Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 213 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electronic Stability Control (esc). Review the 174 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

40 crash reports17 fire reports30 injury reports

Power Train complaints

112 reports

Clear category filter

Mileage unknown · Aug 24, 2021

Power Train

Read full complaint

On busy city 3 lane highway transmission failed to engage. I managed to drift right to immediate side street, emergency blinkers on, horns blowing. Turned corner and stopped. No warnings, lights, sounds. 59,908 mileage! Insurance co towed to transmission shop. Mechanic had to completely rebuild $2,132. Insisted not normal problem for such low mileage. I will be contacting Chevy dealer, ect. This car is available for any inspection. I have 0 confidence in the safety of this car. When I picked up the owner of shop pointed out an identical vehicle in his lot, yes, waiting for another transmission replace/repair.

NHTSA ODI #11430310

79,632 miles · Jan 19, 2021

Power Train

Read full complaint

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 30 MPH ON A RAMP AND ATTEMPTING TO ENTER HIGHWAY TRAFFIC, THE VEHICLE STALLED WITHOUT WARNING. ADDITIONALLY, THE CONTACT ALSO WANTED TO STATE THAT PREVIOUSLY THE GEAR SHIFTER FAILED TO ENGAGE IN REVERSE. THE VEHICLE WAS TOWED TO ROY ROBINSON CHEVROLET (6616 35TH AVENUE NE, MARYSVILLE, WA, 98271, (360) 659-6236) WHERE THE DEALER PERFORMED A DIAGNOSTIC TEST AND INFORMED THE CONTACT THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED OR REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 79,632.

NHTSA ODI #11388880

90,000 miles · Aug 18, 2020

Power Train

CAR QUIT SHIFTING INTO 3RD, 4TH OR 5TH GEAR AND REVERSE. EXITING THE HIGHWAY WHEN IT DOWNSHIFTED VERY SUDDENLY AND VERY HARD. FROM THERE STOPPED AT RED LIGHT. WENT TO TAKE OFF AND IT SLIPPED IN 2ND GEAR. FROM THERE PROGRESSIVELY GOT WORSE. NEXT TIME I TRIED REVERSE IT WOULD NOT GO AT ALL. LEADS ME TO BELIEVE IT'S THE TRANSMISS…

Read full complaint

NHTSA ODI #11350042

132,000 miles · Jul 13, 2020

Power TrainSeat Belts

WHILE MY SEATBELT IS FASTENED THE SEATBELT NOTIFICATION GOES OFF AS IF ITS NOT FASTENED. ALSO AS I'M ACCELERATING IT'S LIKE MY CAR STRUGGLES TO GET TO 40 MPH. SOMETIMES I HAVE TO GIVE IT A LITTLE MORE GAS FOR IT TO GO OVER 40

NHTSA ODI #11338972

36,000 miles · Jul 3, 2020

EnginePower Train

TIMING CHAIN AND ENGINE MALFUNCTION. REVIEWED THE INTERNET AND THERE ARE THOUSANDS OF COMPLAINTS REGARDING THE SAME THING. THE 2.4 ECOTECH ENGINE WAS IN A CLASS ACTION SUIT FOR EQUINOXS BUT NOT MALIBUS AND THEY HAVE THE SAME ISSUE.

NHTSA ODI #11337353

137,000 miles · Jun 8, 2020

Electrical SystemEnginePower Train

Read full complaint

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE ESC, THE SERVICE TRACTION CONTROL, AND THE ENGINE REDUCED POWER WARNING LIGHTS ILLUMINATED. THE VEHICLE ALSO VIBRATED ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED AN ELECTRICAL SHORT IN THE WIRING SYSTEM, AND REPLACED THREE DIFFERENT SENSORS. THE TECHNICIAN ALSO REPROGRAMMED THE ENGINE CONTROL UNIT. THE FAILURES RECURRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 137,000.

NHTSA ODI #11327797

140,000 miles · Apr 11, 2020

Electrical SystemEnginePower Train

I BOUGHT MY 2011 CHEVY MALIBU IN MARCH OF 2017. ONLY PUT 30K MILES AND IT'S APRIL OF 2020. MY CAR WON'T CRANK UP SOMETIMES OR WHEN I'M IDLE, IT'LL START TO SHAKE AND I HAVEN'T DROVE MY CAR IN A WEEK BUT WHEN I PUT THE KEY IN AND TRY TO TURN IT, NOTHING COMES ON. NO LIGHTS OR ANYTHING

NHTSA ODI #11320878

45,000 miles · Mar 10, 2020

Electrical SystemPower TrainVehicle Speed Control

Read full complaint

I HAVE A 2011 CHEVY MALIBU LTZ WITH 44,589 MILES AND I HAVE AN ISSUE WITH MY SCREENS READING THAT MY ESC SYSTEM IS BAD AND WILL REDUCE MY ENGINE POWER, I TOOK IT IN TO AIRPORT CHEVROLET IN MEDFORD, OREGON AND THEY PLUGED MY CAR IN AND TOLD ME HE HAS SEEN THIS ISSUE COUNTLESS TIMES, AND HAS SEEN PEOPLE HAVE TO REPLACE THINGS AS SIMPLE AS A SENSOR ALL THE WAY TO IT BEING AN ISSUE IN THE WIRING HARNESS AND PEOPLE WILL BRING THEIR CAR IN AND DO THE SMALL REPAIRS FIRST ( ECONOMICALLY MAKES SENSE) AND IT WILL NOT FIX THE PROBLEM.. UNTIL THEY FIX THIS HUGE EXPENSIVE ISSUE ALL BECAUSE. CHEVY HAS AN ISSUE WITH A SYSTEM THEY PUT INTO A CAR THAT DOESN'T WORK PROPERLY! I HAVE READ OTHER REVIEWS VERY SIMILAR TO MINE WHERE PEOPLE HAVE BEEN HIT IN TRAFFIC . NOW LUCKILY I CAUGHT MINE BEFORE A WRECK. THIS NEEDS TO BE FIXED!

NHTSA ODI #11317263

166,000 miles · Jan 24, 2020

EnginePower TrainUnknown Or Other

Read full complaint

MY 2011 CHEVY MALIBU BURNING OIL I KEEP HAVING ADD OIL TO CAR ON TOP THAT TIMING BELT BROKE CHANCES OUT EXHAUST CAMSHAFT POSSIBLE SENSOR OUT 2-3 TIMES AND CODE REMAIN LATER CHAIN GUIDES BROKE SEEN 2.4L EQUINOX HAD RECALL DUE TO BURNING OIL NOT SURE TIMING CHAIN BRAKE BUT HEARD ALOT COMPLAIN ABOUT CHAIN GUIDES BREAKING ALSO SEAT BACKING KEEP CALLING OFF LATCHES FOR THEM FAIL EVERY TIME CAR JUST GAVE ME ALOT OF PROBLEM CONTROL ARM GOING OUT. CAR WAS MADE CHEAP AND WASN'T MEANT TO LAST. CAR BROKE DOWN TIMING CHAIN SNAPPED.BURNT OIL SMELL WHEN TURN CAR ON COMING THROW AC WHEN ON. 2.4 L ECOTEC MOTOR IS PROBLEM AS WELL POWER TRAIN TRANSMISSION BREAK REVERSE WAVE GEAR MAKING IT A COSTLY REPAIR.

NHTSA ODI #11301512

103,000 miles · Oct 15, 2019

Power Train

Read full complaint

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. WHILE DRIVING, THE VEHICLE DECELERATED, THE RPMS REVVED, THE VEHICLE LOST POWER, AND A SPEED SENSOR FOR THE ENGINE ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE A CODE FOR THE SPEED SENSOR WAS FOUND. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT SPOKE WITH PRIORITY CHEVROLET (1495 S MILITARY HWY, CHESAPEAKE, VA 23320, (757) 424-1811) AND WAS INFORMED THAT THERE WERE NO RECALLS. THE CONTACT RESEARCHED THE ISSUE AND FOUND A LOT OF THE SAME MODEL VEHICLES THAT WERE EXPERIENCING THE SAME FAILURES EVEN WITH THE TRANSMISSION REPLACED AROUND 90,000 TO 95,000 MILES. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 103,000. THE VIN WAS UNKNOWN.

NHTSA ODI #11268611

Official recalls

19V019000 · Air Bags:frontal:driver Side:inflator Module

Jan 16, 2019

General Motors LLC (GM) is recalling certain 2010-2011 Chevrolet Malibu vehicles. In the event of a crash necessitating deployment of the driver frontal air bag, the air bag inflator may explode due to being overpressurized.

Consequence & remedy

Consequence: If the inflator explodes, sharp metal fragments may strike the driver or other occupants resulting in serious injury or death.

Remedy: GM has notified owners, and dealers will replace the front driver air bag module, free of charge. The recall began February 25, 2019. Owners may contact GM customer service at 1-800-522-9559. GM's number for this recall is N182206630.

15V269000 · Seat Belts

May 8, 2015

General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.

Consequence & remedy

Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)