE REPLACED DUE TO THIS DEFECT. MECHANIC PUT IN SAME TYPE OF INTAKE GASKET BACK INTO VEHICLE IN ORDER FOR ENGINE TO BE COVERED UNDER A WARRANTY. *AK
NHTSA ODI #887383
Mileage unknown · Apr 27, 2001
Visibility
WHILE DRIVING IN RAINY WEATHER CONDITIONS WINDSHIELD WIPERS BECOME INOPERABLE CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS.*AK
NHTSA ODI #886995
Mileage unknown · Apr 6, 2001
Visibility
WINDSHIELD WIPERS ARE INOPERABLE, CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS.*AK
NHTSA ODI #885295
Mileage unknown · Feb 27, 2001
Power Train
WHEN 4- WHEEL DRIVE IS NEEDED TRANSFER CASE DOES NOT KICK FRONT END INTO GEAR DUE TO ACTUATOR VACUUM FAILING. CONSUMER NOTED THAT ACTUATOR HAS BEEN REPLACED BEFORE, AND CURRENTLY NEEDED TO BE REPLACED. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
NHTSA ODI #881616
Mileage unknown · Feb 26, 2001
Service Brakes, Hydraulic
WHEN BRAKES WERE PRESSED VEHICLE AUTOMATICALLY TURNED LEFT. DEALER HAD ADVISED CONSUMERTHAT PROBLEM WAS DUE TO A RUST PROBLEM WHICH WERE NATURAL CAUSES, AND WOULD DISAPPEAR IN A COUPLE OF DAYS. DEFECT WAS STILL PRESISTED, AND CONSUMER WAS INVOLVED IN AN ACCIDENT BECAUSE HE DID NOT HAVE FULL CONTROL OF VEHICLE. *AK
NHTSA ODI #881471
Mileage unknown · Feb 21, 2001
Power Train
TRANSMISSION EXPERIENCED HARD SHIFTS BETWEEN 1ST AND 2ND GEARS. ALSO, ENGINE SERVICE AND CHECK LIGHTS WOULD COME ON INTERMITTENTLY. DEALER INFORMED CONSUMER THAT TRANSMISSION BODY NEEDED TO BE REPLACED FOR SECOND TIME. PLEASE FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK
NHTSA ODI #881031
Mileage unknown · Feb 18, 2001
Power TrainSteering
THIS VEHICLE HAS HAD BOTH DRIVE LINES REPLACED, THE FOUR WHEEL DRIVE, THE TORQUE CONVERTER, THREE DIFFERENT IDLER ARMS, THREE SETS OF TIRES AND TWO ALIGNMENTS, THE REAR END HAS BEEN REBUILT DUE TO WORN OUT PINION BEARING, TWO PULLEYS ARE SQUEELING, THE BRAKES HAVE TO BE PRESSED EXTREMELY HARD AND ABS KICKS IN ALL THE TIME, TIRES…
Read full complaint
THIS VEHICLE HAS HAD BOTH DRIVE LINES REPLACED, THE FOUR WHEEL DRIVE, THE TORQUE CONVERTER, THREE DIFFERENT IDLER ARMS, THREE SETS OF TIRES AND TWO ALIGNMENTS, THE REAR END HAS BEEN REBUILT DUE TO WORN OUT PINION BEARING, TWO PULLEYS ARE SQUEELING, THE BRAKES HAVE TO BE PRESSED EXTREMELY HARD AND ABS KICKS IN ALL THE TIME, TIRES RUBBED THE FENDER, ALTENATOR SQUEELING. I FEEL THAT THIS VEHICLE IS SUBSTANDARD AND THAT MOST OF THE REPAIRS HAVE BEEN MADE OUT OF POCKET DUE TO VEHICLE NOT BEING UNDER WARRANTY WHEN THEY OCCURRED. I HAVE WRITTEN AN E MAIL TO CHEVROLET SERVICE TO FIND OUT WHAT I CAN DO WITH THIS TRUCK.
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: ELECTRIC PICKUP TRUCKS. A CONDITION IN WHICH THE FUEL-FIRED HEATER FILL PIPE GROUND STRAP CONTACTS THE REAR PASSENGER SIDE BRAKE PIPE.
Consequence & remedy
Consequence: THIS COULD WEAR OFF THE CORROSION PROTECTION ON THE BRAKE PIPE, LEADING TO PREMATURE CORROSION AND EVENTUAL LOSS OF BRAKE PIPE INTEGRITY. WHEN BRAKE PIPE INTEGRITY IS LOST, BRAKE FLUID LEAKAGE CAN OCCUR.
Remedy: DEALERS WILL RELOCATE THE GROUND STRAP ATTACHMENT, INSPECT THE BRAKE PIPE FOR WEAR, AND REPLACE THE BRAKE PIPE IF NECESSARY.
VEHICLE DESCRIPTION: GENERATION 1 ELECTRIC LIGHT DUTY PICKUP TRUCKS. THESE VEHICLES WERE BUILT WITH A CHARGE PORT ASSEMBLY THAT COULD FAIL DURING A CHARGING EVENT.
Consequence & remedy
Consequence: HEAT COULD BUILD UP WITHIN THE CHARGE PORT AND A FIRE COULD RESULT.
Remedy: DEALERS WILL REPLACE THE CHARGE PORT ASSEMBLY WITH A REDESIGNED CHARGE PORT ASSEMBLY.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH ELECTRIC DRIVE. RAPID FOGGING OF THE INTERIOR GLASS CAN OCCUR WITHIN TWO MINUTES AFTER THE HEAT IS TURNED ON IF (1) THE OUTSIDE TEMPERATURE IS BETWEEN 35 AND 76 DEGREES FAHRENHEIT AND (2) WATER HAS COLLECTED ON THE HEAT EXCHANGER DURING PREVIOUS OPERATION OF THE AIR CONDITIONING.
Consequence & remedy
Consequence: IF RAPID FOGGING WERE TO OCCUR DURING DRIVING, IT COULD OBSTRUCT THE DRIVER'S VISION INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: OWNERS ARE BEING PROVIDED WITH A CAUTION LABEL AND SUPPLEMENTAL INSERT FOR THEIR OWNER'S MANUAL ADVISING THEM TO FOLLOW A "STOP AND WAIT" PROCEDURE TO HELP AVOID WINDOW FOGGING WHILE DRIVING.
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER PICKUP TRUCKS EQUIPPED WITH 4.3L ENGINES. THE FRONT BRAKE LINE CAN CONTACT THE LEFT-HAND SIDE OF THE ENGINE OIL PAN CAUSING THE BRAKE LINE TO WEAR TO THE POINT OF BRAKE FLUID LOSS DURING BRAKE APPLICATION.
Consequence & remedy
Consequence: BRAKE FLUID LOSS CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE STOPPING DISTANCES RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE OIL PAN AND THE BRAKE LINE. IF THE CLEARANCE IS 6MM OR LESS, DEALERS WILL INSTALL AN ADDITIONAL BRAKE LINE CLIP AND IF THERE WAS CONTACT BETWEEN THE OIL PAN AND BRAKE LINE, THE FRONT BRAKE LINE WILL BE REPLACED.
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
ON FEBRUARY 18, 2004, ODI OPENED THIS RECALL QUERY (RQ) BASED ON TWO FATALITY REPORTS INVOLVING MY 1997 GM S-10 PICKUP TRUCKS.EACH REPORT ALLEGED THAT THE BELTED DRIVER OCCUPANT WAS EJECTED IN A MULTIPLE-ROTATION ROLLOVER CRASH.THE MY 1997 S/T SERIES PICKUPS USE AN ENERGY-ABSORBING LOOP IN THE DRIVER SEAT BELT THAT ALLOWS THE WEBBING TO ELONGATE UP TO 10 INCHES (TO MITIGATE DRIVER INJURY IN FRONTAL CRASHES).GM ALSO USED THIS ENERGY-ABSORBING LOOP SEAT BELT DESIGN IN MY1997 S/T SERIES UTILITY VEHICLES (CHEVROLET BLAZER, GMC JIMMY AND OLDSMOBILE BRAVADA).GM CONDUCTED A SAFETY RECALL CAMPAIGN (03V-117) TO REPLACE THE DRIVER SEAT BELT IN THESE UTILITY VEHILCES BASED ON A HIGHER FATALITY RATE OF EJECTED BELTED DRIVERS IN ROLLOVER CRASHES.BOTH FATAL CRASHES ARE SEVERE ROLLOVER CRASHES (MULTIPLE-ROTATION ROLLOVER) AND BOTH VEHICLES SUSTAINED DAMAGE TO THE ROOF STRUCTURE.ODI REVIEWED THE FIELD DATA PERFORMANCE OF THE SUBJECT VEHICLES AND COMPARED THEM TO PEER VEHICLES USING NHTSA'S FATALITY ANALYSIS REPORTING SYSTEM (FARS) DATABASE.THE FARS DATA DID NOT INDICATE A FIELD PERFORMANCE TREND FOR THE SUBJECT VEHICLE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Seat Belts:front
