Electrical System. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 202 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

50 crash reports13 fire reports27 injury reports

Steering complaints

191 reports

Clear category filter

33,000 miles · Nov 6, 2014

Air BagsSteeringCrashInjury

Read full complaint

TL* THE CONTACT OWNED A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE MAKING A LEFT TURN, ANOTHER VEHICLE CRASHED INTO THE REAR PASSENGER SIDE OF THE CONTACT'S VEHICLE. THE CONTACT STATED THAT THE STEERING WHEEL AND STEERING COLUMN DETACHED FROM THE VEHICLE, WHICH LANDED ON THE CONTACT'S LAP. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT WAS CONCERNED THAT IF THE STEERING AIR BAG DEPLOYED, HE WOULD HAVE SUSTAINED POSSIBLE FATAL INJURIES. A POLICE REPORT WAS FILED. THE FRONT PASSENGER SUSTAINED BACK BRUISES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO AN IMPOUND LOT. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 33,000.

NHTSA ODI #10653107

33,000 miles · Oct 24, 2014

Air BagsSteeringCrash

I WAS REAR ENDED AND THE STEERING WHEEL AND SHAFT COMPLETELY DISLODGED ONTO MY LAP .THE AIR BAG DID NOT DEPLOY. I WAS PUSHED APPROXIMATELY 150 FT. AND THERE WAS NO WAY I COULD HAVE STEERED IF THERE WAS ANOTHER VEHICLE COMING UP THE HIGHWAY. IF AIRBAG WOULD HAVE DEPLOYED THERE WOULD HAVE BEEN SERIOUS INJURY TO MYSELF. *TR

NHTSA ODI #10649804

16,000 miles · Sep 15, 2014

Steering

Read full complaint

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE WANDERED OUT OF LANE INDEPENDENTLY. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS BEING DRIVEN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO NOTICED THAT BOTH FRONT INNER TIE RODS WERE PROTRUDED OUTWARD WHICH CAUSED DAMAGE TO BOTH FRONT TIRES. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 16,000.

NHTSA ODI #10633142

57,000 miles · Jul 18, 2014

Electrical SystemService BrakesSteering

Read full complaint

DRIVING AND CAR HAD SEVERE ELECTRICAL PROBLEM THAT CAUSED THE CAR TO RANDOMLY STALL WHILE DRIVING. WE LOST POWER STEERING AND POWER BRAKES. THE INSTRUMENT PANEL STARTING GOING CRAZY DISPLAYING ALL LIGHTS, SAYING DEVICE ESC AND THE DOORS LOCKED AND UNLOCKED. THE ENGINE STALLED AND TRANSMISSION STARTED JOLTING AROUND. THE CAR WOULD NOT TURN BACK ON AFTER TURNING IT OFF. TOOK THE CAR TO STARLING CHEVROLET TO GET IT FIXED THE FOLLOWING MONDAY SINCE CLOSED SUNDAY. BEFORE TAKING TO THE DEALER TOOK THE CAR TO AUTO ZONE TO CHECK THE BATTERY. AUTOZONE STATING BATTERY WAS GREAT. CHEVROLET DIDN'T LOOK AT THE CAR AT ALL MONDAY, AND TUESDAY STATED WE NEED NEW BATTERY. I ADVISED OF AUTO ZONE READING AND WAS TOLD AUTZONE WAS WRONG. PICKED UP THE CAR TUESDAY AFTER HAVING A BRAND NEW BATTERY PUT IN FOR $270. TODAY IS THE FOLLOWING FRIDAY AND THE CAR DID EVERYTHING AGAIN WHILE DRIVING AND WILL NOT START. NOW I HAVE TO TOW THE CAR TO CHEVY AGAIN. *TR

