IllustrationPASSENGER SIDE HEADLIGHT (LOW BEAM) HAS HAD TO BE REPLACED 4 TIMES IN THE LAST 2 YEARS.
2012 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2012 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
7125–50K
11250–75K
12475–100K
187100–150K
64150K+
646 reports with mileage · 260 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 202 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
50 crash reports13 fire reports27 injury reports
Exterior Lighting complaints
202 reportsTL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START AND THE AIR BAG AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THE FAILURES OCCURRED ON DIFFERENT OCCASIONS. THE VEHICLE WAS TAKEN TO COX CHEVROLET (2900 CORTEZ RD W, BRADENTON, FL 34207, (941) 348-6417), …
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START AND THE AIR BAG AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THE FAILURES OCCURRED ON DIFFERENT OCCASIONS. THE VEHICLE WAS TAKEN TO COX CHEVROLET (2900 CORTEZ RD W, BRADENTON, FL 34207, (941) 348-6417), BUT THE CAUSE OF THE FAILURES COULD NOT BE DETERMINED. THE CONTACT STATED THAT THE DEALER MADE UNKNOWN REPAIRS TO THE VEHICLE, BUT THE WARNING INDICATORS REMAINED ILLUMINATED. THE CONTACT ALSO MENTIONED THAT THE VEHICLE WAS TAKEN TO A LOCAL TIRE SHOP FOR THE REPLACEMENT OF THE EXTERIOR LIGHTING. THE CONTACT STATED THAT EVERY THREE MONTHS A DIFFERENT EXTERIOR LIGHT WOULD GO OUT AND HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS UNKNOWN.
THIS IS THE FOURTH TIME MY PASSENGER LOW BEAM HAS WENT OUT THE THIRD TIME I CHANGED THE LOW BEAM WIRING AND IN LESS THAN A MONTH IT HAS GONE OUT AGAIN SOMETHING IS NOT RIGHT I HAVE HEARD MANY PEOPLE COMPLAIN ABOUT THE PASSENGER LOW BEAM KEEPS GOING OUT SOMETHING NEEDS TO BE DONE ASAP
CAR WILL SHUT DOWN. HEAD LIGHTS STOP WORKING LESS THEN EVERY TWO MONTHS. FUSE INSIDE THE CAR WHERE TO CHARGE THE PHONE ISN'T WORKING BOTH FRONT AND MIDDLE. CAR DIES RANDOMLY AFTER BEING LEFT ON FOR A LITTLE WHILE. HOT AND COLD RATE STAYS ON COLD ALL DAY AND HAS THE AC UNIT BLOW OUT COLD AIR WHEN ON HEAT AND IF ON COLD IT JUST BL…
Read full complaint
CAR WILL SHUT DOWN. HEAD LIGHTS STOP WORKING LESS THEN EVERY TWO MONTHS. FUSE INSIDE THE CAR WHERE TO CHARGE THE PHONE ISN'T WORKING BOTH FRONT AND MIDDLE. CAR DIES RANDOMLY AFTER BEING LEFT ON FOR A LITTLE WHILE. HOT AND COLD RATE STAYS ON COLD ALL DAY AND HAS THE AC UNIT BLOW OUT COLD AIR WHEN ON HEAT AND IF ON COLD IT JUST BLOWS AIR. CAR WONT DRIVE FASTER THEN 5 MPH AFTER HAVING THE BATERY REBOOTED DEPENDING ON IF TE CAR WAS ALLOWED TO SIT IDOL OR A WHILE. CAR WILL PLACE IT'S SELF IN SHUT DOWN DE TO ELECRICAL PROBLEMS. ONCE ONE STARTS ACTING UP THEY ALL START ACTING UP.
MY CAR CAN RUN FOR A CERTAIN AMOUNT OF TIME AND THE BATTERY WILL DIE RANDOMLY. MY HEADLIGHT CONSTANTLY CUT OFF AND INTERIOR MY HOT AN COLD LEVEL STAY DOWN ON A REGLAR DAY. THE AC BLOWS OUT COLD AIR WHEN ON HEAT OR IT WILL JUST BLOW AIR. MY CAR WILL JUST STIFEN UP AND NOT DRIVE AFTER RESTARTING THE BATTERY.
TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT THE HEADLIGHT BULBS FAILED NUMEROUS TIMES. THE BULBS WERE REPLACED SEVERAL TIMES; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER FOR INSPECTION, BUT A FAILURE CODE FOR THE HEADLIGHT WIRING SYSTEM COULD NOT BE LOCATED. THE VE…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT THE HEADLIGHT BULBS FAILED NUMEROUS TIMES. THE BULBS WERE REPLACED SEVERAL TIMES; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER FOR INSPECTION, BUT A FAILURE CODE FOR THE HEADLIGHT WIRING SYSTEM COULD NOT BE LOCATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
IN LESS THEN ONE YEAR THE PASSENGER SIDE LOW BEAM LIGHT IS OUT. I LOOK ON LINE AND A LOT OF 2012 MALIBU ARE HAVING THE SAME PROBLEM. IT COST OVER $100 TO CHANGE IT BECAUSE THEY HAVE TO REMOVE THE BUMPER TO DO IT.
MY HEADLIGHT KEEPS GOING OUT I HAD THE BULB REPLACED AND ELECTRICAL SOCKETS AND IT KEEPS GOING OUT THIS IS THE 4TH TIME I HAVE HAD TO HAVE THE SAME WORK COMPLETED.
LOW BEAMS BOTH HEADLIGHTS REPEATEDLY GO OUT. HEATER/AIR CONDITIONER TURNS OFF AND ON BY ITSELF. MOTOR HAS BEEN CHANGED AND TESTED. IS THERE A WIRING PROBLEM WITH THIS VEHICLE ACROSS THE BOARD. I READ A LOT OF PEOPLE WITH THIS VEHICLE HAVE THE EXACT SAME ISSUES. HEATER/AIR TURNS OFF WHILE IN PARK OR DRIVE RANDOMLY.
I'VE CHANGED MY DRIVER'S SIDE LOW BEAM HEADLIGHT 3 TIMES IN THE PAST YEAR.
Official recalls
215V269000 · Seat Belts
May 8, 2015
General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.
Consequence & remedy
Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.