ON FEBRUARY 18, 2004, ODI OPENED THIS RECALL QUERY (RQ) BASED ON TWO FATALITY REPORTS INVOLVING MY 1997 GM S-10 PICKUP TRUCKS.EACH REPORT ALLEGED THAT THE BELTED DRIVER OCCUPANT WAS EJECTED IN A MULTIPLE-ROTATION ROLLOVER CRASH.THE MY 1997 S/T SERIES PICKUPS USE AN ENERGY-ABSORBING LOOP IN THE DRIVER SEAT BELT THAT ALLOWS THE WEBBING TO ELONGATE UP TO 10 INCHES (TO MITIGATE DRIVER INJURY IN FRONTAL CRASHES).GM ALSO USED THIS ENERGY-ABSORBING LOOP SEAT BELT DESIGN IN MY1997 S/T SERIES UTILITY VEHICLES (CHEVROLET BLAZER, GMC JIMMY AND OLDSMOBILE BRAVADA).GM CONDUCTED A SAFETY RECALL CAMPAIGN (03V-117) TO REPLACE THE DRIVER SEAT BELT IN THESE UTILITY VEHILCES BASED ON A HIGHER FATALITY RATE OF EJECTED BELTED DRIVERS IN ROLLOVER CRASHES.BOTH FATAL CRASHES ARE SEVERE ROLLOVER CRASHES (MULTIPLE-ROTATION ROLLOVER) AND BOTH VEHICLES SUSTAINED DAMAGE TO THE ROOF STRUCTURE.ODI REVIEWED THE FIELD DATA PERFORMANCE OF THE SUBJECT VEHICLES AND COMPARED THEM TO PEER VEHICLES USING NHTSA'S FATALITY ANALYSIS REPORTING SYSTEM (FARS) DATABASE.THE FARS DATA DID NOT INDICATE A FIELD PERFORMANCE TREND FOR THE SUBJECT VEHICLE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Seat Belts:front:webbing
ON FEBRUARY 18, 2004, ODI OPENED THIS RECALL QUERY (RQ) BASED ON TWO FATALITY REPORTS INVOLVING MY 1997 GM S-10 PICKUP TRUCKS.EACH REPORT ALLEGED THAT THE BELTED DRIVER OCCUPANT WAS EJECTED IN A MULTIPLE-ROTATION ROLLOVER CRASH.THE MY 1997 S/T SERIES PICKUPS USE AN ENERGY-ABSORBING LOOP IN THE DRIVER SEAT BELT THAT ALLOWS THE WEBBING TO ELONGATE UP TO 10 INCHES (TO MITIGATE DRIVER INJURY IN FRONTAL CRASHES).GM ALSO USED THIS ENERGY-ABSORBING LOOP SEAT BELT DESIGN IN MY1997 S/T SERIES UTILITY VEHICLES (CHEVROLET BLAZER, GMC JIMMY AND OLDSMOBILE BRAVADA).GM CONDUCTED A SAFETY RECALL CAMPAIGN (03V-117) TO REPLACE THE DRIVER SEAT BELT IN THESE UTILITY VEHILCES BASED ON A HIGHER FATALITY RATE OF EJECTED BELTED DRIVERS IN ROLLOVER CRASHES.BOTH FATAL CRASHES ARE SEVERE ROLLOVER CRASHES (MULTIPLE-ROTATION ROLLOVER) AND BOTH VEHICLES SUSTAINED DAMAGE TO THE ROOF STRUCTURE.ODI REVIEWED THE FIELD DATA PERFORMANCE OF THE SUBJECT VEHICLES AND COMPARED THEM TO PEER VEHICLES USING NHTSA'S FATALITY ANALYSIS REPORTING SYSTEM (FARS) DATABASE.THE FARS DATA DID NOT INDICATE A FIELD PERFORMANCE TREND FOR THE SUBJECT VEHICLE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
PE96061 · Seat Belt Webbing Separation
Opened Oct 25, 1996 · Closed Feb 28, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
ON 9/9/96 NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) PERFORMED A 35 MPH BARRIER CRASH TEST WITH A 1997 CHEVROLET S10 EXTENDED CAB PICKUP.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
1997 Chevrolet S10 Problems, Complaints & Recalls | Skip That Year
Illustration