NHTSA ODI #10614572

46,000 miles · Apr 28, 2014

Electronic Stability Control (esc)Steering

Read full complaint

STARTED MY 2012 CHEVY MALIBU UP AND POWER STEERING LIGHT CAME ON AND ALSO SERVICE ESC. CAR HAD NO POWER STEERING. THIS WAS AFTER THE FIRST NIGHT OF EVENTS I WAS AT. SO I DROVE IT TO THE HOTEL I WAS AT. FOUND OUT WHEN TRYING TO CORRECT THE PROBLEM THAT IT HAS A ELECTRONIC POWER STEERING. DROVE IT TO A DEALERSHIP BUT THEY COULDN'T SERVICE IT ON THE WEEKEND. I WAS 3 HOURS FROM MY HOME AT AN EVENT. SO I DROVE IT BACK TO MY HOTEL WITH NO POWER STEERING. SO I DROVE FOR ROUGHLY AN HOUR WITH LIGHTS ON AND NO POWER STEERING. THEN WAS ABOUT TO HEAD TO THE DAY TWO OF THE EVENT ABOUT 5 HOURS LATER AND EVERYTHING WORKS AGAIN. I DON'T KNOW WHAT I NEED TO FIX ON IT AT ALL NOW. MY GIRL FRIEND WAS DRIVING WHEN THE POWER STEERING MESSED UP AND SHE NEVER HAS LOST POWER STEERING BEFORE AND SHE COULDN'T EVEN TURN THE WHEEL. SO I HAD TO DRIVE IT FOR HER. *JS

NHTSA ODI #10585372

24,000 miles · Apr 3, 2014

Steering

I WAS HEADING SOUTHBOUND COLERAIN.. AS I WAS GOING THROUGH A GREEN LIGHT THIS YOUNG LADY KEPT ON COMING AT ME AND I SLAMMED MY BRAKES ON AND MOVE MY STEERING WHEEL IN A HARD WAY TO AVOID HER HITTING ME AND ALSO LAST YEAR SLAMMING MY BRAKES TO AVOID HITTING A CAR INFRONT OF ME THAT THERE WAS AN ACCIDENT ON 75 SOUTH BOUND IN K…

Read full complaint

NHTSA ODI #10577202

36,999 miles · Jan 16, 2014

Electronic Stability Control (esc)SteeringSuspension

07/2013 SERVICE ESC MSG AND SYMBOL CAME ON , DEALER UNABLE TO FIND 01/07/2014 SAME 01/15/2014 AGAIN, GM PAID HALF OF THE REPAIR, BECAUSE THE FIRST TIME IT HAPPEN AND WAS NOTICE BY DEALER, I BELIEVE GM SHOULD PAID THE WHOLE COST, AS THIS IS A SAFETY ISSUE , EFFECTS STEERING AND STABILIZATION OF THE VEHICLE. *TR

NHTSA ODI #10560214

Mileage unknown · Nov 24, 2013

Power TrainSteeringVehicle Speed Control

Read full complaint

I PURCHASED THE CAR IN MARCH 2013. IT ONLY HAD 18,000 MILES ON IT. WHILE SLOWING, SUCH AS EXITING THE INTERSTATE, AS THE CAR DOWN SHIFTS, IT DOWN SHIFTS HARD. ESPECIALLY GOING FROM 3RD GEAR TO 2ND AND THEN 1ST. IT SEEMS TO HAVE A SLIGHT DELAY WHEN TRYING TO PICK UP SPEED. MORE SO WHEN YOU HAVE SLOWED AND THEN SPED BACK UP, LIKE WHEN SOMEONE IS TURNING AND YOU HAVE TO SLOW FOR THEM. THERE IS AN AWFUL NOISE IN THE DASH AROUND THE STEERING COLUMN. IF YOU ARE ON A GRAVEL ROAD, IT SOUNDS LIKE THE DASH/STEERING COLUMN IS GOING TO FALL ONTO YOUR FEET. ITS A RATTLE TYPE SOUND. *TR

NHTSA ODI #10553578

11 miles · Feb 4, 2013

Power TrainSteering

Read full complaint

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT THE FRONT END OF THE VEHICLE STARTED TO WOBBLE AT 55 MPH AND ABOVE. THE CONTACT ALSO STATED THAT THE DEALER DID AN ALIGNMENT FOUR TIMES AND REPLACED THE STEERING COLUMN ONCE BUT THE FAILURE RECURRED. THE REAR RIGHT WHEEL HAD BEEN LEANING OUTWARD FROM THE TIME THE VEHICLE WAS PURCHASED AND HAD NOT BEEN CORRECTED BY THE ALIGNMENT. THE FAILURE MILEAGE WAS 11 AND THE CURRENT MILEAGE WAS 19,500. THE CONSUMER STATED FROM THE DAY SHE PURCHASED THE VEHICLE, THE STEERING WAS DIFFICULT TO CONTROL. AS TIME WENT ON, THE PROBLEM BECAME WORSE. THE VEHICLE WAS WOBBLY, CHOPPY AND CAREENING . IT WAS DIFFICULT TO CONTROL ON UNEVEN PAVEMENT ROADS AND STREETS AND EXTREMELY DIFFICULT TO MAINTAIN AT 55 MPH AND HIGHER. EACH TIME THE CONSUMER WENT TO THE DEALER, THE VEHICLE WAS OUT OF ALIGNMENT. AT TIMES, THE STEERING WAS VERY LOOSE. ALSO, THE SHIFTING WAS ERRATIC AND LAGGED. IT LAGGED FROM STOP SIGNS. IT OFTEN FAILED TO DOWN SHIFT TO GAIN POWER NEEDED ON HIGHWAY UPGRADES. WHEN THE CONSUMER ATTEMPTED TO PASS SEMI-TRUCKS ON AN UNEVEN PAVEMENT ON THE INTERSTATE, THE VEHICLE PULLED TO THE RIGHT, JERKED TO THE LEFT WITH ALMOST AN UNCONTROLLABLE SHIFTING AND SWAYING. IF THERE WERE CURVE , THE VEHICLE WOULD DANGEROUSLY SWING WIDE OUT INTO THE CURVES. THE STEERING WHEEL, WOULD THEN FREEZE UP AND WOULD BECOME DIFFICULT TO TURN AND STEER SAFELY. ON ONE OCCASION, WHILE DRIVING ON THE INTERSTATE HIGHWAY, THE CONSUMER HAD JUST PASSED A SEMI AT A SPEED OF 70 MPH AND AS SHE WAS RETURNING TO THE RIGHT LANE, THE VEHICLE STUTTERED AND STARTED TO STOP. SHE PUSHED THE ACCELERATOR PEDAL TO THE FLOOR AND THERE WAS A DANGEROUS LAG BEFORE ENOUGH POWER CAME TO THE VEHICLE.

NHTSA ODI #10496272

1,100 miles · Jan 30, 2013

Electrical SystemService BrakesSteering

Read full complaint

VEHICLE (2012 MALIBU) WAS PURCHASED APRIL 2012 - STARTING JULY 2012 VEHICLE WOULD STALL GOING DOWN THE ROAD, WITH LOSS OF ENGINE, POWER ASSIST STEERING AND POWER ASSIST BRAKES. DEALER REPLACED NUMEROUS MODULES, BUT IT OCCURRED AGAIN IN SEPT 2012 (3 TIMES) THEN AGAIN IN JANUARY 2013. TWO BODY CONTROL MODULES HAVE BEEN REPLACED, ENGINE CONTROL MODULES, TWO POWER STEERING MODULES, ONSTAR MODULE, TRANSMISSION CONTROL MODULE, ETC. UNINTENDED POWER STEERING ASSIST OCCURS SUCH THAT WITHIN APPROXIMATELY 5 SECONDS WHILE DRIVING DOWN THE ROAD, POWER STEERING COMES IN AND OUT AS MODULE FAILS (ALONG WITH ENGINE AND TRANSMISSION). VERY UNSAFE TO DRIVE. DEALER WOULD NOT REPLACE VEHICLE AND GM STATES THEY STAND BY LAST REPAIR. IT HAS BEEN REPAIRED 6 TIMES NOW, BUT WE REFUSE TO DRIVE VEHICLE, AS WE BELIEVE THERE MUST BE A SHORT SOMEWHERE. THEY KEEP STATING IT IS DEFECTIVE MODULES AND THEY JUST KEEP REPLACING THEM. PLEASE SEE YOUTUBE VIDEOS: "2012 CHEVY MALIBU - UNINTENDED POWER STEERING ASSIST FAILURE MODE?" "2012 CHEVY MALIBU DANGEROUS ELECTRICAL PROBLEM - ANY IDEAS?" *TR

NHTSA ODI #10495304

Official recalls

15V269000 · Seat Belts

May 8, 2015

General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.

Consequence & remedy

Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)