IllustrationDT*: THE CONTACT STATED THE VEHICLE STALLED IMMEDIATELY UPON STARTING THE ENGINE. THE VEHICLE WAS RESTARTED BUT IMMEDIATELY STALLED AGAIN. THE ABS LIGHT ALSO ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR SERVICE.
1996 Chevrolet Monte Carlo
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Monte Carlo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 155 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports1 fire reports6 injury reports
Service Brakes, Hydraulic complaints
44 reportsBRAKES DO NOT WORK DURING INCLIMATE WEATHER. LOSES A QUART OF OIL PER 500 MILES. BLOWS BY SMOKE THROUGH EXHAUST WHEN STARTING.
I OWN A 1996 Z34 WITH 78000 MILES ON IT. IN THE LAST MONTH MY ANTI LOCK LIGHT KEPT COMING ON IN THE DASH ALSO THE LOW TRACK WOULD COME ON SOMETIMES I TOOK IT TO THE DEALER YESTERDAY 5-2-03 TO HAVE IT CHECKED OUT, THEY FOUND COMPUTER SCAN BRAKE LIGHT SWITCH OPEN. LEFT REAR SENSOR, LEFT REAR EXCESSIVE SPEED VARIATION, LEFT REAR O…
Read full complaint
I OWN A 1996 Z34 WITH 78000 MILES ON IT. IN THE LAST MONTH MY ANTI LOCK LIGHT KEPT COMING ON IN THE DASH ALSO THE LOW TRACK WOULD COME ON SOMETIMES I TOOK IT TO THE DEALER YESTERDAY 5-2-03 TO HAVE IT CHECKED OUT, THEY FOUND COMPUTER SCAN BRAKE LIGHT SWITCH OPEN. LEFT REAR SENSOR, LEFT REAR EXCESSIVE SPEED VARIATION, LEFT REAR OPEN SHORT THEY ORDERED A LEFT REAR HUB AND SENSOR AT MY COST I HAD TO PAY UP FRONT 469.19 FOR THE PART TO BE ORDERED ALSO 65.00 FOR THE LABOR PLUS WHEN THE PART COMES IN I HAVE TO PAY ANOTHER 130.00 FOR R/R THE LEFT REAR HUB . ABOUT A MONTH AGO WHILE PULLING OUT OF THE PARKING LOT AT WORK THE LEFT REAR WHEEL LOCK UP AND STARTED TO SKIP MY FELLOW EMPLOYEES CAME OVER TO MY CAR AND ASK WHAT HAD HAPPENED AN IF I WANTED THEM TO FOLLOW ME HOME AFTER MOVING ANOTHER 10 FEET IT UNLOCKED IT SELF IF THIS WOULD HAVE HAPPENED WHILE DRIVING DOWN THE HIGHWAY WHO KNOWS WHAT WOULD HAVE HAPPENED HAS ANYONE ELSE HAD THIS EXPERIENCE WITH THE 1996 CHEVROLET Z34 ABS. *JB
BRAKING PROBLEMS: I OWN A 1996 CHEVY MONTE CARLO AND I HAVE RECENTLY BEEN EXPERIENCING BRAKING PROBLEMS. THE LOW TRACK LIGHT COMES ON PERIODICALLY AND I LOSE ALMOST ALL OF MY BRAKES. IT IS VERY DIFFICULT TO STOP AND I FEEL THIS NEEDS TO BE INVESTIGATED, IT SEEMS THAT I AM NOT THE ONLY CONSUMER WITH BRAKING CONCERNS AND PROBLEMS…
Read full complaint
BRAKING PROBLEMS: I OWN A 1996 CHEVY MONTE CARLO AND I HAVE RECENTLY BEEN EXPERIENCING BRAKING PROBLEMS. THE LOW TRACK LIGHT COMES ON PERIODICALLY AND I LOSE ALMOST ALL OF MY BRAKES. IT IS VERY DIFFICULT TO STOP AND I FEEL THIS NEEDS TO BE INVESTIGATED, IT SEEMS THAT I AM NOT THE ONLY CONSUMER WITH BRAKING CONCERNS AND PROBLEMS. SOMEONE IS GOING TO GET KILLED. *JB
THIS CAR ALSO HAS BRAKE AND INJECTOR PROBLEMS. I HAD TO REPLACE THE REAR STRUTS IN JUNE TOO. THIS CAR HAS LOW MILEAGE AND I THINK IT IS HIGHLY UNUSAL TO HAVE THESE PROBLEMS.
LOW TRACTION LIGHT COMES ON, THEN BRAKES GO OUT. BUT IF ABS AND TRACTION LIGHTS COME ON TOGETHER, BRAKES SOMETIMES WORK. *AK
PROBLEM WITH BRAKES HAVE ALWAYS BEEN THERE. CONSUMER RAN A RED LIGHT GOING 30 MPH BECAUSE VEHICLE WOULDN'T STOP. BRAKE PEDAL GOES ALL THE WAY TO FLOOR, BUT IT STARTS TO SLOW DOWN. DEALER HAS HOOKED VEHICLE UP TO A DIAGNOSTIC MACHINE, BUT PROBLEM DOESN'T SHOW. DEALER IS CONVINCED THAT'S THE WAY THEY SHOULD WORK.*AK THE CO…
Read full complaint
PROBLEM WITH BRAKES HAVE ALWAYS BEEN THERE. CONSUMER RAN A RED LIGHT GOING 30 MPH BECAUSE VEHICLE WOULDN'T STOP. BRAKE PEDAL GOES ALL THE WAY TO FLOOR, BUT IT STARTS TO SLOW DOWN. DEALER HAS HOOKED VEHICLE UP TO A DIAGNOSTIC MACHINE, BUT PROBLEM DOESN'T SHOW. DEALER IS CONVINCED THAT'S THE WAY THEY SHOULD WORK.*AK THE CONSUMER HAD TWO ACCIDENTS AS THE RESULT OF BRAKE FAILURES. *YH
TOO MUCH PEDAL PRESSURE REQ'D TO STOP CAR. BRAKES/ROTORS WORN OUT AT 36,OOO MILES , FRONT AND REARS. *AK
AT 70208 MILES DEALER REPLACED WATER PUMP AT MY COST, AGAIN AT 91000 MILES DEALER TO REPLACE WATER PUMP, AFTER COMPLAINING TO GM DEALER AGREED TO WARRANTY PARTS AND LABOR. 2 WATER PUMPS IN 91000 MILES! #2 BRAKES AT 48911 DEALER REPLACED FRONT DISC AND WARPED ROTORS. AGAIN AT 91000 DEALER SAYS ROTORS ARE WARPED AGAIN AND REPLA…
Read full complaint
AT 70208 MILES DEALER REPLACED WATER PUMP AT MY COST, AGAIN AT 91000 MILES DEALER TO REPLACE WATER PUMP, AFTER COMPLAINING TO GM DEALER AGREED TO WARRANTY PARTS AND LABOR. 2 WATER PUMPS IN 91000 MILES! #2 BRAKES AT 48911 DEALER REPLACED FRONT DISC AND WARPED ROTORS. AGAIN AT 91000 DEALER SAYS ROTORS ARE WARPED AGAIN AND REPLACED, BOTH TIMES AT MY COST. 2 SETS OF ROTORS IN 91000 MILES! NEITHER TIME WERE THE ROTORS VISUALLY DAMAGED OR WORN FROM DISC PADS.
AT 70208 MILES DEALER REPLACED WATER PUMP AT MY COST, AGAIN AT 91000 MILES DEALER REPLACED WATER PUMP. AFTER COMPLAINING TO GM THE DEALER AGREED TO WARRANTY PARTS AND LABOR. 2 WATER PUMPS IN 91000 MILES! #2 BRAKES AT 48911 DEALER REPLACED FRONT DISC AND WARPED ROTORS. AGAIN AT 91000 MILES DEALER SAYS ROTORS ARE WARPED AGAIN …
Read full complaint
AT 70208 MILES DEALER REPLACED WATER PUMP AT MY COST, AGAIN AT 91000 MILES DEALER REPLACED WATER PUMP. AFTER COMPLAINING TO GM THE DEALER AGREED TO WARRANTY PARTS AND LABOR. 2 WATER PUMPS IN 91000 MILES! #2 BRAKES AT 48911 DEALER REPLACED FRONT DISC AND WARPED ROTORS. AGAIN AT 91000 MILES DEALER SAYS ROTORS ARE WARPED AGAIN AND REPLACED, BOTH TIMES AT COST. 2 SETS OF ROTORS IN 91000 MILES! NEITHER TIME WERE THE ROTORS VISUALLY DAMAGED OR WORN FROM DISC PADS. *NLM **DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS*734293
Official recalls
196V122000 · Service Brakes, Hydraulic:power Assist:vacuum
Jul 1, 1996
THESE VEHICLES WERE ASSEMBLED WITH ONE OF THE FOUR BRAKE BOOSTER TABS NOT PROPERLY LOCATED IN THE FRONT OF DASH REINFORCEMENT ASSEMBLY.
Consequence & remedy
Consequence: IF THIS CONDITION WERE PRESENT IN A SITUATION WHERE STOPPING DISTANCES WERE SMALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT FOR PROPER BOOSTER INSTALLATION. BOOSTERS FOUND TO BE IMPROPERLY LOCATED WILL BE REMOVED AND REINSTALLED PROPERLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA98019 · Degraded Braking Performance
Opened Aug 31, 1998 · Closed Dec 13, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE98023 · Degraded Braking Performance
Opened Apr 23, 1998 · Closed Aug 31, 1998
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
EA96023 · Inappropriate Air Bag Deployment
Opened Sep 27, 1996 · Closed Feb 13, 1998
Status: closed (inferred from source dates) · Air Bags
THE FAILURE RATE (1.25/100K) ON THIS ISSUE IS LOW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITURE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTINUE TO CLOSELY MONITOR THIS ISSUE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED IN THE PUBLIC FILE.