NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
45 reportsClear category filter170,000 miles · Jan 16, 2015
Electrical System
TL* THE CONTACT OWNS A 2000 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE SECURITY WARNING LIGHT ILLUMINATED. IN ADDITION, THE VEHICLE HESITATED TO RESTART AFTER BEING SHUT OFF. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAG…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE SECURITY WARNING LIGHT ILLUMINATED. IN ADDITION, THE VEHICLE HESITATED TO RESTART AFTER BEING SHUT OFF. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT UNKNOWN WIRES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
NHTSA ODI #10672967
Mileage unknown · Nov 13, 2014
Electrical System
2000 CHEVROLET MONTE CARLO STOPS WHILE DRIVING DOWN THE HIGHWAY, LOOSE POWER STEERING AND BRAKES*CW THE CONSUMER IS SEEKING REIMBURSEMENT FOR THE REPLACEMENT OF THE IGNITION SWITCH. *JB
NHTSA ODI #10653281
Mileage unknown · Nov 12, 2014
Electrical System
CONSUMER WRITING IN REGARDS TO 2000 MONTE CARLO. THE CONSUMER NO LONGER OWNS THE VEHICLE. *KL THE CONSUMER STATED SHE KEEPS GETTING RECALL NOTICES. *JB
NHTSA ODI #10651235
165,000 miles · Nov 10, 2014
Electrical SystemFuel/propulsion System
HAD TO CHARGE BATTERY SO I COULD TAKE CAR IN FOR IGNITION RECALL. SINCE I DON'T USE THE CAR MUCH ANYMORE. UPON TRYING TO START VEHICLE, ENGINE BACKFIRED AND UPPER INTAKE MANIFOLD EXPLODED AND PIECES ALL OVER THE DRIVEWAY. THIS IS THE SAME ISSUE AS DESCRIBED IN THE 2004 RECALL WHICH WAS PERFORMED ON THE FUEL PRESSURE REGULATOR…
Read full complaint
HAD TO CHARGE BATTERY SO I COULD TAKE CAR IN FOR IGNITION RECALL. SINCE I DON'T USE THE CAR MUCH ANYMORE. UPON TRYING TO START VEHICLE, ENGINE BACKFIRED AND UPPER INTAKE MANIFOLD EXPLODED AND PIECES ALL OVER THE DRIVEWAY. THIS IS THE SAME ISSUE AS DESCRIBED IN THE 2004 RECALL WHICH WAS PERFORMED ON THE FUEL PRESSURE REGULATOR. SINCE THE RECALL. I DID HAVE TO REPLACE THE FUEL PRESSURE REGULATOR AGAIN AROUND 2011. I ALSO HAD REPLACED THE UPPER AND LOWER INTAKE GASKETS THAT WERE FAULTY OEM PARTS. THE UPPER PLASTIC MANIFOLD WAS REPLACED TO THE NEWER DESIGN. ALTHOUGH IT BEING PLASTIC IS JUST AN ENGINEERING CATASTROPHE STILL DOESN'T SOLVE THE PROBLEM WITH WARPING FROM HEAT. ANYWAY. HERE'S MY DIAGNOSIS. FUEL INJECTORS CONTINUED TO SPRAY FUEL INTO ENGINE AFTER THE FIRST ATTEMPT OF STARTING VEHICLE CAUSED BY A WEAK BATTERY. I SAY THIS BECAUSE AFTER TURNING THE KEY OFF AFTER THE FIRST ATTEMPT I HEARD THE FUEL PUMPING FOR AT LEAST 10 SECONDS. THIS IS NOT NORMAL. AFTER 1 MINUTE I TRIED TO RESTART AND THATS WHEN PARTS STARTED FLYING. GOOD THING NO HELPERS HAD THEIR HEADS UNDER THE HOOD WHEN THIS HAPPENED. *TR
NHTSA ODI #10654028
145,127 miles · Oct 28, 2014
Electrical SystemElectronic Stability Control (esc)
THIS VEHICLE KEPT CUTTING OFF ON ME WHILE GOING 55 MPH DOWN THE ROAD. I TOOK IT TO HUBERT VESTER CHEVROLET AND THEY COULD FIND NOTHING WRONG. THEY REPLACED THE SWITCH AT A COST OF $388.98 INVOICE NO 73404C THIS STILL DID NOT FIX MY VEHICLE. TO THIS DAY IT IS STILL CUTTING OFF WHILE GOING DOWN THE ROAD AT 55 MPH I AM SCARED TO D…
Read full complaint
THIS VEHICLE KEPT CUTTING OFF ON ME WHILE GOING 55 MPH DOWN THE ROAD. I TOOK IT TO HUBERT VESTER CHEVROLET AND THEY COULD FIND NOTHING WRONG. THEY REPLACED THE SWITCH AT A COST OF $388.98 INVOICE NO 73404C THIS STILL DID NOT FIX MY VEHICLE. TO THIS DAY IT IS STILL CUTTING OFF WHILE GOING DOWN THE ROAD AT 55 MPH I AM SCARED TO DRIVE BUT COULD NOT SELL IT FOR THIS REASON. I HAVE HAD THE CAR ALL THIS TIME AND NOW FIND OUT THAT IT HAS THIS RECALL FOR CUTTING OFF WHILE GOING DOWN THE ROAD. I WOULD LIKE A REFUND OF MY MONEY AS THEY DID NOT FIX MY VEHICLE.
NHTSA ODI #10651213
Mileage unknown · Oct 22, 2014
Electrical SystemFuel/propulsion SystemSeat Belts
AFTER I CONTACTED THE DEALER, THE APPOINTMENT WAS MADE TO REPAIR ALL RECALL ISSUES. RECEIVED NOTIFICATION THAT ALL PARTS WERE AT THE DEALERSHIP. ONCE I ARRIVED AT THE DEALER, WAS TOLD IT WOULD BE A THREE HOUR WAIT. DROVE APPROX. 100 MILES TO DEALER (BILL GATTON CHEVROLET-CADILLAC). ONE RECALL ISSUE WAS RESOLVED, RESULTING IN…
Read full complaint
AFTER I CONTACTED THE DEALER, THE APPOINTMENT WAS MADE TO REPAIR ALL RECALL ISSUES. RECEIVED NOTIFICATION THAT ALL PARTS WERE AT THE DEALERSHIP. ONCE I ARRIVED AT THE DEALER, WAS TOLD IT WOULD BE A THREE HOUR WAIT. DROVE APPROX. 100 MILES TO DEALER (BILL GATTON CHEVROLET-CADILLAC). ONE RECALL ISSUE WAS RESOLVED, RESULTING IN ANOTHER APPOINTMENT TO BE MADE WHEN OTHER PARTS ARRIVED. NO PRECAUTIONS WERE MADE TO ENSURE VEHICLE PROTECTED AGAINST SERVICE DEPARTMENT INJURY TO VEHICLE, IE, NO PAPER MATS PLACED IN CAR, DIRT INSIDE CAR, AND KEYS LEFT IN THE VEHICLE ON THE DEALER LOT. THIS VEHICLE HAS BEEN MAINTAINED IN A PRISTINE CONDITION, (51,000 ACTUAL MILES). HAS NEVER BEEN DRIVEN ON SALT OR UNDER ANY BAD WEATHER CONDITIONS. THE DEALER EVEN COMMENTED THAT THE VEHICLE APPEARED TO BE BRAND NEW. I WOULD WELCOME A CUSTOMER SATISFACTION SURVEY FOR THIS DEALERSHIP. *TR
NHTSA ODI #10649334
85,000 miles · Oct 2, 2014
Electrical System
TL* THE CONTACT OWNS A 2000 CHEVROLET MONTE CARLO. WHILE THE VEHICLE WAS IN THE PARK POSITION, IT AUTOMATICALLY SHUT OFF WITH A FALSE READING AND WAS UNABLE TO RECOGNIZE THE ORIGINAL VEHICLE KEY. THE CONTACT HAD TO WAIT SEVERAL MINUTES UNTIL THE COMPUTER AUTO REPROGRAMMED. THE DEALER STATED THAT THE IGNITION SWITCH NEEDED TO BE …
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET MONTE CARLO. WHILE THE VEHICLE WAS IN THE PARK POSITION, IT AUTOMATICALLY SHUT OFF WITH A FALSE READING AND WAS UNABLE TO RECOGNIZE THE ORIGINAL VEHICLE KEY. THE CONTACT HAD TO WAIT SEVERAL MINUTES UNTIL THE COMPUTER AUTO REPROGRAMMED. THE DEALER STATED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.
NHTSA ODI #10640783
Mileage unknown · Oct 1, 2014
Air BagsElectrical SystemEngineCrashInjury
TL* THE CONTACT OWNS A 2000 CHEVROLET MONTE CARLO SS. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE ENGINE STALLED AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT WAS ABLE TO MERGE TO SIDE OF ROAD AND RESTARTED THE VEHICLE. THE PROBLEM OCCURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. TH…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET MONTE CARLO SS. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE ENGINE STALLED AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT WAS ABLE TO MERGE TO SIDE OF ROAD AND RESTARTED THE VEHICLE. THE PROBLEM OCCURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE IGNITION SWITCH FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. IN ADDITION, THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE CRASHED INTO ANOTHER AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED BACK, NECK AND PAIN TO BOTH ARMS NO MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS NOT FAILED. THE CONTACT BELIEVED THAT THE FAILURE WAS DIRECTLY RELATED TO RECALL NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN. UPDATED 12/9/14*CN UPDATED 6/1/2015 *JS
NHTSA ODI #10640587
211,809 miles · Sep 25, 2014
Electrical System
TL* THE CONTACT OWNS A 2000 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO REPLACED THE IGNITION CYLINDER. THE CONTACT PREVIOUSLY RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: (ELECTRICAL SYSTEM); HOWEVER, THE PART WAS NOT AVA…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO REPLACED THE IGNITION CYLINDER. THE CONTACT PREVIOUSLY RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: (ELECTRICAL SYSTEM); HOWEVER, THE PART WAS NOT AVAILABLE TO REMEDY THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 211,809. UPDATED 12/02/14.*JB
NHTSA ODI #10638863
100,000 miles · Sep 11, 2014
Electrical SystemFire
TL* THE CONTACT OWNS A 2000 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT AFTER PARKING AND EXITING THE VEHICLE SHE RETURNED LATER TO DISCOVER THAT THE VEHICLE HAD CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FLAMES. AFTER INSPECTING THE VEHICLE THE CONTACT DISCOVERED THAT WIRING IN THE ENGIN…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT AFTER PARKING AND EXITING THE VEHICLE SHE RETURNED LATER TO DISCOVER THAT THE VEHICLE HAD CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FLAMES. AFTER INSPECTING THE VEHICLE THE CONTACT DISCOVERED THAT WIRING IN THE ENGINE COMPARTMENT HAD OVERHEATED AND CAUGHT ON FIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 100,000. UPDATED 12/30/14*CN UPDATED 5/28/2015 *JS
NHTSA ODI #10632517
Official recalls
5Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Feb 24, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration