IllustrationTRACKING CONTROL LIGHT COMES ON AND SLOWS THE CAR, THE THE ENGINE WILL DISABLE . THE CAR WILL DO THIS WHILE IN MOTION. TODAY ON THE FREEWAY ENGINES DISABLED AND ALMOST REAR ENDED. NO MACHANIC KNOW HOW TO FIX IT WITHOUT CHANGING AND REPLACING MULTIPLE PARTS AND STILL HAPPENS. WE PURCHASED THE CAR IN MARCH 2018
2012 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2012 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
7125–50K
11250–75K
12475–100K
187100–150K
64150K+
646 reports with mileage · 260 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 202 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
50 crash reports13 fire reports27 injury reports
Engine complaints
99 reportsVEHICLE STARTED IDLING ROUGH BUT RAN GOOD ON THE INTERSTATE OR SPEEDS ABOVE 40 MPH. CHECKED TIMING CHAINS. CHAINS WERE LOOSE AND JUMPED TIME.
CYLINDER 2 KEEP MISS FIRING AND SERVICE TRACTION LIGHT KEEPS COMING ON. I HAVE TAKEN THE CARE TO 3 REPAIR SHOP AND SPENT OVER $2500 IN REPAIRS OVER THE LAST YEAR.
MISFIRE CYL #1 AND ENG LT. WITH MISFIRE CODE, ATTEMPTED CHEV DEALER WARRANTY REPAIR WITH REMOVAL OF CYL HEAD AND REPLACEMNT VALVES [THE CHEAP FIX INSTEAD OF REPLACING CYL HEAD, IN RETROSPECT I BELIEVE CHEV SHOULD HAVE REPLACED THE CYL HEAD FOR A PERMANENT REPAIR, NOW THE CAR IS OUT OF 100K POWERTRAIN WARRANTY] BUT RECURRENCE 22K…
Read full complaint
MISFIRE CYL #1 AND ENG LT. WITH MISFIRE CODE, ATTEMPTED CHEV DEALER WARRANTY REPAIR WITH REMOVAL OF CYL HEAD AND REPLACEMNT VALVES [THE CHEAP FIX INSTEAD OF REPLACING CYL HEAD, IN RETROSPECT I BELIEVE CHEV SHOULD HAVE REPLACED THE CYL HEAD FOR A PERMANENT REPAIR, NOW THE CAR IS OUT OF 100K POWERTRAIN WARRANTY] BUT RECURRENCE 22K MILES LATER. I SUSPECT A DESIGN FLAW. ITERNET SHOWS MANY OWNERS WITH SAME COMPLAINT. TRACTION CONTROL LIGHT CONTINUES TO COME OFF AND ON.
TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. WHILE DRIVING VARIOUS SPEEDS, THE CHECK ENGINE INDICATOR ILLUMINATED WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO GRISMER AUTOMOTIVE (60 N MAIN ST, SPRINGBORO, OH 45066, 937-748-2050) WHERE IT WAS DIAGNOSED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE CONTACT WAS ADVIS…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. WHILE DRIVING VARIOUS SPEEDS, THE CHECK ENGINE INDICATOR ILLUMINATED WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO GRISMER AUTOMOTIVE (60 N MAIN ST, SPRINGBORO, OH 45066, 937-748-2050) WHERE IT WAS DIAGNOSED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE CONTACT WAS ADVISED BY CHEVROLET TO CONTACT GM. THE CONTACT CALLED GM AND WAS INFORMED THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY DUE TO THE MILEAGE; THEREFORE, THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR. THE FAILURE MILEAGE WAS 103,000.
TIMING CHAIN NEEDS REPAIR ONLY 80,000 MILES ON CAR BOUGHT IT CERTIFIED USED WARRANTY IS UP IM VERY UPSET WAS DRIVING ON EXPRESS WAY ENGINE LIGHT CAME ON HAD IT CHECKED AT DEALERSHIP
THIS IS MY SECOND INCIDENT REPORT FOR THE SAME VEHICLE. WHILE DRIVING ON THE HIGHWAY THE VEHICLE SUDDENLY LOST ALL MOBILITY. NO WARNING AT ALL JUST STOPPED RUNNING. FORTUNATLY I WAS NOT AT A VERY HIGH RATE OF SPEED BUT WAS GETTING READY TO MAKE A TURN OFF THE HIGHWAY. NO INDICATION THAT ANYTHING WAS WRONG AT ALL. MY CONCERN IS W…
Read full complaint
THIS IS MY SECOND INCIDENT REPORT FOR THE SAME VEHICLE. WHILE DRIVING ON THE HIGHWAY THE VEHICLE SUDDENLY LOST ALL MOBILITY. NO WARNING AT ALL JUST STOPPED RUNNING. FORTUNATLY I WAS NOT AT A VERY HIGH RATE OF SPEED BUT WAS GETTING READY TO MAKE A TURN OFF THE HIGHWAY. NO INDICATION THAT ANYTHING WAS WRONG AT ALL. MY CONCERN IS WHY DOES SOMEONE NEED TO GET HURT OR KILLED BEFORE THIS PROLEM IS ADDRESSED? HAVING TAKEN THIS TO BE SERVICED I ENCOUNTERED OTHERS WHO HAVE HAD THE SAME EXPERIENCE WITH THEIR VEHICLES, ALL CHEVROLETS OF ONE MODEL OR SIMILAR TO IT. BASICALLY THE SAME MOTOR. THIS HAPPENED TO ME BEFORE AND I HAVE NOT BEEN GIVEN A REASON FOR THE PROBLEM.
VEHICLE WAS IN MOTION AT ABOUT 60 MPH ON A HIGHWAY AND THE RPMS DROPPED DRASTICALLY, THE ANTI SKID INDICATOR LIGHT CAME ON, THE VEHICLE LOST POWER TEMPORARILLY. I PULLED OVER AND SLOWED DOWN AND THE CAR RETURNED TO NORMAL. SAME EVENING VEHICLE WAS IN MOTION ABOUT 55 MPH ON A HIGHWAY WHEN THERE WAS A LOSS OF POWER, STEERING GOT S…
Read full complaint
VEHICLE WAS IN MOTION AT ABOUT 60 MPH ON A HIGHWAY AND THE RPMS DROPPED DRASTICALLY, THE ANTI SKID INDICATOR LIGHT CAME ON, THE VEHICLE LOST POWER TEMPORARILLY. I PULLED OVER AND SLOWED DOWN AND THE CAR RETURNED TO NORMAL. SAME EVENING VEHICLE WAS IN MOTION ABOUT 55 MPH ON A HIGHWAY WHEN THERE WAS A LOSS OF POWER, STEERING GOT SLUGGISH,ALL INDICATORLIGHTS ON DASH BLINKED ON AND OFF ENGINE LIGHT CAME ON AND STAYED ON, ANTI SKID INDICATOR LIGHT CAME ON, WAS KNOCKING IN MOTOR AND CAR WOULD NOT ACCELERATE OVER 20 MPH. COMPLETED A DIAGNOSIS OF THE VEHICLE AND A CODE P0068 WAS NOTED BY DIAGNOSTICS. P0068 THE ENGINE AND TRANSMISSION SYSTEM IS NOT PERFORMING AS EXPECTED. AN ISSUE HAS BEEN DETECTED IN THE THROTTLE CONTROL SYSTEM THAT CONNECTS THE ACCELERATOR PEDAL WITH THE THROTTLE AND INTEGRATES FEATURES SUCH AS CRUISE CONTROL, TRACTION CONTROL, STABILITY CONTROL, AND PRE-CRASH SYSTEMS. IF THE CHECK ENGINE LIGHT IS FLASHING, A MISFIRE CONDITION HAS BEEN DETECTED. A MISFIRE INCREASES VEHICLE EMISSIONS AND COULD DAMAGE THE EMISSION CONTROL SYSTEM ON THE VEHICLE. PLEASE REDUCE VEHICLE SPEED, AVOID HARD ACCELERATIONS, AVOID STEEP UPHILL GRADES, AND REDUCE ANY CARGO LOADS SUCH AS A TRAILER. IF THE VEHICLE IS CONTINUALLY DRIVEN WITH THE CHECK ENGINE LIGHT ON, THE EMISSION CONTROLS MIGHT NOT WORK AS WELL, THE VEHICLE FUEL ECONOMY MIGHT NOT BE AS GOOD, AND THE ENGINE MIGHT NOT RUN AS SMOOTHLY. THIS COULD LEAD TO FUTURE REPAIRS
STOP AT LIGHT, KNOCKING NOISE STARTS & HESITATION AT NEXT LIGHT. A MILE LATER, CHECK ENGINE LIGHT TURNS ON.CODES P00011,P00014 P00366- FROM DEALERSHIP #1. HAD PREVIOUS ENGINE WORK DONE UNDER WARRANTY (WHICH DEARLERSHIP #1 TRIED TO CHARGE ME $400. UNTIL I PRESSED THE WARRANTY).I BOUGHT IT THERE.SERVICE PERSON REPORTED:FOREIGN DEB…
Read full complaint
STOP AT LIGHT, KNOCKING NOISE STARTS & HESITATION AT NEXT LIGHT. A MILE LATER, CHECK ENGINE LIGHT TURNS ON.CODES P00011,P00014 P00366- FROM DEALERSHIP #1. HAD PREVIOUS ENGINE WORK DONE UNDER WARRANTY (WHICH DEARLERSHIP #1 TRIED TO CHARGE ME $400. UNTIL I PRESSED THE WARRANTY).I BOUGHT IT THERE.SERVICE PERSON REPORTED:FOREIGN DEBRIS ON THE SCREEN OF THE CAM POSITION ACTUATORS SHE ALSO REPORTED: FILTER BROKE, OR SOMEONE WHERE I HAD THE OIL CHANGED (VALVOLINE) PUT A RAG OR BOTTLE CAP IN MY ENGINE,NEEDED A NEW ONE. SHE ADVISE ME TO TAKE THE CAR TO VALVOLINE.AFTER PERSISTENT QUESTIONING, SHE SUGGESTS, ENGINE FLUSH BUT NO GUARANTEE. REFUSED FLUSH. PAID $133. FOR "DIAGNOSTIC". TOOK TO VALVOLINE - THEY SPOKE TO TECH AT DEALERSHIP #1 WHO SAID FILTER INTACT BUT TILTED.THEY VIEWED THE FILTER, SAID IT WAS FINE BUT SHOWED ME THE METALLIC SPARKLES IN IT. THEY MENTIONED IT WAS TILTED.THEY TOOK PICTURES AND HAVE A VIDEO WHERE THEY SAID A RAG OR BOTTLE CAP WAS NOT NEAR ENGINE. I HAVE NOT VIEW THIS TAPE.CALLED GM - MADE A COMPLIANT AGAINST DEALER - THEY ESCALATE GM CALLS BACK. ADVISED TAKE TO DEALERSHIP. ANYONE, TOOK TO ANOTHER - DO NOT TRUST THE ORIGINAL.GM DEALERSHIP #2 - SAID FILTER HAD METAL PARTS IN IT - THEY SAID IT WAS CRUSHED,ASKED TO DROP PAIN,QUOTED $350.DEALER #2 - DROPS PAN AND SAYS THE FOLLOWING IN AN EMAIL AND SENT PICTURES:THE FOLLOWING PICTURES SHOW THE VEHICLES OIL PAN REMOVED AND FOREIGN DEBRIS IN THE BOTTOM. TECHNICIAN BELIEVES THE PLASTIC FROM THE TIMING CHAIN GUIDES AND VISIBLE METAL IN THE OIL ITSELF. ADVISED NEED ENGINE. REBUILT IS APPROX: $6000, OR $7500 NEW. CAR HAS 33K MILES.TIMING CHAIN BELT FAILURE.GM WILL NOT STAND BY THEIR PRODUCTS THAT DESTROYED ENGINE.TWO ENGINE ISSUES PRIOR TO CURRENT: STALLED APPROACHING A HIGHWAY. TOWED TO DEALERSHIP#1. DRIVING ON HIGHWAY/SLOWED FROM 50 TO 20MPH, TRYING TO PULL OVER THEN IT ACCELERATED.
2012 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO MULTIPLE SAFETY DEFECTS WITH VEHICLE. *LD THE CONSUMER STATED THE VEHICLE HAS SEVERAL SAFETY DEFECTS INCLUDING THE ELECTRIC STABILITY CONTROL, BRAKES, SENSOR LIGHTS, STEERING, SUSPENSION, WHEELS, ENGINE LIGHTS, POWER TRAIN. UPDATED 10/23/2017*JS
Official recalls
215V269000 · Seat Belts
May 8, 2015
General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.
Consequence & remedy
Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.