IllustrationTHE VEHICLE HAVE NO CHECK ENGINE CODES BUT WON'T START AND CUTS OFF I TRAFFIC AND IN HIGHWAY. THE FUSE BOX IN TRUNK GETS GOT AND THE FUEL PUMP RELAY GETS HOT. AFTER THE CAR STALLS THE ONLY WAY TO START IS SHAKE WIRETAP FUSE BOX IN TRUNK AND TAP ON REAR FUSE BOX
2012 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2012 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
7125–50K
11250–75K
12475–100K
187100–150K
64150K+
646 reports with mileage · 260 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 202 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
50 crash reports13 fire reports27 injury reports
Electrical System complaints
290 reportsENGINE LOSSES POWER SHUTS OFF WONT RESTAT
CAR STOPS WHILE DRIVING LOSES POWER. START AND STOP INTERMITTENTLY. FUSES HOT IN TRUNK FUSE BOX. WAS NEARLY REAR ENDED MULTIPLE TIMES.THIS HAS BEEN AN ONGOING PROBLEM AND HAVE HAD MANY PARTS REPLACED WHICH HAS NOT FIXED THE PROBLEM. THIS IS HOWEVER, THE THIRD TIME IT HAS HAPPENED WHILE DRIVING. THIS IS A VERY DANGEROUS SITUAT…
Read full complaint
CAR STOPS WHILE DRIVING LOSES POWER. START AND STOP INTERMITTENTLY. FUSES HOT IN TRUNK FUSE BOX. WAS NEARLY REAR ENDED MULTIPLE TIMES.THIS HAS BEEN AN ONGOING PROBLEM AND HAVE HAD MANY PARTS REPLACED WHICH HAS NOT FIXED THE PROBLEM. THIS IS HOWEVER, THE THIRD TIME IT HAS HAPPENED WHILE DRIVING. THIS IS A VERY DANGEROUS SITUATION! I HAVE HEARD OF MANY OTHER VEHICLE OWNERS OF THE SAME MAKE AND MODEL HAVING THESE ISSUES. THIS IS A WIRING ISSUE WITH GENERAL MOTORS. SOMEONE IS GOING TO GET INJURED OR WORSE DUE TO THIS ISSUE.
THE LOW-BEAM HEADLIGHTS KEEP BURNING OUT. A MELTED SOCKET WAS THE FIRST ISSUE. IT WAS REPAIRED A MONTH AGO AND NOW THE SAME PROBLEM IS AGAIN AT PLAY. THERE MUST BE AN ELECTRICAL SHORT. THIS IS A COMMON PROBLEM WITH THESE VEHICLES THAT MANY HAVE REPORTED. IT COSTS DEARLY TO HAVE A MECHANIC TAKE APART THE FRONT OF THE VEHICLE …
Read full complaint
THE LOW-BEAM HEADLIGHTS KEEP BURNING OUT. A MELTED SOCKET WAS THE FIRST ISSUE. IT WAS REPAIRED A MONTH AGO AND NOW THE SAME PROBLEM IS AGAIN AT PLAY. THERE MUST BE AN ELECTRICAL SHORT. THIS IS A COMMON PROBLEM WITH THESE VEHICLES THAT MANY HAVE REPORTED. IT COSTS DEARLY TO HAVE A MECHANIC TAKE APART THE FRONT OF THE VEHICLE AND WORK ON THE LIGHTS SINCE YOU MUST TAKE OFF THE WHOLE FRONT BUMPER TO ACCESS THE HEADLIGHTS. I HAVE PAID FOR REPAIR AND BULB REPLACEMENT ALREADY IN THE PAST 2 MONTHS. TO SEE IT HAPPENING AGAIN IS VERY DISCOURAGING.
MY 2012 CHEVY MALIBU PASSENGER SIDE LOW BEAM HAS GONE OUT FOR THE SECOND TIME IN LESS THAN A YEAR. AFTER DOING SOME RESEARCH, I FOUND THIS IS A COMMON ISSUE FOR THE CHEVY MALIBU. ENTRIES STATING SIMILAR ISSUES SPECIFICALLY EFFECTING THE SAME PASSENGER SIDE LOW BEAM, TOTALED MORE THAN 300 ON CARPROBLEMZOO.COM THIS IS NOT ONLY A…
Read full complaint
MY 2012 CHEVY MALIBU PASSENGER SIDE LOW BEAM HAS GONE OUT FOR THE SECOND TIME IN LESS THAN A YEAR. AFTER DOING SOME RESEARCH, I FOUND THIS IS A COMMON ISSUE FOR THE CHEVY MALIBU. ENTRIES STATING SIMILAR ISSUES SPECIFICALLY EFFECTING THE SAME PASSENGER SIDE LOW BEAM, TOTALED MORE THAN 300 ON CARPROBLEMZOO.COM THIS IS NOT ONLY A MONETARY ISSUE, NOT ONLY A RESOURCE ISSUE, BUT A SIGNIFICANT RISK TO OPERATOR AND BYSTANDER SAFETY. IF GM DOES NOT ACKNOWLEDGE THEY HAVE SUPPLIED A FAULTY PRODUCT, AS DESCRIBED BY THE HUNDREDS OF COMPLAINTS LISTED ONLINE, THEY ARE COMPLICIT TO ANY ACCIDENTS OR INJURY CAUSED BY THEIR LACK OF ACTION AND CONCERN. MY OWN EXPERIENCE HAS BEEN FRIGHTENING, NOTICING A LACK OF POWER AFTER I'M ALREADY ON THE ROAD, ONLY SEEING ONE LIGHT FROM MY CAR REFLECTING ON ANOTHER CAR OR SURFACE. THE GENERAL PUBLIC TAKES GREAT CARE TO MAKE SURE THEIR VEHICLES CAN BOTH SAFELY OPERATE AND TRANSPORT THEMSELVES AND OTHERS. WITH THIS DAMAGED PART IN CHEVY'S MALIBU, MAKING GREAT STRIDES FOR A SAFE VEHICLE COULD BE FOR NOTHING IF THE LIGHT DOES NOT DO ITS JOB. WITH THIS IN MIND, PLEASE CONSIDER THE CLIMATE WE LIVE IN TODAY. THE DIFFERENCE BETWEEN A FAULTY HEADLIGHT, AND A RELIABLE LIGHT, COULD MEAN LIFE OR DEATH NOT ONLY FOR THOSE ON THE ROAD, BUT FOR POC, TARGETED BY POLICE, FOR A FAULTY HEADLIGHT. IN 2015, DARRIUS STEWART WAS A PASSENGER IN A 2009 CHEVY MALIBU. HE UNJUSTLY LOST HIS LIFE TO A POLICE OFFICER AFTER THE DRIVER WAS PULLED OVER FOR WHAT DO YOU ASK? A HEADLIGHT OUT. DARRIUS STEWART. GENERAL MOTORS- RECALL. HTTP://CHNG.IT/RPXWYMBW9V
ESC WARNING ON DASH COMING ON WILL DRIVING AND TURNING FORWARD OR BACKWARD. HVAC CONTROLLER NOT RESPONDING TO COMMANDS, HVAC RESISTOR AND BLOWER MOTOR WIRES GETTING VERY HOT AND NOT BLOWING FUSES WHEN DRIVING WITH AC OR HEATER RUNNING. HVAC RESISTOR BLOWING OUT. HIGH MOTOR OIL CONSUMPTION , EVERY 1000 MILES ITS LOW A QUART.
THE ANTI-THEFT SYSTEM RANDOMLY ACTIVATES AND SHUTS DOWN THE CAR. IT PREVENTS ME FROM STARTING THE CAR. IT USUALLY HAPPENS WHEN I AM TRYING TO START THE CAR BUT I'VE READ POSTS ABOUT IT HAPPENING WHILE PEOPLE ARE DRIVING. *TR
MY FUSE BOX IN MY TRUNK CAME BACK FAIL BAD ONE SO CHANGED IT OUT WITH ANOTHER ONE WELL THAT WORKED FOR 1 MONTH MY CAR STALLS OR DON'T START UNLESS I HIT THE FUSE BOX GOT ANOTHER FUSE BOX THAT DID THE SAME EXACT THINGS NOW SOME TIMES WHEN I HIT THE FUSE BOX MY CAR WILL START THEN AGAIN WON'T SOMETHINGS MAKING THE FUSE BOX TO GO B…
Read full complaint
MY FUSE BOX IN MY TRUNK CAME BACK FAIL BAD ONE SO CHANGED IT OUT WITH ANOTHER ONE WELL THAT WORKED FOR 1 MONTH MY CAR STALLS OR DON'T START UNLESS I HIT THE FUSE BOX GOT ANOTHER FUSE BOX THAT DID THE SAME EXACT THINGS NOW SOME TIMES WHEN I HIT THE FUSE BOX MY CAR WILL START THEN AGAIN WON'T SOMETHINGS MAKING THE FUSE BOX TO GO BAD I BELIEVE IT'S SOMETHING TO DO THE WIRING OR FUEL PUMP RELAY FUSE. I'VE HAD MY CAR STALL ON THE HIGH WAY TO MANY TIMES THIS NEED TO BE RECALLED ITS A HAZARD PROBLEM NOT SAFE. *TR
THIS IS MY THIRD COMPLAINT BECAUSE MY CAR HAS ELECTRICAL ISSUES THAT NEED REPAIRED. THE VEHICLE WOULD NOT START, WOULD HAVE TO TAP ON FUEL BOX LOCATED IN TRUNK TO GET IT TO START. IN THE MIDDLE OF DRIVING THE CAR, THE CAR WOULD LOSE POWER AND ESC, TRACTION CONTROL, CHECK ENGINE LIGHT WOULD COME ON AND POWER STEERING WOULD LOCK U…
Read full complaint
THIS IS MY THIRD COMPLAINT BECAUSE MY CAR HAS ELECTRICAL ISSUES THAT NEED REPAIRED. THE VEHICLE WOULD NOT START, WOULD HAVE TO TAP ON FUEL BOX LOCATED IN TRUNK TO GET IT TO START. IN THE MIDDLE OF DRIVING THE CAR, THE CAR WOULD LOSE POWER AND ESC, TRACTION CONTROL, CHECK ENGINE LIGHT WOULD COME ON AND POWER STEERING WOULD LOCK UP. TOOK IT TO NEAREST CHEVY DEALER AND THEY SAID 'THE WIRING IS BURNT UP FROM THE FUEL PUMP/FUSE BOX LOCATED IN TRUNK' THIS IS BECAUSE GM USED CHEAP WIRING. MY PASSENGER HEADLIGHT KEEPS GOING OUT, REAR DEFROST DOESN'T WORK, AND MY DOOR SPEAKERS DOESN'T NOT WORK. THIS IS ALL BECAUSE OF THE WIRING LOCATED IN THE TRUNK. I REFUSE TO PAY OVER $2,000 TO FIX MYSELF WHEN THIS IS CLEARLY A GM ISSUE. EVERYBODY ON HERE HAS THE SAME PROBLEM WITH THEIR MALIBU'S. AND IT REALLY SUCKS BECAUSE I'M MAKING PAYMENTS ON A CAR I CANNOT DRIVE. THIS IS REALLY DANGEROUS ESPECIALLY WHEN I HAVE MY KIDS IN THE CAR AND IT JUST LOSES POWER AND CUT OFF IN THE MIDDLE OF TRAFFIC.
I HAVE A 2012 CHEVY MALIBU LT AND MY CAR HAS THE SAME PROBLEM AS EVERYBODY ELSE'S. IT WOULD CUT OFF AND LOSE POWER WHILE DRIVING AND AT FIRST I WOULD BEAT THE FUSE BOX IN THE TRUNK AND IT WOULD RUN. NOW IT DOESN'T EVEN WORK AT ALL. HAD IT DIAGNOSED AT MY LOCAL CHEVY DEALER AND THEY SAID THE WIRING LEADING FROM THE FUEL PUMP AND …
Read full complaint
I HAVE A 2012 CHEVY MALIBU LT AND MY CAR HAS THE SAME PROBLEM AS EVERYBODY ELSE'S. IT WOULD CUT OFF AND LOSE POWER WHILE DRIVING AND AT FIRST I WOULD BEAT THE FUSE BOX IN THE TRUNK AND IT WOULD RUN. NOW IT DOESN'T EVEN WORK AT ALL. HAD IT DIAGNOSED AT MY LOCAL CHEVY DEALER AND THEY SAID THE WIRING LEADING FROM THE FUEL PUMP AND FUEL BOX IS ALL BURNT UP. I REFUSE TO PAY $2000 OR MORE TO FIX WHEN THIS IS CLEARLY A GM ISSUES. IT NEEDS A RECALL ON THIS VEHICLE BECAUSE THEY USED CHEAP WIRING. THIS IS MY SECOND COMPLAINT AND I WILL CONTINUE TO WRITE COMPLAINS UNTIL IT IS FIXED. ESC, POWER STEERING WOULD LOCK UP WHICH MAKES IT VERY DANGEROUS ESPECIALLY WITH KIDS IN THE VEHICLE.
Official recalls
215V269000 · Seat Belts
May 8, 2015
General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.
Consequence & remedy
Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.