IllustrationSPARE TIRE MOUNT FAILED.
1990 Chevrolet S10
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1990 Chevrolet S10 do not stand out strongly from the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all S10 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 29 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports2 injury reports
What owners actually said
29 reportsBRAKES FAILED TWICE; BOTH INCIDENTS OCCURED WITHIN TWO YEARS, RESULTING IN COLLISIONS.
BRAKES FAILED.
ABS BRAKES FAILED TWICE, ONCE RESULTING IN A COLLISION/INJURIES.
INSTRUMENT PANEL FAILED HAD TO HAVE CLUSTER MODULE REPLACED.
GAS TANK RUSTED OUT.
WHILE DRIVING AT 35 MPH THE DEFECTIVE ABS BRAKING SYSTEM MALFUNCTIONED, CAUSING THE BRAKING SYSTEM TO BE INOPERATIVE, RESULTIN IN ROLLOVER. ALSO, THE DRIVER'S SEAT BELT DID NOT PROTECT THE OCCUPANT, CAUSING THE OCCUPANT TO FLY OUT OF THE DRIVER'S SEATBELT AND ONTO THE PASSENGER'S SIDE. *AK
GAS TANK EXPLODES IF AN ELECTRICAL CONNECTOR IS CONNECTED BACKWARDS BECAUSE 12 VOLTS IS SUPPLIED TO THE SENSOR CIRCUIT, CAUSING IT TO BURN OUT AND EMIT SPARKS. *AK
WINDSHIELD WIPER MOTOR FAILED.
WHILE DRIVING APPROX 30 MPH, NEEDING TO MAKE A QUICK STOP, APPLIED BRAKES, NO REACTION, DID NOT STOP. MECHANIC CHANGED PADS/DRUMS, INTERMITTENT PROBLEM. DEFECT HAS REOCCURRED AFTER 1 YEAR. THIS DEFECT CAN RESULT IN AN ACCIDENT. *AK
Official recalls
296V195000 · Steering:gear Box:shaft Sector
Oct 8, 1996
THE INTERMEDIATE STEERING SHAFT LOOSENS AT THE STEERING SHAFT TO STEERING GEAR COUPLING. WITH THIS LOOSENESS, THE YOKE PINCH BOLT CAN WEAR ON THE SPLINES OF THE SHAFT UNTIL THERE IS NO LONGER AN INTERFERENCE BETWEEN THE SPLINES AND THE BOLT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE BODY TO CHASSIS MOVEMENT ALLOWING THE STEERING SHAFT TO SEPARATE FROM THE STEERING GEAR WHICH CAN RESULT IN A LOSS OF STEERING CONTROL.
Remedy: DEALERS WILL RETORQUE THE UPPER AND LOWER BOLTS TO CORRECT SPECIFICATIONS.
93V008000 · Engine And Engine Cooling:cooling System:fan
Jan 14, 1993
THE ENGINE COOLING FAN BLADES BREAK AS A RESULT OF FATIGUE AND/OR VEHICLE INDUCED STRESS.
Consequence & remedy
Consequence: IF THE BLADE BREAKAGE OCCURS WHILE THE HOOD IS OPEN, APERSON WORKING UNDER THE HOOD OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCKAND INJURED BY THE BLADE SEGMENT.
Remedy: INSTALL A NEWLY DESIGNED FAN ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA94029 · Engine Compartment Fires
Opened Jul 29, 1994 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
AN ALLEGED MALFUNCTION IN THE ATLERNATOR RESULTING IN ENGINE COMPARTMET FIRES.
EA92015 · High Idle Flare
Opened May 22, 1992 · Closed May 28, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92001 · High Idle Flare
Opened Jan 7, 1992 · Closed May 22, 1992
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE91057 · Headlight Switch Failure
Opened Mar 6, 1991 · Closed Jul 12, 1991
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available