NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
9 reportsClear category filter193,000 miles · Apr 13, 2016
EngineFuel System, GasolineFire
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, A STRONG BURNING FUEL ODOR WAS PRESENT INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT VALVE COVER GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS NOT…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, A STRONG BURNING FUEL ODOR WAS PRESENT INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT VALVE COVER GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 193,000.
NHTSA ODI #10855363
45,513 miles · Jan 31, 2014
EngineFuel System, GasolineFireInjury
WENT OUT TO START CAR. TURNED ON KEY, SET RADIO. THEN TURNED KEY TO START ENGINE WITH A RESULTING LOUD EXPLOSION FROM UNDER HOOD. IN HURRY TO GET UP HOOD AND EXTINGUISH FIRE EXPERIENCED BURNS ON HANDS FROM LIFTING HOOD AND A FUEL LINE THAT WAS SQUIRTING FUEL/FLAMES. FIRE EXTINGUISHER EXTINGUISHED FLAMES. UPPER INTAKE MANIFOLD IS…
Read full complaint
WENT OUT TO START CAR. TURNED ON KEY, SET RADIO. THEN TURNED KEY TO START ENGINE WITH A RESULTING LOUD EXPLOSION FROM UNDER HOOD. IN HURRY TO GET UP HOOD AND EXTINGUISH FIRE EXPERIENCED BURNS ON HANDS FROM LIFTING HOOD AND A FUEL LINE THAT WAS SQUIRTING FUEL/FLAMES. FIRE EXTINGUISHER EXTINGUISHED FLAMES. UPPER INTAKE MANIFOLD IS BLOW APART WITH MULTIPLE SENSORS DESTROYED. THANK GOD THIS HAPPENED AT HOME WITH AN EXTINGUISHER HANDY AND NOT DRIVING DOWN THE ROAD WITH NO TIME TO SLOW DOWN. *TR
NHTSA ODI #10562438
150,000 miles · Jun 5, 2013
Electrical SystemEngineFuel System, GasolineFire
I STARTED THE CAR UP AND I HEARD A POP AND SAW A BLUE FLAME. AFTER REPAIRING THE CAR COSTING $3240.74 IT ONCE AGAIN CAUGHT ANOTHER FIRE PLEASE HELP. *TR
NHTSA ODI #10515289
Mileage unknown · Sep 23, 2010
Electrical SystemFuel System, Gasoline
3 NEW FUEL PUMP RAILS INSTALLED FROM RECALL ( GAS GAUGE DOES NOT WORK). THE PROBLEM STILL OCCURS, THE GAUGE WORKS FOR A SMALL AMOUNT OF TIME AFTER NEW FUEL RAIL IS INSTALLED, THEN FAILS, LEAVING NO WAY TO CHECK THE AMOUNT OF FUEL LEFT IN THE TANK. *TR
NHTSA ODI #10357096
133,153 miles · Sep 7, 2010
Fuel System, Gasoline
GAS GAUGE ALL OF A SUDDEN STOPPED WORKING AND I RAN OUT OF GAS! *TR
NHTSA ODI #10354375
100,000 miles · Aug 28, 2010
Fuel System, Gasoline
MY 2002 CHEVY MONTECARLO SS THE GAS GAUGE IS VERY ERRATIC IT SHOWS YOU HAVING A FULL TANK OF A GAS WHEN YOU DON'T IT BOUNCES BACK AND FORTH LIKE THIS NO MATTER IF IT'S FULL OR NOT VERY FRUSTRATING TO KNOW WHEN TO FILL UP... *TR
NHTSA ODI #10352510
Mileage unknown · Feb 6, 2007
Engine And Engine CoolingFuel System, GasolinePower Train
2002 CHEVROLET MONTE CARLO WITH ABS AND SERVICE ENGINE LIGHT PROBLEMS AND CONCERNS**CC THE TRACTION LIGHT ILLUMINATED AS WELL. THE TRANSMISSION WAS REPLACED 2 MONTHS AFTER THE CONSUMER PURCHASED THE VEHICLE, BECAUSE THE VEHICLE WOULDN'T GO INTO 3RD GEAR. THE STEERING SHAFT WAS LUBRICATED. THE CONSUMER WAS INFORMED THAT THE EBC…
Read full complaint
2002 CHEVROLET MONTE CARLO WITH ABS AND SERVICE ENGINE LIGHT PROBLEMS AND CONCERNS**CC THE TRACTION LIGHT ILLUMINATED AS WELL. THE TRANSMISSION WAS REPLACED 2 MONTHS AFTER THE CONSUMER PURCHASED THE VEHICLE, BECAUSE THE VEHICLE WOULDN'T GO INTO 3RD GEAR. THE STEERING SHAFT WAS LUBRICATED. THE CONSUMER WAS INFORMED THAT THE EBCM NEEDED TO BE REPLACED AND WITHOUT THE REPLACEMENT, THE ABS WOULD NOT WORK SO THE TRACTION CONTROL AND ABS LIGHT WOULD REMAIN ON. THE WATER PUMP AND INTAKE GASKET WAS REPLACED DUE THEM LEAKING. THE FUEL INJECTOR WAS REPLACED DUE TO IT BEING STUCK OPEN. THE TIRE PRESSURE MONITORING LIGHT ILLUMINATED, THE DEALER SEALED THE REAR WHEELS. *JB
NHTSA ODI #10182677
50,000 miles · Feb 5, 2007
Electrical SystemFuel System, GasolineFire
TL *- THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. ON FEBRUARY 3, 2007 THE CONTACT STARTED THE VEHICLE, THEN TURNED IT OFF QUICKLY AFTER REALIZING SHE HAD FORGOTTEN SOMETHING IN HER HOME. THE CONTACT WENT BACK INSIDE THE HOME, THEN RETURNED TO THE VEHICLE. THE CONTACT STARTED THE VEHICLE A SECOND TIME AND HEARD AN EXPLOS…
Read full complaint
TL *- THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. ON FEBRUARY 3, 2007 THE CONTACT STARTED THE VEHICLE, THEN TURNED IT OFF QUICKLY AFTER REALIZING SHE HAD FORGOTTEN SOMETHING IN HER HOME. THE CONTACT WENT BACK INSIDE THE HOME, THEN RETURNED TO THE VEHICLE. THE CONTACT STARTED THE VEHICLE A SECOND TIME AND HEARD AN EXPLOSION COMING FROM UNDER THE VEHICLE LOUD ENOUGH THAT THE NEIGHBORS CAME AND OFFERED ASSISTANCE. WHILE INSIDE THE VEHICLE THE CONTACT SMELLED SMOKE. THE CONTACT'S HUSBAND OPENED THE HOOD AND WITNESSED A FIRE COMING FROM THE ENGINE. THE CONTACT'S HUSBAND USED A FIRE EXTINGUISHER TO PUT OUT THE FIRE. THE VEHICLE WAS TRANSPORTED TO THE RIZZA CHEVROLET 8200 SOUTH HARLEM AVE, BRIDGEVIEW IL 60455, TEL 708-594-9090 FOR SERVICE. THE CONTACT FILED A COMPLAINT WITH GMC #71-478219613, AND WAS TOLD TO WAIT 48 HOURS FOR AN AGENT TO BE ASSIGNED TO THE CASE. THE CONTACT NOTED THAT THERE WAS A RECALL ON THE 2000 MONTE CARLO MODELS FOR SIMILAR PROBLEMS, AND THIS VEHICLE SHOULD BE INCLUDED IN THE RECALL. *AK THE CONSUMER STATED THE FAILURE MAYBE RELATED TO RECALL 04V0900000 UPDATED 02/27/07. *JB
NHTSA ODI #10181715
Mileage unknown · Sep 3, 2003
EquipmentFuel System, GasolineService Brakes, Hydraulic
THESE ISSUES LISTED BELOW ARE TROUBLES I HAVE HAD WITH MY 2002 MONTE CARLO BOUGHT VEHICLE NEW 4/15/02 AND 21/02, FRONT BUMPER PAINT BEGAN TO PEEL. BUMPER REPAINTED./5/02 REAR SPEAKERS BEGIN TO CRACKLE AND QUIT WORKING. REPLACED./30/03 TOOK VEHICLE TO CHEVROLET GARAGE DUE TO VEHICLE PULSATING WHEN STOPPING AND THE CAR HAVIN…
Read full complaint
THESE ISSUES LISTED BELOW ARE TROUBLES I HAVE HAD WITH MY 2002 MONTE CARLO BOUGHT VEHICLE NEW 4/15/02 AND 21/02, FRONT BUMPER PAINT BEGAN TO PEEL. BUMPER REPAINTED./5/02 REAR SPEAKERS BEGIN TO CRACKLE AND QUIT WORKING. REPLACED./30/03 TOOK VEHICLE TO CHEVROLET GARAGE DUE TO VEHICLE PULSATING WHEN STOPPING AND THE CAR HAVING TROUBLE STARTING. FRONT AND REAR ROTORS FOUND WARPED AND RESURFACED. CARS FUEL PRESSURE REGULATOR FOUND TO BE LEAKING DOWN AND WAS REPLACED. 8/21/03 CAR PULSATING AGAIN WHEN STOPPING. RETURNED VECHICLE TO CHEVY GARAGE. FOUND REAR ROTORS RUSTED AGAIN AND REPLACED REAR ROTORS. WAS TOLD TIRES WERE CUPPING IN REAR. ROTATED TIRES ON 8/22/03 AND FOUND SCORE MARK ON REAR DRIVERS SIDE ROTOR. 8/22/03 RETURNED VEHICLE TO CHEVY GARAGE SHOWED SERVICE MANAGER THE DEFECT AND WAS TOLD THE PART WOULD NOT BE REPLACED AT THIS TIME EEVN THOUGH ROTOR WAS SCORED. S.MGR STATED THIS WAS NORMAL CONDITION DUE TO BRAKE PAD METALLIC LINING. 8/24/03 CONTACTED GM CUSTOMER SERVICE ABOUT ISSUE. ASKED TO HAVE NEW ROTORS AND BRAKES PUT ON VEHICLE. RESPONSE WAS "GM IS AWARE OF ISSUES WITH OUR BRAKES AND ROTORS, BUT IF THERE IS NO DEFECT THE PART WOULD NOT BE REPLACED." I RESTATED ABOUT THE SCORE MARK ON THE NEW ROTOR AND WAS TOLD SORRY NOTHING THEY COULD DO AT THIS POINT. 9/2/03 WHILE OIL WAS BEING CHANGED TWO BOLTS WHERE NOTICED MISSING FROM THE TRANSMISSION PAN. WILL BE SERVICED ON 9/4/03 REPAIR PENDING. 9/3/03 VEHICLE HAVING TROUBLE STARTING AGAIN. ENGINE HESITATES FOR 10-20 SEC. WILL BE ADDRESSED ON 9/4/03 THIS VEHICLE ONLY HAS 24,000 MILES ON IT. I NEED NEW BRAKE PADS AND NEW ROTORS DUE TO DEFECTS IN PARTS. VEHICLE HAS 7YR/100,000 MILE WARRANTY. DO I HAVE A LEMON?
NHTSA ODI #10037176
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration