Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 213 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electronic Stability Control (esc). Review the 174 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

40 crash reports17 fire reports30 injury reports

Structure complaints

19 reports

Clear category filter

81,000 miles · Dec 17, 2015

Structure

Read full complaint

FRONT DRIVERS SIDE DOOR ON 2011 MALIBU WOULD NOT OPEN WHEN SHUT. THE DOOR WAS UNLOCKED BUT WOULD NOT OPEN WHEN I PARKED.I TRIED LOCKING AND UNLOCKING THE VEHICLE AND IT STILL WOULD NOT OPEN. I WAS STUCK IN THE VEHICLE AND I BEGAN PRESSING LOCK AND UNLOCK ON THE KEY FOB SEVERAL TIMES UNTIL I HEARD A POPPING NOISE AND THE DOOR WAS FINALLY ABLE TO BE OPENED. ALL OTHER DOORS WERE LOCKING/UNLOCKING AND WERE ABLE TO BE OPENED PROPERLY. THE VEHICLE HAS BEEN DOING THIS FOR ABOUT A WEEK NOW AND IT HAPPENS INTERMITTENTLY EVERYDAY. I DROPPED IT OFF AT THE DEALERSHIP AND AM AWAITING FURTHER INFORMATION. THIS WOULD BE VERY DANGEROUS DURING AN ACCIDENT/VEHICLE FIRE AS YOU WOULD BE TRAPPED IN THE VEHICLE.

NHTSA ODI #10810835

Mileage unknown · Jun 10, 2015

Structure

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. THE CONTACT STATED THAT THE FRONT DRIVER SIDE DOOR FAILED TO OPEN. THE DEALER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ODI #10724608

54,000 miles · Jun 9, 2015

Electrical SystemStructure

Read full complaint

DRIVER'S DOOR WILL NOT CLOSE AND LATCH PROPERLY OR UNLOCK/UNLATCH TO OPEN. THIS HAS STARTED OCCURRING FREQUENTLY. THERE ARE MANY COMPLAINTS REGARDING DOOR LATCH MECHANISM FAILURES THAT DEALERS ARE MORE THAN WILLING TO FIX FOR HUNDREDS OF DOLLARS. I FEEL THIS IS A SAFETY ISSUE, AS EACH TIME THE CAR IS STARTED, IT IS A GAMBLE, AS TO WHETHER THE DOOR WILL LATCH, OR UNLATCH, PROPERLY, AS NEEDED. IF THIS VEHICLE IS INVOLVED IN AN ACCIDENT, I AM NOT CONFIDENT THAT THE DOOR WILL OPEN, EVEN IF IT IS AN UNDAMAGED ONE, DUE TO THE FAILING LOCK/LATCH MECHANISM. I AM REPLACING THIS AT MY COST BUT FEEL THAT THE MANUFACTURER BEARS RESPONSIBILITY FOR FAULTY PARTS/DESIGN. THANKFULLY, NO ONE IN MY FAMILY HAS BEEN INJURED, YET. I FEAR THAT THIS COULD BE AN ISSUE DURING TIMES OF GREAT STRESS THAT CAN AND WILL LEAD TO FATALITIES, IF LEFT UNADDRESSED.

NHTSA ODI #10724216

60,000 miles · Mar 24, 2015

StructureVehicle Speed Control

Read full complaint

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE REVERSING OUT OF A PARKING SPACE AT AN UNKNOWN SPEED, THE PIECE OF PLASTIC DETACHED FROM THE MIDDLE CONSOLE AND COVERED THE ACCELERATOR PEDAL CAUSING THE VEHICLE TO ACCELERATE WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT WAS MADE AWARE THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

NHTSA ODI #10701327

Mileage unknown · Feb 21, 2015

Structure

I HAVE A 2011 CHEVROLET MALIBU AND WHEN IT RAIN THE DRIVER SIDE ON THE INSIDE ALWAYS GETS WET. ITS THE LEFT SIDE ONLY THAT HAS WATER ON IT. THIS IS BECOMING A PROBLEM BECAUSE I ONLY HAVE HAS THIS CAR FOR A YEAR. YES IT DOES HAVE A SUNROOF BUT NO WATER IS COMING FROM THE SUNROOF. I HAVE HEARD SEVERAL OF TIMES IT COULD BE THE DRAI…

Read full complaint

NHTSA ODI #10689762

45,000 miles · Dec 5, 2013

Air BagsEngineStructureCrashInjury

I WAS GOING ONTO A EXIT AN HIT A GUARDRAIL ON THE DRIVERS SIDE, THE CAR SPUN AND I ENDED UP SIDEWAYS. THE AIRBAG DEPLOYED BUT DID NOT INFLATE. I SUSTAINED BROKEN RIBS, A FACIAL HEMATOMA AND MULTIPLE CONTUSIONS. I WAS WEARING MY SEATBELT AT THE TIME OF THE ACCIDENT. *TR

NHTSA ODI #10554926

26,800 miles · Aug 5, 2013

Electrical SystemSeatsStructure

Read full complaint

THE MANUFACTURER FORGOT TO INSTALL A CLAMP ON THE MOON ROOF DRAIN. THE TUBE FELL OFF AND FLOODED THE INTERIOR OF THE CAR WITH 3 INCHES OF STANDING WATER ON JULY 12, 2013. THE ENTIRE PASSENGER SIDE INCLUDING CEILING, DASH (IN FRONT AND BEHIND), SEATS, FLOORING, AND ELECTRICAL COMPONENTS HAVE WATER DAMAGE. IT THEN HAPPENED AGAIN ON JULY 14, 2013. CONTACT WAS MADE TO THE DEALER ON JULY 16, 2013. AFTER NUMEROUS, MEANINGLESS PHONE CONVERSATIONS WITH CHEVROLET, THEY WOULD ONLY REPLACE SOME COSMETIC PARTS. ONLY THE FLOORING WAS REPLACED AT FIRST. AFTER MORE COMPLAINTS, THE SEAT COVERS AND HEAD LINER WERE REPLACED, BUT NOT THE FACTORY CARPETED FLOOR MATS. THEY REFUSED TO REPLACE OR INSPECT ANYTHING ELSE THAT WATER CAME IN CONTACT WITH INCLUDING ELECTRICAL COMPONENTS, SEAT CUSHIONS, SAFETY RESTRAINTS, WIRING HARNESSES, OR AIRBAG SYSTEM BEHIND THE DASH. OUR 10 YEAR OLD SON HAD A KIDNEY TRANSPLANT TWO YEARS AGO AND HAS A SUPPRESSED IMMUNE SYSTEM. DUE TO THIS, HE CANNOT BE AROUND MOLD WHICH CHEVROLET IS REFUSING TO TEST FOR. BEING THAT ONLY 50% OR LESS OF THE COMPONENTS HAVE BEEN REPLACED, WE ARE CONCERNED OF THE PRESENCE OF MOLD. OUR PHYSICIAN HAS REQUESTED THAT THE CAR BE TESTED AND SIGNED OFF THAT NO MOLD IS PRESENT BEFORE OUR SON CAN RIDE IN THE CAR AGAIN. OUR SON'S HEALTH DEPENDS ON HAVING A SAFE, CLEAN CAR TO BE TRANSPORTED IN. CHEVROLET HAS NO CONCERNS FOR HIS SAFETY OR LIFE THREATENING ISSUES. UNKNOWN ELECTRICAL SAFETY COMPONENTS MAY OR MAY NOT HAVE BEEN COMPROMISED WITH THIS MUCH WATER OR MOISTURE IN THE VEHICLE. THESE PARTS WERE NOT CHECKED, TESTED OR REPLACED. *TR

NHTSA ODI #10533737

21,000 miles · Jul 1, 2013

Air BagsEngineStructureCrashInjury

Read full complaint

ON 6/22/13 AT APPROX 1:40PM I WAS HEADING BACK TO WORK FROM MY LUNCH BREAK AND I WAS GOING THROUGH THE INTERSECTION ON MY GREEN LIGHT AT APPROX 30MPH WHEN A BIG CHEVY TRUCK BLEW THROUGH THE RED LIGHT GOING APPROX 40 MPH. I ENDED UP T BONING THE CAB OF HIS TRUCK. CAUSING ME TO DO A 360. TORE OFF THE BUMPER COMPLETELY. MY AIRBAGS DID NOT DEPLOY AND ONSTAR DID NOT CALL ME. TWO IMPORTANT SAFETY FEATURES OF MY CAR FAILED ME! I THANK GOD I AM ALIVE WITH NO SERIOUS INJURIES! EVERYONE WHO SAW MY CAR INCLUDING THE BODY SHOP ARE IN COMPLETE SHOCK OF MY AIR BAGS NOT DEPLOYING! I REALLY WOULD LIKE TO KNOW THE CAUSE! *TR

NHTSA ODI #10522768

42,568 miles · Mar 16, 2013

Electrical SystemElectronic Stability Control (esc)Structure

Read full complaint

DRIVING 65 MPH ON INTERSTATE AND SERVICE ESC AND ALL OTHER LIGHTS CAME ON AND ENGINE DIED. I HAD TO MANEUVER 3 LANES TO THE RIGHT IN RUSH HOUR TO GET TO THE BREAKDOWN LANE WITHOUT POWER STEERING. "FAULTY ALTERNATOR" RULED TO BE AT FAULT. NO WARNING THAT MORNING PRIOR TO EVENT. TWO DAYS BEFORE THE BATTERY LIGHT STAYED ON A LITTLE LONGER (5 MINUTES) THAN USUAL AND THEN WENT OFF. IT NEVER CAME ON AGAIN TO WARN OF SOMETHING WRONG. I CALLED CHEVROLET AND THE CUSTOMER SERVICE WAS INDIFFERENT SO I FILED A COMPLAINT WITH MY STATE'S BBB AS THIS IS THE THIRD, AND MOST SEVERE ISSUE, I HAVE HAD WITH THIS CAR AND I HAVE NOT HAD IT TWO YEARS QUITE YET. I DID RECEIVE A CALL BACK FROM GM. THEY ARE WORKING ON THEIR RESPONSE TO THIS LIFE THREATENING EVENT AS WELL AS THE OTHER PROBLEMS, WHICH WERE THE EXHAUST SOLENOID DIED ( SERVICE ENGINE LIGHT CAME ON) AND THE DRIVER'S SIDE DOOR HANDLE COVERING CAME OFF EXPOSING THE SHARP METAL IT IS MADE OF). *TR

NHTSA ODI #10503271

Official recalls

19V019000 · Air Bags:frontal:driver Side:inflator Module

Jan 16, 2019

General Motors LLC (GM) is recalling certain 2010-2011 Chevrolet Malibu vehicles. In the event of a crash necessitating deployment of the driver frontal air bag, the air bag inflator may explode due to being overpressurized.

Consequence & remedy

Consequence: If the inflator explodes, sharp metal fragments may strike the driver or other occupants resulting in serious injury or death.

Remedy: GM has notified owners, and dealers will replace the front driver air bag module, free of charge. The recall began February 25, 2019. Owners may contact GM customer service at 1-800-522-9559. GM's number for this recall is N182206630.

15V269000 · Seat Belts

May 8, 2015

General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.

Consequence & remedy

Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)