IllustrationVehicle will intermittently not start, have to tap on trunk fuse box to get the Malibu to start, the wire is too small and burns up, can’t find anyone to replace it, is a big issue with this generation of Malibu. Vehicle has shut off while on highways and stoplights on MULTIPLE occasions
2012 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2012 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
7125–50K
11250–75K
12475–100K
187100–150K
64150K+
646 reports with mileage · 260 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 202 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
50 crash reports13 fire reports27 injury reports
Fuel/propulsion System complaints
51 reportsI’m having recalled issues in my car, but the car has no recall on it
Vehicle has intermittent periods where it won’t start. After replacing fuel pump relay it started after a week vehicle stalled while driving tested relay worked perfect after reading online forums found that this model car has an issue with the wiring to the fuse/fuse block in the trunk after pulling the fuse block out the wirin…
Read full complaint
Vehicle has intermittent periods where it won’t start. After replacing fuel pump relay it started after a week vehicle stalled while driving tested relay worked perfect after reading online forums found that this model car has an issue with the wiring to the fuse/fuse block in the trunk after pulling the fuse block out the wiring to the block is loose and very thin after adjusting the wires the car will start and run with no issues for several days to week where it will be fine the the wires will come lose again causing a crank. I start issue and stalling while driving.
Vehicle repeatedly shuts down due to wiring issue for fuel pump. Wire in rear fuse panel (in trunk) shows signs of overheating (discoloration). Vehicle shuts down without warning while driving. This causes an unsafe condition especially when travelling on busy roadways and highways. This seems to be a common problem with this mo…
Read full complaint
Vehicle repeatedly shuts down due to wiring issue for fuel pump. Wire in rear fuse panel (in trunk) shows signs of overheating (discoloration). Vehicle shuts down without warning while driving. This causes an unsafe condition especially when travelling on busy roadways and highways. This seems to be a common problem with this model and year.
To Whom It May Concern: My 2012 Chevrolet Malibu LS HASN'T been involved in an accident but I feel it necessary to report it! Due to issues involving my electrical system and other components of the vehicle that aren't working properly, the vehicle is inoperable! Beginning in April 2022, I have experienced issues with the vehic…
Read full complaint
To Whom It May Concern: My 2012 Chevrolet Malibu LS HASN'T been involved in an accident but I feel it necessary to report it! Due to issues involving my electrical system and other components of the vehicle that aren't working properly, the vehicle is inoperable! Beginning in April 2022, I have experienced issues with the vehicle starting (one day it will start and drive normally, another day it might not). Then it started stalling unexpectedly. Granted, I've had the car 10 years but I've never had these problems! It's been serviced and the problems still exist! These problems could easily cause an accident; I'm grateful I've been spared from tragedy! These issues need to be addressed and I'd greatly appreciate hearing from NHTSA!
I had been out running errands and I picked my mother up from church. Pulled up to the stoplight, light turned green, I pressed the gas pedal and nothing. I'm sitting at a major intersection and my car won't move I just put the pedal to the floor and my car creeped forward. Which if someone had been coming up behind me that wasn…
Read full complaint
I had been out running errands and I picked my mother up from church. Pulled up to the stoplight, light turned green, I pressed the gas pedal and nothing. I'm sitting at a major intersection and my car won't move I just put the pedal to the floor and my car creeped forward. Which if someone had been coming up behind me that wasn't stopped just driving up, I mean that could have been a very serious accident probably involving more than just my vehicle and the person behind me. The error codes that showed up on it after a reading was done (mind you there were no warning lights, there was nothing indicating a problem, there was no hint that there was a problem, an engine light came on AFTER the fact. ) the p0207 faulty fuel injector 7 and a p1607 serial communication problem with Device 7 and a p0700 transmission control system malfunction. In looking this up online there have been a lot of people who've had the same problem that have posted online. And there's a great many more posting in different places online and many that are not posting anything online about it. It's common and I would say a very common problem for owners of the Chevy Malibu.
The bcm and fuel pump relay over heats burns the wire causing stalls at traffic lights and normal driving then won’t start back up. If you’re lucky you can hit the bcm or take the fuel relay out and reinstall and it may start back up
This car will not start!!!! It starts when it feels like it. I’ve been stranded after work so many times for unknown reasons. Multiple mechanics have inspected car and cannot find the issue. Go on YouTube and search for this year car and you’ll find so many people in the same situation as me. The car has battery but the engine w…
Read full complaint
This car will not start!!!! It starts when it feels like it. I’ve been stranded after work so many times for unknown reasons. Multiple mechanics have inspected car and cannot find the issue. Go on YouTube and search for this year car and you’ll find so many people in the same situation as me. The car has battery but the engine will not start. GM cars have this issue in common and it’s ridiculous GM cannot stand behind their brand. Please HELP US!!!
While parked or driving this vehicle shuts down on its own, sometimes on the freeway going 65 mph. The fuse located in the trunk has a faulty connection and a wire that isn’t efficient for heat from fuel pump so it shuts down while driving and sometimes won’t start. This is gonna kill someone when it shuts off on the freeway in …
Read full complaint
While parked or driving this vehicle shuts down on its own, sometimes on the freeway going 65 mph. The fuse located in the trunk has a faulty connection and a wire that isn’t efficient for heat from fuel pump so it shuts down while driving and sometimes won’t start. This is gonna kill someone when it shuts off on the freeway in traffic. I’ve read up on this being a regular problem with the Malibu
CAR STALLED IN THE MIDDLE OF THE ROAD WHILE DRIVING POSING HAZARDOUS CONDITIONS.
Official recalls
215V269000 · Seat Belts
May 8, 2015
General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.
Consequence & remedy
Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.