UPON COLD START, IDLE RACED AT 2800 RPM AND WOULDN'T DROP TO NORMAL 800 RPM EVEN AFTER BRAKING AND BRIEF STEPS ON GAS PEDAL. RACING EVEN CONTINUED WHEN CAR SHIFTED INTO NEUTRAL FROM DRIVE. PROBLEM CONTINUES EVEN AFTER DEALER SERVICING ON 11/24/2000WHERE SERVICE BULLETINS CHECKED, FINDING NOTHING ($46.41 CHARGE) AND THROTTLE BODY…
Read full complaint
UPON COLD START, IDLE RACED AT 2800 RPM AND WOULDN'T DROP TO NORMAL 800 RPM EVEN AFTER BRAKING AND BRIEF STEPS ON GAS PEDAL. RACING EVEN CONTINUED WHEN CAR SHIFTED INTO NEUTRAL FROM DRIVE. PROBLEM CONTINUES EVEN AFTER DEALER SERVICING ON 11/24/2000WHERE SERVICE BULLETINS CHECKED, FINDING NOTHING ($46.41 CHARGE) AND THROTTLE BODY CLEANED AND LINKAGES LUBED. DANGEROUS CONDITION CONTINUES. ONLY SOLUTION I HAVE FOUND--TURN ON IGNITION, LET CAR IDLE RACE A FEW MINUTES, THEN TURN OFF IGNITION. WHEN IGNITION IS THEN TURN ON AGAIN, IDLE APPEARS TO FUNCTION NORMALLY AT AROUND 800 RPM. OTHERS, INCLUDING SENIOR CITIZENS, MAY NOT DISCOVER THIS FIX AND CONFRONT AN OUT OF CONTROL, NONE BREAKABLE CAR RESULTING IN SERIOUS COLLISION. SUSPECT SOME OTHER PROBLEM, POSSIBLY DEFECTIVE COMPUTER CHIP--WHATEVER ALLOWS IDLE SPEED TO DROP AFTER WARM UP UNDER COLD CONDITION.*AK
NHTSA ODI #738575
Mileage unknown · Jan 31, 2000
Electrical SystemEngine And Engine CoolingEquipment
FUEL FILTER FAILED. YH
NHTSA ODI #549938
Mileage unknown · Aug 2, 1999
Vehicle Speed Control
ACCELERATOR CABLE HAS BROKEN TWICE, AT 33,000 MILES AND AT 49,000 MILES, CAUSING LOSS OF CONTROL. *AK
NHTSA ODI #844017
Mileage unknown · Feb 8, 1999
Electrical SystemVehicle Speed Control
WHILE DRIVING VEHICLE WILL SURGE FORWARD AND BACKWARD, WHICH MAY CAUSE LOSS OF VEHICLE CONTROL. DEALER RESTARTED THE COMPUTER AND CHANGED SPARK PLUGS. BEEN TO DEALER 6 TIMES.DEALER CANNOT DETERMINE PROBLEM. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #834612
Mileage unknown · Aug 15, 1998
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
ENGINE CHECK LIGHT COMES ON, CAR RUNS ROUGH, ENGINE SPEED VARIES WITH FAST IDLE, ENGINE STOPS WHILE CAR IS MOVING - LOSS OF POWER STEERING AND BRAKES, HARD TO START - TAKES SEVERAL TRIES, RANDOM ENGINE SURGING - 3 NEAR MISSES - ENGINE WILL SPEED UP TO 3000 RPM WITHOUT WARNING.
NHTSA ODI #539858
Mileage unknown · Dec 15, 1997
Vehicle Speed Control
CRUISE CONTROL GOT STUCK ,WILL NOT DISENGAGE OR RECOVER. HAD TO STEP ON ACCELERATOR FOR ABOUT 1 MINUTE. DEALER CANNOT DUPLICATE PROBLEM. *AK
THESE VEHICLES WERE ASSEMBLED WITH ONE OF THE FOUR BRAKE BOOSTER TABS NOT PROPERLY LOCATED IN THE FRONT OF DASH REINFORCEMENT ASSEMBLY.
Consequence & remedy
Consequence: IF THIS CONDITION WERE PRESENT IN A SITUATION WHERE STOPPING DISTANCES WERE SMALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT FOR PROPER BOOSTER INSTALLATION. BOOSTERS FOUND TO BE IMPROPERLY LOCATED WILL BE REMOVED AND REINSTALLED PROPERLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA98019 · Degraded Braking Performance
Opened Aug 31, 1998 · Closed Dec 13, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE98023 · Degraded Braking Performance
Opened Apr 23, 1998 · Closed Aug 31, 1998
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
EA96023 · Inappropriate Air Bag Deployment
Opened Sep 27, 1996 · Closed Feb 13, 1998
Status: closed (inferred from source dates) · Air Bags
THE FAILURE RATE (1.25/100K) ON THIS ISSUE IS LOW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITURE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTINUE TO CLOSELY MONITOR THIS ISSUE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED IN THE PUBLIC FILE.
1996 Chevrolet Monte Carlo Problems, Complaints & Recalls | Skip That Year
Illustration