NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
55 reportsClear category filter180,000 miles · Feb 15, 2010
Electrical SystemExterior LightingPower Train
ON MY WAY TO WORK ON MY NORMAL ROUTE BEFORE DAWN, DRIVING DOWN A NARROW CURVY RURAL ROAD RIFE WITH DEER, I FLICKED ON MY HIGH BEAMS AS USUAL. ABOUT 5 SECONDS LATER I LOST ALL MY HEADLIGHTS. SOMEHOW SAFELY PULLED OFF ROAD WITHOUT FALLING INTO THE DITCH AND TURNED OFF VEHICLE. AFTER SEVERAL MINUTES OF TURNING LIGHTS ON AND OFF THE…
Read full complaint
ON MY WAY TO WORK ON MY NORMAL ROUTE BEFORE DAWN, DRIVING DOWN A NARROW CURVY RURAL ROAD RIFE WITH DEER, I FLICKED ON MY HIGH BEAMS AS USUAL. ABOUT 5 SECONDS LATER I LOST ALL MY HEADLIGHTS. SOMEHOW SAFELY PULLED OFF ROAD WITHOUT FALLING INTO THE DITCH AND TURNED OFF VEHICLE. AFTER SEVERAL MINUTES OF TURNING LIGHTS ON AND OFF THE FOG LAMPS CAME ON AND I WAS ABLE TO MAKE IT BACK HOME VERY SLOWLY. SPENT $1000 GETTING A CONTROL MODULE REPLACED. HAD TROUBLE WITH TURN SIGNALS QUITTING RANDOMLY FOR 3 YEARS, HAVE TO TURN ON EMERGENCY FLASHERS IN ORDER TO GET THEM TO WORK. ANOTHER $500 WILL FIX THE PROBLEM BUT SINCE THE CAR IS ONLY WORTH $1500 IT DOESN'T SEEM WORTH IT. THIS CAR IS A PIECE OF JUNK - 2 TRANSMISSIONS, NUMEROUS ELECTRICAL PROBLEMS, 5 STEERING SHAFT REPLACEMENTS... *TR
NHTSA ODI #10310435
95,000 miles · Jul 4, 2009
Electrical SystemService Brakes, Hydraulic
LOSS OF TRACTION CONTROL AND ANTI LOCK BRAKES IN MY CAR. MY VEHICLE HAS ALLOWED THESE SAFETY FEATURES TO QUIT WORKING AND AFTER REPLACING THE PARTS THAT THE DEALER SAID NEEDED TO BE REPLACED, THE VEHICLE'S SYSTEM DOES NOT RECOGNIZE THE NEW SENSOR AND PART, THUS NOT ALLOWING THE TRACTION CONTROL AND ABS TO WORK. AFTER RESEARCHI…
Read full complaint
LOSS OF TRACTION CONTROL AND ANTI LOCK BRAKES IN MY CAR. MY VEHICLE HAS ALLOWED THESE SAFETY FEATURES TO QUIT WORKING AND AFTER REPLACING THE PARTS THAT THE DEALER SAID NEEDED TO BE REPLACED, THE VEHICLE'S SYSTEM DOES NOT RECOGNIZE THE NEW SENSOR AND PART, THUS NOT ALLOWING THE TRACTION CONTROL AND ABS TO WORK. AFTER RESEARCHING THIS ON THE INTERNET, IT SEEMS TO BE A VERY COMMON PROBLEM IN GM VEHICLES. *TR
NHTSA ODI #10275775
36,000 miles · Jun 8, 2009
Electrical SystemFire
TL*THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING 55 MPH, SMOKE APPEARED FROM THE GLOVE COMPARTMENT AND THE ENGINE BURST INTO FLAMES. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE CONTACT HAS GONE BACK AND FORTH WITH THE MANUFACTURER, BUT THEY HAVE NOT INSPECTED THE VEHICLE. FOUR YEARS AFTER THE FIR…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING 55 MPH, SMOKE APPEARED FROM THE GLOVE COMPARTMENT AND THE ENGINE BURST INTO FLAMES. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE CONTACT HAS GONE BACK AND FORTH WITH THE MANUFACTURER, BUT THEY HAVE NOT INSPECTED THE VEHICLE. FOUR YEARS AFTER THE FIRE, THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 09V116000. THE CURRENT AND FAILURE MILEAGES WERE 36,000.
NHTSA ODI #10273139
Mileage unknown · Jan 20, 2009
Electrical System
IS THERE A RECALL FOR THE INSTRUMENT PANEL ON A 2002 MONTE CARLO SS? MY GAUGES STOPPED WORKING TODAY AND I WAS TOLD THERE MAY BE A RECALL. *TR
NHTSA ODI #10255616
35,000 miles · Sep 17, 2008
Electrical SystemExterior Lighting
TURN SIGNAL FAILURE: BEGINNING IN 2005 THROUGH TO 2007 THE TURN SIGNALS WOULD WORK INTERMITTENTLY. WHILE UNDER WARRANTY THE VEHICLE WAS TAKEN TO THE DEALERSHIP. THEY INDICATED THAT THERE WAS NO PROBLEM. ONCE WARRANTY WAS EXPIRED THERE WAS NOTHING I COULD DO. I DID FIND THAT TURNING THE HAZARD SIGNALS ON FOR 5-10 SECONDS WOU…
Read full complaint
TURN SIGNAL FAILURE: BEGINNING IN 2005 THROUGH TO 2007 THE TURN SIGNALS WOULD WORK INTERMITTENTLY. WHILE UNDER WARRANTY THE VEHICLE WAS TAKEN TO THE DEALERSHIP. THEY INDICATED THAT THERE WAS NO PROBLEM. ONCE WARRANTY WAS EXPIRED THERE WAS NOTHING I COULD DO. I DID FIND THAT TURNING THE HAZARD SIGNALS ON FOR 5-10 SECONDS WOULD SOMETIMES CORRECT THE PROBLEM AND THE TURN SIGNAL WOULD WORK. FINALLY AFTER MANY HOURS SEARCHING THE INTERNET I FOUND SEVERAL POSTINGS INDICATING THAT THERE WAS A FAULTY HAZARD LIGHT SWITCH, THE TURN SIGNALS ARE ALSO CONTROLLED BY THE HAZARD LIGHT SWITCH. IN OCTOBER 2007 I SPENT $399 TO HAVE THE HAZARD LIGHT SWITCH REPAIRED. PLEASE INSIST THAT THE DEALERSHIP REPLACE THE HAZARD LIGHT SWITCH AND NOT ADD ON ADDITIONAL PARTS LIKE THE TURN SIGNAL ARM ETC. MY DEALERSHIP FIRST QUOTED ME $850 STATING THAT THE TURN SIGNAL ARM MUST ALSO BE REPLACED TO CORRECT THE ISSUE. SINCE THE REPAIR ALL IS FINE. I DO BELIEVE THAT GM/CHEVROLET SHOULD BE RESPONSIBLE FOR THE COST OF REPAIR SINCE IT IS A DEFECT IN THEIR DESIGN.*TR
NHTSA ODI #10242662
84,000 miles · Jun 16, 2008
Electrical System
SECURITY LIGHT, HAS BEEN ON SEVERAL MONTHS, DEALERS SHIP SAYS THE COMPUTER WILL NOT LET THEM FIND THE PROBLEM, MEAN WHILE NOTHING HAS BEEN DONE, IT REFUSES TO START, I WAIT 10 MINUTES OR SO THEN IT STARTS. *TR
NHTSA ODI #10231196
70,010 miles · Feb 20, 2008
Electrical System
I CAN'T BELIEVE GM IS NOT BEING FORCED TO ISSUE A RECALL ON THEIR CLUSTER PROBLEMS. I'M HAVING THE PROBLEM WITH MY 2002 MONTE CARLO SS. NOT JUST THE SPEEDOMETER, BUT THE OIL PRESSURE, RPMS, AND TEMP. THE ONLY THING ON MY PANEL THAT WORKS IS THE GAS INDICATOR. IT ALL STARTED WHEN I HIT 70,000 AND I'M NOW AT 78,000. THIS IS MAKIN…
Read full complaint
I CAN'T BELIEVE GM IS NOT BEING FORCED TO ISSUE A RECALL ON THEIR CLUSTER PROBLEMS. I'M HAVING THE PROBLEM WITH MY 2002 MONTE CARLO SS. NOT JUST THE SPEEDOMETER, BUT THE OIL PRESSURE, RPMS, AND TEMP. THE ONLY THING ON MY PANEL THAT WORKS IS THE GAS INDICATOR. IT ALL STARTED WHEN I HIT 70,000 AND I'M NOW AT 78,000. THIS IS MAKING ME CRAZY AND OUR LOCAL GM DEALER QUOTED $680 TO REPAIR, AND SAID IT MUST BE REPAIRED AT A GM DEALER BECAUSE OF ALL OF THE WORK AND PROGRAMMING THAT NEEDS TO BE DONE. I LOVED THIS CAR UNTIL THIS MAJOR PROBLEM STARTED. AFTER READING ALL OF THE OTHER ISSUES AND GM'S LACK OF RECALL, I'M REAL TEMPTED TO LEAVE GM -- AND WE'VE BEEN GM FOR THREE GENERATIONS IN MY FAMILY AND THIS. *TR
NHTSA ODI #10218672
Mileage unknown · Jan 13, 2008
Electrical System
PASSLOCK MALFUNCTIONING WITH LOW MILES ON VEHICLE NOT JUST THE DATE BELOW BUT MANY MANY TIMES. *TR
NHTSA ODI #10214640
61,000 miles · Aug 15, 2007
Electrical System
MY WIFE OWNS A 2002 MONTE CARLO WITH 60,00 MILES ON IT THAT SHUTS DOWN NO NOTICE, JUST LIKE YOU TURNED THE KEY OFF. THE LAST EPISODE WAS AT 68 MPH ON AN INTERSTATE. I MANAGED TO COAST THE CAR OVER TO THE EDGE OF THE HIGHWAY UNDER AN OVER PASS, BUT IT WAS A TERRIFYING EVENT. *JB
NHTSA ODI #10199648
50,000 miles · Feb 5, 2007
Electrical SystemFuel System, GasolineFire
TL *- THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. ON FEBRUARY 3, 2007 THE CONTACT STARTED THE VEHICLE, THEN TURNED IT OFF QUICKLY AFTER REALIZING SHE HAD FORGOTTEN SOMETHING IN HER HOME. THE CONTACT WENT BACK INSIDE THE HOME, THEN RETURNED TO THE VEHICLE. THE CONTACT STARTED THE VEHICLE A SECOND TIME AND HEARD AN EXPLOS…
Read full complaint
TL *- THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. ON FEBRUARY 3, 2007 THE CONTACT STARTED THE VEHICLE, THEN TURNED IT OFF QUICKLY AFTER REALIZING SHE HAD FORGOTTEN SOMETHING IN HER HOME. THE CONTACT WENT BACK INSIDE THE HOME, THEN RETURNED TO THE VEHICLE. THE CONTACT STARTED THE VEHICLE A SECOND TIME AND HEARD AN EXPLOSION COMING FROM UNDER THE VEHICLE LOUD ENOUGH THAT THE NEIGHBORS CAME AND OFFERED ASSISTANCE. WHILE INSIDE THE VEHICLE THE CONTACT SMELLED SMOKE. THE CONTACT'S HUSBAND OPENED THE HOOD AND WITNESSED A FIRE COMING FROM THE ENGINE. THE CONTACT'S HUSBAND USED A FIRE EXTINGUISHER TO PUT OUT THE FIRE. THE VEHICLE WAS TRANSPORTED TO THE RIZZA CHEVROLET 8200 SOUTH HARLEM AVE, BRIDGEVIEW IL 60455, TEL 708-594-9090 FOR SERVICE. THE CONTACT FILED A COMPLAINT WITH GMC #71-478219613, AND WAS TOLD TO WAIT 48 HOURS FOR AN AGENT TO BE ASSIGNED TO THE CASE. THE CONTACT NOTED THAT THERE WAS A RECALL ON THE 2000 MONTE CARLO MODELS FOR SIMILAR PROBLEMS, AND THIS VEHICLE SHOULD BE INCLUDED IN THE RECALL. *AK THE CONSUMER STATED THE FAILURE MAYBE RELATED TO RECALL 04V0900000 UPDATED 02/27/07. *JB
NHTSA ODI #10181715
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration