Electrical System. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 202 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

50 crash reports13 fire reports27 injury reports

What owners actually said

906 reports

130,000 miles · Feb 21, 2025

Steering

Read full complaint

The contact owns a 2012 Chevrolet Malibu. The contact stated that while his son was driving at an undisclosed speed, he became aware that the electronic power steering assist was not functioning properly, requiring an increased effort to maneuver the vehicle. The service power steering warning light was illuminated. The vehicle was taken to the dealer, who diagnosed failures with the power steering control module and power steering torque sensor. The vehicle was not repaired. After investigating the failure, the contact related the failure to Technical Service Bulletin: 15356; however, the vehicle had previously been repaired in 2019 and again in 2020, under the special coverage program. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 130,000.

NHTSA ODI #11644194

113,000 miles · Jan 8, 2025

Air BagsEngine And Engine Cooling

Read full complaint

The contact owns a 2012 Chevrolet Malibu. The contact stated that while driving at 55 MPH, the temperature gauge began to indicate the vehicle was overheating after which the vehicle lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The check engine and air bag warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the oil pan gasket; resulting in damage to the engine, and ABS control module resulting in the air bag warning light. The contact was informed that the engine would need to be replaced. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the independent mechanic, who again diagnosed a failure with the oil pan gasket. The vehicle was repaired, but again the failure occurred for the third time. The manufacturer was not notified of the failure. The failure mileage was 113,000.

NHTSA ODI #11634893

103,000 miles · Jan 8, 2025

Electrical System

Read full complaint

The contact owns a 2012 Chevrolet Malibu. The contact stated while driving at 40 MPH the traction warning illuminated. The contact stated that the ABS and the traction control were disabled. The contact stated that the failure was occurring at any speed. Additionally, the contact stated that the brake lights were randomly illuminating when he depressed the brake pedal. The contact stated that he had to depress the brake pedal with force for the brake lights to illuminate. The contact had taken the vehicle to an independent mechanic was diagnosed and determined that the vehicle needed to have all four brake pads and rotors replaced and two front tires replaced. The vehicle was repaired, however, the failure reoccurred. The manufacturer was not informed of the failure. The failure mileage was approximately 103,000.

NHTSA ODI #11634811

Mileage unknown · Jan 7, 2025

Electrical SystemExterior LightingFire

Passenger and or driver side low beam headlight continues to go out. Mechanic has found connector keeps burning out the socket. Light is fine but connector is shorting out. Fire and safety issue. This issue is on a lot of chevrolet malibu and needs a recall fix.

NHTSA ODI #11634698

Mileage unknown · Dec 31, 2024

Air BagsEngineSeats

Read full complaint

The catalytic converter and exhaust manifold are suspected to be malfunctioning. These components are part of the vehicle’s exhaust system, and their failure is believed to be contributing to hesitation and skipping during operation. Both components are available for inspection upon request. The hesitation and skipping reduce the vehicle’s responsiveness, creating a safety risk in traffic. This issue could hinder safe merging, overtaking, or maintaining consistent speeds. Additionally, malfunctioning exhaust components may lead to increased emissions and pose a risk of toxic gases entering the cabin if leaks are present. Check engine light displays. The problem has been confirmed by a professional auto mechanic during their inspection and diagnosis. The components have been inspected and diagnosed by an independent service center (the auto mechanic). They have not yet been inspected by the manufacturer, police, or insurance representatives. No warning lamps or error messages were displayed on the dashboard prior to the diagnosis. The symptoms, including hesitation and skipping, began approximately [insert timeline, e.g., two weeks ago] and have been recurring during normal driving, particularly during acceleration or at lower speeds.

NHTSA ODI #11633324

100,000 miles · Nov 20, 2024

Air BagsCrashInjury

Read full complaint

The contact called on behalf of her daughter's boyfriend who was driving alongside her daughter in a 2012 Chevrolet Malibu. The contact stated that her daughter's boyfriend was driving on the highway at approximately 75 MPH in the left lane when a tractor-trailer in the right lane veered into their lane and the rear end of the tractor-trailer clipped the front end of their vehicle. The contact vehicle began to spin out of control until it came to a stop on the side of the road. The vehicle was totaled. The air bags were not deployed. The vehicle was towed to a local tow lot. No warning lights were illuminated prior to the crash. A police report was filed. The boyfriend seated in the driver's seat, and the contact's daughter seated in the rear passenger seat were both injured, and the infant in the rear driver's seat in a car seat was not harmed. No other individuals outside of the vehicle were injured. Medical treatment was needed for the daughter's boyfriend and the daughter. The boyfriend injured his nose on the steering wheel, and the daughter's shoulder was injured. A dealer was not contacted. The manufacturer was not notified of the failure. The approximate failure mileage was 100,000.

NHTSA ODI #11626387

Mileage unknown · Nov 3, 2024

Air BagsUnknown Or Other

On [XXX], as I was leaving softball tournament in Poway Ca with my kiddos about 6 minutes into driving a message popped up on my dash "ENG PWR REDUCED & SERVICE TRACTION", I lost power to accelerate, I pulled over just before getting on the [XXX] freeway, turned car off and thought car would reset which it didn't. I was stranded…

Read full complaint

NHTSA ODI #11623319

Mileage unknown · Oct 30, 2024

Exterior Lighting

Read full complaint

The contact owns a 2012 Chevrolet Malibu. The contact stated while driving at various speeds and driving over a pothole or an object on the roadway, the front driver’s side headlight became inoperable. There was no warning light illuminated. The vehicle was taken to an independent mechanic but was not diagnosed; however, the contact was informed that there was a failure with the electrical wiring inside the front driver’s side headlight. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the independent mechanic and was diagnosed and determined that the wiring harness inside the front driver’s side headlight needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA ODI #11622767

146,000 miles · Oct 22, 2024

Air Bags

Read full complaint

The contact owns a 2012 Chevrolet Malibu. The contact stated while a passenger was seated in the front passenger’s seat, the passenger’s side air bag warning light intermittently illuminated while driving at various speeds. The vehicle was taken to a local dealer where it was diagnosed with an inoperable passenger’s side air bag sensor. The vehicle was not repaired. The manufacturer had been informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 146,000.

NHTSA ODI #11621232

Mileage unknown · Oct 13, 2024

Electrical SystemSeat BeltsUnknown Or Other

First, there is a problem with the transmission. The car will stall or stop abruptly while driving. Second, the automatic turn signals do not work. Third, the driver safety belt does tightly secure the driver.

NHTSA ODI #11619575

Official recalls

15V269000 · Seat Belts

May 8, 2015

General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.

Consequence & remedy

Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)