IllustrationMY INSTRUMENT CLUSTER WILL RESET WHILE I AM DRIVING. THE GUAGES WILL SWEEP AND ALL THE WARNING LIGHTS COME ON AND THE CAR WILL DING AS IF IT WAS JUST STARTED HOWEVER THE CAR NEVER STALLS AND THE RADIO STAYS ON ALONG WITH EVERYTHING ELSE.
2002 Chevrolet Monte Carlo
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Monte Carlo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
210–25K
3525–50K
2950–75K
2875–100K
36100–150K
21150K+
170 reports with mileage · 60 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports24 fire reports7 injury reports
Electrical System complaints
55 reportsWAS GOING ABOUT 55-60 MPH DOWN THE HIGHWAY AND MY RPMS STARTED TO DROP AND I LET OFF GAS AND IT JUST DIED. IT CRANKS AND TURNS OVER BUT WILL NOT FIRE
PASSLOCK SYSTEM; CAR WILL RANDOMLY (TEMPERATURE BASED?) REFUSE TO START DUE TO POORLY CONSTRUCTED PASSLOCK SENSOR. I KEEP MY DASH APART SO I CAN POKE AT THE CONTACTS (CORRODED? CHEAP TIN PLATING) TO HOTWIRE MY CAR WHEN IT LOCKS OUT. TOOK 20 MINUTES TO GO SEE IF MY WIFE WAS OK AT THE ER, THANKS CHEVY!
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THERE WERE VARIOUS ELECTRICAL SHORTS IN THE VEHICLE, WHICH PREVENTED THE WINDOWS FROM GOING UP AND DOWN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND SEVERAL INDEPENDENT MECHANICS FOR DIAGNOSTIC TESTING. THE MANUFACTURER PROVIDED NO SOLUTION AND THE …
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THERE WERE VARIOUS ELECTRICAL SHORTS IN THE VEHICLE, WHICH PREVENTED THE WINDOWS FROM GOING UP AND DOWN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND SEVERAL INDEPENDENT MECHANICS FOR DIAGNOSTIC TESTING. THE MANUFACTURER PROVIDED NO SOLUTION AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.
HAD ISSUES WITH ELECTRICAL IN 2015 IN WHICH GAS GAUGE AND OTHER GAUGES, SPEEDOMETER WERE "BOUNCING". AUTO REPAIR DETERMINED IT WAS THE FUEL PUMP AND REPLACED IT TO THE TUNE OF $600. THIS YEAR, WHILE DRIVING AT HIGHWAY SPEEDS WHEN CAR SUDDENLY LOOSES ALL POWER AND TURNS OFF. BROUGHT BACK TO SAME REPAIR SHOP WHO STATED BATTERY CAB…
Read full complaint
HAD ISSUES WITH ELECTRICAL IN 2015 IN WHICH GAS GAUGE AND OTHER GAUGES, SPEEDOMETER WERE "BOUNCING". AUTO REPAIR DETERMINED IT WAS THE FUEL PUMP AND REPLACED IT TO THE TUNE OF $600. THIS YEAR, WHILE DRIVING AT HIGHWAY SPEEDS WHEN CAR SUDDENLY LOOSES ALL POWER AND TURNS OFF. BROUGHT BACK TO SAME REPAIR SHOP WHO STATED BATTERY CABLES WERE LOOSE AND TIGHTENED THEM FREE OF CHARGE. NOW 4-5 MONTHS LATER AND SAME ISSUE IS OCCURRING WHICH HAPPENED 4 TIMES TODAY. TWICE WHILE MAKING A HARD TURN. TERMINALS ARE COMPLETELY TIGHT. EARLIER THIS YEAR COULD NOT TURN IGNITION KEY AND TAPPED IT WITH A HAMMER TO GET IT TO TURN. I HAVE BEEN READING QUITE A BIT ABOUT AN IGNITION SWITCH RECALL, BUT NO MENTION OF IT BY THE DEALER FOR TWO RECALL FIXES THIS YEAR REGARDING THE IGNITION KEY AND FOB, AND SOME COVER ON THE ENGINE. *TR
ISSUES WITH THE BCM AND PASSLOCK SYSTEM. THE CAR WHILE ON AND DRIVING WILL DISPLAY SECURITY ALONGSIDE THE BATT GAUGE QUITS WORKING. IF SHUT OFF CAR WILL NOT START, AND LIGHT STAY ON. I HAVE TO DISCONNECT THE BATT FOR SOME TIME. WITH THE THE AUTO LIGHTS SOMETIMES COME ON DURING MID DAY WITH THE SUN SHINING. THIS IS BECOMING A HAS…
Read full complaint
ISSUES WITH THE BCM AND PASSLOCK SYSTEM. THE CAR WHILE ON AND DRIVING WILL DISPLAY SECURITY ALONGSIDE THE BATT GAUGE QUITS WORKING. IF SHUT OFF CAR WILL NOT START, AND LIGHT STAY ON. I HAVE TO DISCONNECT THE BATT FOR SOME TIME. WITH THE THE AUTO LIGHTS SOMETIMES COME ON DURING MID DAY WITH THE SUN SHINING. THIS IS BECOMING A HASSLE. I'D RATHER PURCHASE ANOTHER CAR THAN GO THREW DEALERSHIP HOOPS.
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE HEAD LAMP LENSES HAD BEEN OXIDIZED AND THAT THERE WAS A FILM BUILD UP WHICH AFFECTED THE VISIBILITY OF THE LOW BEAMS WHILE THE VEHICLE WAS IN MOTION CAUSING THE LIGHTING TO BE DIM. THE CONTACT ALSO STATED THAT THE KEY LESS ENTRY FUNCTION FAILED INTERM…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE HEAD LAMP LENSES HAD BEEN OXIDIZED AND THAT THERE WAS A FILM BUILD UP WHICH AFFECTED THE VISIBILITY OF THE LOW BEAMS WHILE THE VEHICLE WAS IN MOTION CAUSING THE LIGHTING TO BE DIM. THE CONTACT ALSO STATED THAT THE KEY LESS ENTRY FUNCTION FAILED INTERMITTENTLY AND THAT UPON ENTERING THE VEHICLE, IT WOULD NOT START. THE CONTACT WAS ABLE TO UTILIZE THE OWNERS MANUAL TO OVERRIDE THE SYSTEM BY EITHER DISCONNECTING AND RECONNECTING THE BATTERY CABLE OR RESETTING THE COMPUTER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 2,400.
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE JERKED AND THE COMPUTER TURNED ON AND OFF AS SMOKE EMITTED UNDER THE HOOD. THE CONTACT EXTINGUISHED THE FIRE. A POLICE AND A FIRE REPORT WERE NOT FILED AND THERE WERE NO INJURIES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE JERKED AND THE COMPUTER TURNED ON AND OFF AS SMOKE EMITTED UNDER THE HOOD. THE CONTACT EXTINGUISHED THE FIRE. A POLICE AND A FIRE REPORT WERE NOT FILED AND THERE WERE NO INJURIES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE FAILURE MILEAGE WAS APPROXIMATELY 119,000.
I HAVE A 2002 CHEVY MONTE CARLO LS THAT HAS BEEN EXPERIENCING ELECTRICAL PROBLEMS. THE CRUISE CONTROL LIGHT COMES ON SPONTANEOUSLY WITHOUT THE BUTTON BEING PRESSED AND WHEN THIS LIGHT SPONTANEOUSLY COMES ON, THE HEATING/COOLING SYSTEMS DO NOT TURN ON WHEN DIAL IS TURNED ON. WHEN THE CRUISE CONTROL LIGHT TURNS OFF, THE HEATING…
Read full complaint
I HAVE A 2002 CHEVY MONTE CARLO LS THAT HAS BEEN EXPERIENCING ELECTRICAL PROBLEMS. THE CRUISE CONTROL LIGHT COMES ON SPONTANEOUSLY WITHOUT THE BUTTON BEING PRESSED AND WHEN THIS LIGHT SPONTANEOUSLY COMES ON, THE HEATING/COOLING SYSTEMS DO NOT TURN ON WHEN DIAL IS TURNED ON. WHEN THE CRUISE CONTROL LIGHT TURNS OFF, THE HEATING/COOLING SYSTEM WORKS WITHOUT ANY FURTHER PROBLEM. I HAVE CALLED TWO DIFFERENT DEALERSHIPS IN MY AREA AND SPOKE TO TWO DIFFERENT SERVICE ADVISORS AND THEY ARE NOT AWARE OF ANY ISSUES YET THERE ARE FORUMS WHERE OTHER OWNERS HAVE BEEN EXPERIENCING THIS PROBLEM FOR SOME TIME NOW.
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE VEHICLE STALLED NUMEROUS TIMES RANDOMLY FOR MONTHS. THE DEALER WAS NOTIFIED OF THE FAILURE SEVERAL TIMES, BUT DID NOT PROVIDE A PERMANENT REMEDY. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE RECA…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE VEHICLE STALLED NUMEROUS TIMES RANDOMLY FOR MONTHS. THE DEALER WAS NOTIFIED OF THE FAILURE SEVERAL TIMES, BUT DID NOT PROVIDE A PERMANENT REMEDY. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE RECALL REPAIR WAS PERFORMED, BUT THE FAILURE RECURRED WEEKS LATER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Official recalls
415V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
02V222000 · Air Bags:frontal
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.