NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
233 reports86,000 miles · May 23, 2007
Exterior LightingFire
I WAS DRIVING MONTE CARLO SS 2000 THE OTHER DAY AND SMOKE STARTED COMING OUT OF THE STEERING WHEEL. I INHALED A MOUTHFUL, THE THROAT BURNED ALL DAY. ALMOST IN AN ACCIDENT. THE WINDSHIELD WIPERS STARTED RUNNING AND WOULD NOT SHUT OFF, SO I REMOVED THE FUSE. I NOTICED MY HEADLIGHTS NO LONGER WORKED ALSO. WHEN I GOT HOME I OPENED…
Read full complaint
I WAS DRIVING MONTE CARLO SS 2000 THE OTHER DAY AND SMOKE STARTED COMING OUT OF THE STEERING WHEEL. I INHALED A MOUTHFUL, THE THROAT BURNED ALL DAY. ALMOST IN AN ACCIDENT. THE WINDSHIELD WIPERS STARTED RUNNING AND WOULD NOT SHUT OFF, SO I REMOVED THE FUSE. I NOTICED MY HEADLIGHTS NO LONGER WORKED ALSO. WHEN I GOT HOME I OPENED THE DASHBOARD AND STEERING WHEEL COVER , AND THE BURNT SMELL WAS COMING FROM THE TURN SIGNAL SWITCH. I OPENED THE SWITCH, AND EVERYTHING INSIDE WAS MELTED. I NOTIFIED GENERAL MOTORS RIGHT AWAY. THEY TOLD ME TO TAKE IT TO A GM DEALER , SO I DID. BUT THE GM DEALER WANTED TO CHARGE A $100 TO DIAGNOSE. NONE OF THE FUSES ON THE CAR BLEW OUT WHEN THE SWITCH STARTED ON FIRE. I FOUND A USED SWITCH FOR $85.00 SO IT COST LESS THE DEALER TO TELL ME IT WAS BAD. IT WAS A FAULTY SWITCH , AND GM TOLD ME I COULD ONLY HAVE A GM DEALER FIX IT. I TOLD THEM I COULD NOT JUSTIFY OR AFFORD PAYING MORE FOR THE DIAGNOSIS THAN THE USED PART. GM TOLD ME I COULD NOT PUT A NEW SWITCH IN MYSELF OR I WON'T BE REIMBURSED IF THERE WAS A RECALL. THIS WAS A VERY SERIOUS SAFETY ISSUE. GM WON'T HELP ME OUT ANYWAY AND THEY DIDN'T REALLY SEEM TO CARE ABOUT THIS ISSUE. SO I EITHER GO TO THE DEALER AND PAY $500 TO GET IT FIXED OR PAY $85 AND DO MYSELF. THEY PUT ME IN A SITUATION SO THEY DIDN'T HAVE TO DO ANYTHING ABOUT THIS PROBLEM. I TOLD THEM I WOULD SEND THE SWITCH TO THEM, BUT THEY DIDN'T WANT IT. NEITHER COULD I HAVE ANOTHER MECHANIC REPLACE IT EXCEPT FOR GM. THIS WAS REDICULOUS. SOMEONEWAS GOING TO GET KILLED IF THIS HAPPENED AGAIN.*AK
NHTSA ODI #10191590
49,500 miles · Sep 6, 2006
Visibility
DT*: THE CONTACT STATED THE DRIVER AND PASSENGER FRONT WINDOWS WERE INOPERABLE. AN INDEPENDENT REPAIR SHOP DETERMINED THE CABLE MOTORS NEEDED TO BE REPLACED. THE CONSUMER STATED THE WINDOWS FAILED NUMEROUS TIMES. UPDATED 09/22/06. *JB
NHTSA ODI #10167477
Mileage unknown · Jul 27, 2006
Fuel System, Gasoline
WE HAVE 2 MONTE CARLOS, A 2000 AND 2004, BOTH OF THESE HAD SENSORS GO OUT OF THE GAS GAUGE. IN TALKING WITH SOME OTHERS, THEIRS DID TOO. ROYAL CHEVROLET IN BLOOMINGTON, IN CHARGES ALMOST $500 FOR THIS. I FEEL SINCE THIS IS HAPPENING A LOT TO THIS BRAND OF CAR, IT SHOULD BE RECALLED. *NM
NHTSA ODI #10163593
72,289 miles · Jul 26, 2006
Exterior Lighting
DT*: THE CONTACT STATED, WHILE HAVING AN OIL CHANGE AT AN INDEPENDENT SERVICE STATION, THE MECHANIC NOTICED AN ODOR OF SOMETHING BURNING IN THE VICINITY OF THE STEERING WHEEL. THERE WAS NO SMOKE OR FIRE PRESENT. UPON INSPECTION, THERE WAS A MALFUNCTION OF THE TURN SIGNAL DIMMER SWITCH ON THE STEERING COLUMN. THE DEALER AND MANUF…
Read full complaint
DT*: THE CONTACT STATED, WHILE HAVING AN OIL CHANGE AT AN INDEPENDENT SERVICE STATION, THE MECHANIC NOTICED AN ODOR OF SOMETHING BURNING IN THE VICINITY OF THE STEERING WHEEL. THERE WAS NO SMOKE OR FIRE PRESENT. UPON INSPECTION, THERE WAS A MALFUNCTION OF THE TURN SIGNAL DIMMER SWITCH ON THE STEERING COLUMN. THE DEALER AND MANUFACTURER WERE CONTACTED. THERE ARE NO RECALLS IN EFFECT.
NHTSA ODI #10163479
125,000 miles · Jun 26, 2006
Seats
DRIVER SEAT FAILURE- IT JUST PLAIN BROKE. I WEIGH 240 LBS, AND THE DRIVER'S SEAT JUST BROKE UNDER MY WEIGHT GETTING IN. IT IS NOW IN PIECES. THE SEAT FRAME CAME APART AT A WELD NEAR THE FRONT LEFT CORNER. THIS POTENTIALLY IS AN UNSAFE CONDITION IN THAT I DON'T KNOW IF THE SEAT BELTS WILL CONTINUE TO RESTRAIN ME PROPERLY. I AM…
Read full complaint
DRIVER SEAT FAILURE- IT JUST PLAIN BROKE. I WEIGH 240 LBS, AND THE DRIVER'S SEAT JUST BROKE UNDER MY WEIGHT GETTING IN. IT IS NOW IN PIECES. THE SEAT FRAME CAME APART AT A WELD NEAR THE FRONT LEFT CORNER. THIS POTENTIALLY IS AN UNSAFE CONDITION IN THAT I DON'T KNOW IF THE SEAT BELTS WILL CONTINUE TO RESTRAIN ME PROPERLY. I AM HAVING IT FIXED, BUT I DROVE AROUND FOR 20,000 MILES IN THIS CONDITION. *NM
NHTSA ODI #10160790
124,000 miles · Jun 26, 2006
Exterior Lighting
TURN SIGNAL FLASHER - INOPERATIVE. ALSO AFFECTS 4-WAY EMERGENCY FLASHER. THE TURN SIGNAL FLASHER UNIT IS EMBEDDED IN THE DASH- AS PART OF THE FOUR-WAY EMERGENCY FLASHER. THE FLASHER UNIT HAS FAILED, AND I CAN'T GET TO THE UNIT TO REPLACE IT. AS A RESULT, MY TURN SIGNALS DO NOT WORK. I HAVE SCHEDULED A REPLACEMENT TIME WITH THE…
Read full complaint
TURN SIGNAL FLASHER - INOPERATIVE. ALSO AFFECTS 4-WAY EMERGENCY FLASHER. THE TURN SIGNAL FLASHER UNIT IS EMBEDDED IN THE DASH- AS PART OF THE FOUR-WAY EMERGENCY FLASHER. THE FLASHER UNIT HAS FAILED, AND I CAN'T GET TO THE UNIT TO REPLACE IT. AS A RESULT, MY TURN SIGNALS DO NOT WORK. I HAVE SCHEDULED A REPLACEMENT TIME WITH THE DEALER, BUT AM OPERATING IN THIS IMPAIRED CONDITION WHILE WAITING TO GET IT FIXED. THE INFORMATION ABOUT REPLACING A FLASHER IS NOT IN THE OPERATOR'S MANUAL. *NM
NHTSA ODI #10160787
74,000 miles · May 30, 2006
Steering
VERY HARD TURNING ESPECIALLY WHEN COLD. LOUD WINING NOISES WHEN TURNING WHEEL. WAS UNABLE TO CHECK FLUID LEVEL DUE TO PUMP BEING LOCATED UNDER THE REAR OF THE ENGINE COMPARTMENT. WAS DIAGNOSED AS LEAKING HOSE LEADING TO RACK UNIT AND PUMP FAILURE. THAT WAS REPLACED IN APRIL 2004. CAR WAS JUST DIAGNOSED WITH BAD RACK UNIT AND PU…
Read full complaint
VERY HARD TURNING ESPECIALLY WHEN COLD. LOUD WINING NOISES WHEN TURNING WHEEL. WAS UNABLE TO CHECK FLUID LEVEL DUE TO PUMP BEING LOCATED UNDER THE REAR OF THE ENGINE COMPARTMENT. WAS DIAGNOSED AS LEAKING HOSE LEADING TO RACK UNIT AND PUMP FAILURE. THAT WAS REPLACED IN APRIL 2004. CAR WAS JUST DIAGNOSED WITH BAD RACK UNIT AND PUMP AGAIN IN MAY 2006. MILEAGE AT FIRST INCIDENT WAS 52000, CAR NOW HAS 74000 WITH THE SAME SYMPTOMS. $1800 EST FOR REPAIR THAT ONLY LASTS 22000 MILES??? *JB
NHTSA ODI #10158531
60,000 miles · May 30, 2006
Steering
STEERING PROBLEMS CLUNKING NOISES WHEN MOVING, TURNING EITHER FORWARD OR BACKWARD. GETS MUCH WORSE WHEN THE WEATHER IS COLD. *JB
NHTSA ODI #10158527
60,000 miles · Apr 15, 2006
Engine And Engine Cooling
ENGINE FAILURE ON A 2000 MONTE CARLO SS WITH ONLY 60,000 MILES. I REALIZE I WAS OUT OF WARRENTY, BUT TO HAVE TO REPLACE AN ENTIRE ENGINE THAT BASICALLY DISINTEGRATED FROM UNDER ME IS NOT SOMETHING I EVER THOUGHT I WOULD HAVE TO DO ON THIS VEHICLE. I AM LEFT HUNG OUT TO DRY BY GM. *NM
NHTSA ODI #10155407
60,000 miles · Nov 6, 2005
Fuel System, Gasoline
NHTSA#04V09000, I JUST PAID $ 247.94 + TAX TO FIX MY 2000 MONTE CARLO (60,000 MILES) WITH THE ABOVE MENTIONED RECALL. WAS IT POSSIBLE MY AUTO WAS MISSED IN THIS RECALL? HAVE THERE BEEN MORE COMPLAINTS REGARDING THIS RECALL? *NM
NHTSA ODI #10141860
Official recalls
5Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Feb 24, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration