2016 Chevrolet Malibu

I bought this car about 10 days ago. Throat was in pain, coughed up blood, dizzy, sweaty, and shaking. There's gas all over the ground coming from front under hood smelling through the vents. Very loud smelling. Took it to Chevrolet dealership on Covington hwy Decatur GA today and had to leave it there. I still don't feel good and neither the passengers in car. Car could've caught on fire gas leaking out when put in. Never experience this ever in my life. I may have to go to the hospital my chest feel very tight and I had a chronic asthmatic and my child in the car with me that's been on a breathing machine since last night and it's now 3:35 pm next day.

On 04/28/2026, when diagnosing a reoccurring check engine light on the vehicle at a Chevy Certified Service, the mechanic "Borescoped cylinder 4 and found significant scuffs on the cylinder wall which along with the misfires indicate a cracked piston. The big picture appears to be the piston cracked which caused excessive oil consumption and misfires. The excess oil and unburned fuel overloaded the converter causing it to fail. The engine and converter will need to be replaced." In 2017, a recall was issued by GM to mitigate Stochastic Pre-Ignition (SPI) Causing Cracked Piston (17019). Between the initial purchase of the vehicle (11/2016) and performed service required by this recall (03/10/2017), there were approximately 5000 miles driven. No engine diagnosis was performed or recommended. After the 17019 was addressed, the engine misfires continued along with reoccurring CEL. C.S.P. N182195660 Predictive Monitoring for Stochastic Pre-ignition (SPI) released in 2019 states the 1.5 L LFV engines in certain 2016 and 2017 model year Chevrolet Malibu vehicles may have a preignition condition that requires immediate repair. This condition may cause the engine to perform poorly, misfire, run rough, and/or excessively consume oil. It may also illuminate the vehicle’s service engine light. Over time, if not repaired, the condition can damage the vehicle’s pistons and engine. The VIN for this Malibu was not attached to this notice despite it having SPI recall history. On 06/2023 (after the N182195660 program ended), at 80k miles a diagnosis revealed a potential cracked cylinder with no mention of the pre-ignition condition that could cause the crack, and the only way to fix is to replace the entire engine (as per dealer recomendation). Since vehicle was out of warranty, the repair est. was nearly $10k. I firmly believe my 2016 Malibu has suffered the consequences of poor mismanagement on this recall, and am demanding mitigation from GM to fix this issue.

My 2016 Chevrolet Malibu Limited (VIN: [XXX] ) experienced sudden loss of power while driving on 9/11/2025 and set code P228C. The dealership diagnosed the problem as the bolts coming loose from the high-pressure fuel pump, which caused the pump to detach from the cylinder head and become damaged, requiring replacement. This failure directly matches the defect described in NHTSA Recall 18V-358 (GM Campaign 18188/18268). That recall explains that the high-pressure fuel pump can detach from its mounting due to a weld failure, leading to oscillation, damage to the fuel system, and an increased risk of fire. Although the dealer phrased it as “bolts came loose,” the result is identical: the pump detached from the cylinder head and damaged the fuel system. Despite this, my VIN does not show an open recall. GM Customer Assistance told me the repair would not be covered because of the vehicle’s age and mileage (current mileage 129264), even though recalls are federal safety obligations that are not limited by warranty coverage. I am requesting that NHTSA review this exclusion and ensure Recall 18V-358 coverage applies to my vehicle. This defect creates a serious safety risk of fuel leaks and fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The high-pressure fuel pump detached from the cylinder head. The dealership confirmed diagnostic trouble code P228C and reported that one mounting bolt was missing and another bolt was broken off inside the cylinder head, causing the pump to come loose and fail. The damaged parts were replaced at my expense and the components are available for inspection if needed. This failure caused loss of engine power and unsafe drivability, putting my safety and the safety of others at risk. The problem was confirmed and documented by a Chevrolet dealer service center. General Motors has inspected the issue through their dealer network but has denied coverage because the vehicle’s VIN was not included in Recall 18V-18V-358, even though the failure matches that recall description. Warning symptoms included weeks of engine misfires, loss of performance, and eventually complete power loss while driving. These symptoms first appeared shortly before the failure occurred.

I started smelling a strong smell of gas while operating the vehicle. Took to a dealership who diagnosed a turbocharger clamp and exhaust failure. From what I understand I am not the only one with a clamp/exhaust/seal problem. A friend of mine who owned a GM product had similar problems to the point her engine failed altogether. Please investigate!

A couple days ago I went to drive my car and it took a second to actually turn on and it was shaking way more than usual and pooped up with a message saying “engine power is reduced” I haven’t drove my car since because i tried and it was moving very slow, and i also didn’t wanna cause further issues. For some time now my car has been shaky. i have taken it in and balanced my tires because of this issue and nothing had helped. I am always scared to drive it because it has been so shaky but now that this message has popped up it’s even worse and it’s during my whole drive. Also every time i park it isn’t connecting and says “shift to park” even though it is shifted into park. i have to shake it and press some button to go all register that it is shifted into park and can shut my vehicle off. I have read every where that this issue has happened to so many 2016/2017 chevy Malibu’s. I have read the dangers and i do not feel safe driving my car like this. I also didn’t have my car when there was a recall on this exact part before. and i’m guessing the dealership who had it before me did not fix it, causing the problems to worsen other parts of my car. I can’t drive this car due to the safety and i believe it should be a recalled. I am not totally sure what is doing it but as of all the other people online, they said it has to do the gas pedal (2k replacement) and fuel pumps and also could have burned wires which my car also has. thank you.