Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 213 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electronic Stability Control (esc). Review the 174 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

40 crash reports17 fire reports30 injury reports

Exterior Lighting complaints

130 reports

Clear category filter

Mileage unknown · Jun 18, 2026

Electrical SystemExterior LightingFire

Read full complaint

There was a fire in the trunk on the way to work. Fire department was called to inspect the car and make sure that the fire was out. Fire melted fuse box located in the trunk along with wiring harness and wires, also causing all electrical items to stop working. Claim was attempted to be made, but insurance did not cover this particular issue. After hours of reading as well as watching videos, this seems to be an on problem for Malibu's from 2011-2016. I bought this car one year ago and had a mechanic inspect the vehicle.

NHTSA ODI #11745051

122,000 miles · Jun 15, 2026

Electrical SystemExterior LightingVehicle Speed Control

Read full complaint

The contact owns a 2011 Chevrolet Malibu. The contact stated that while operating the vehicle, the ESC and traction control warning lights remained illuminated. Additionally, while the cruise control was activated and the brake pedal was depressed, the vehicle unintendedly accelerated. The contact stated that the gear shifter was able to be moved without the brake pedal being depressed. The cause of the failures were not yet determined. The manufacturer and local dealer were notified of the failures, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 14V252000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL (ESC). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 122,000.

NHTSA ODI #11744231

85,000 miles · Jan 2, 2026

Electrical SystemExterior LightingFire

Read full complaint

The contact owns a 2011 Chevrolet Malibu. The contact stated that while the vehicle was parked under a carport in her driveway, she had been warned by neighbors that the rear end of the vehicle was on fire. The contact stated that she saw that flames were issuing from both rear light housings. The contact stated that by the time her husband and a neighbor attempted to extinguish the flames with garden hoses, the light housings and the rear bumper were on fire and melting. The fire department and the police were called. The contact stated that by the time emergency services arrived, the flames had been extinguished. The contact stated that the fire department opened the trunk, and the interior of the trunk and the matting were not damaged. The only damage was to the rear light housings and the rear bumper. The fire department had not issued a report, however the police had. The vehicle was not taken to a dealer or to an independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 85,000.

NHTSA ODI #11708409

Mileage unknown · Nov 17, 2025

Electrical SystemExterior LightingVisibility/wiper

Read full complaint

Headlight wiring harness connector has melted multiple times leaving me without low beam headlights while driving at night with my children in the car. This has left me having to use my high beams to drive and this poses as a safety hazard for not only me and my family but other people on the road. This also poses a fire hazard if the plastic connector is getting hot enoughto melt. I have requested warranty replacements for this part through AC Delco and made them aware of the on going problem and informed them that this is a well known issue with this car and that it is extremely dangerous. I have not had the part inspected by a mechanic, insurance company or law enforcement but have the failed part and would be willing to have it inspected by law enforcement or anyone else but can not afford out of pocket expenses to do so. There was no prior warning to this happening any of the times it happened it would be working when I left my house I would stop somewhere turn the car off and when I got back in and started the car they wouldn't turn on. Another time they quit working while driving down the road. The date below is the date that I ordered the first replacement wiring harness it lasted less than 3 months and i had to have it replaced and currently I am dealing with not having low beams again this is the 3rd time I have dealt with this issue and it has been on going since January 2025.

NHTSA ODI #11699889

Mileage unknown · Feb 17, 2025

Electrical SystemExterior Lighting

Read full complaint

Two months ago While driving on the highway at 60 mph at night my headlights shut off with no warning leaving only my running lights, turn signals, brake lights and hazards lights functioning. Neither hi or low beams would function. Yet no warning or service lights appeared on the dash. Local mechanic replaced both the headlights bulbs and connectors on both sides. 3 weeks later it happened again, this time when I started my car the headlights failed to turn on. So i contacted a local Chevy dealer (Rob Eck chevy) who said there was no recall or investigation...so I took it back the mechanic and had him fix it AGAIN. Just a few minutes ago today when I went to go to work yet AGAIN the headlights won't turn on. Checked through a plethora of forums about the Malibu both fan sites and manufacturers sites and have found that this is an extremely common issue for 2008-2014 Malibus, As this is an extremely dangerous failure/malfunction for both the driver and everyone else on the road I am STUNNED that there's no recall or at least an INVESTIGATION into this as with this many occurrences with so many owners it's virtually impossible to be owner fault ergo it must be a product defect or a manufacturer defect....please do what's right for the safety and well being of others not what's right to protect the rich lining their pockets

NHTSA ODI #11643114

Mileage unknown · Jan 12, 2025

Electrical SystemExterior Lighting

I'm having to replace the low beam headlight in my car more times than a lil bit! I hate that I'm constantly spending $60+ everytime on headlights cause of i replace one side imma replace the other! I have brought the replacement harness for the lights and the low beam still blows!

NHTSA ODI #11635518

Mileage unknown · Jun 11, 2024

Exterior Lighting

Passenger headlight keeps going out. Have had to replace 4 times in 3 years. Difficult taking off entire bumper

NHTSA ODI #11593651

Mileage unknown · Jan 9, 2024

Electrical SystemExterior Lighting

Passenger side low beam headlight bulb connector melted/burnt. Caused low beam to go out on occasion - hit a bump and it switches on/off

NHTSA ODI #11564517

Mileage unknown · May 29, 2023

Exterior Lighting

Read full complaint

I purchased this 2011 Cheverolet Malibu brand new. A few years prior to me giving it to my daughter, I had to get the headlights replaced several times, one would go out a month or so after I had the other one fixed. I gave it to her in 2019 and lately every other week one or even BOTH of the front headlights have gone out. Also, the third brake lamp randomly goes out and now one of the rear brake lamps has gone out. There’s already over 100 complaints about these issues with this particular model but GM has yet to do a recall! WHY?? It’s clearly an issue with the vehicle and the fact that the ENTIRE front bumper has to come off to get to it is the dumbest thing I’ve ever seen!!! Headlights, of all things, randomly going out on a vehicle is not safe at all! There are people out here who have children in these faulty vehicles and clearly neither GM nor the NHTSA cares. What is it going to take for someone to do something about this, deaths???

NHTSA ODI #11524274

Mileage unknown · May 15, 2023

Exterior LightingSeat Belts

Driverside Airbag light will come on with Service Airbag message. This does occasionally turn off but comes back for days or weeks at a time. Driver side seatbelt light will randomly come on and stay on or turn off. Both airbag and seatbelt light may be on at the same time. If they are all off or the airbag light turns off it…

Read full complaint

NHTSA ODI #11522179

Official recalls

19V019000 · Air Bags:frontal:driver Side:inflator Module

Jan 16, 2019

General Motors LLC (GM) is recalling certain 2010-2011 Chevrolet Malibu vehicles. In the event of a crash necessitating deployment of the driver frontal air bag, the air bag inflator may explode due to being overpressurized.

Consequence & remedy

Consequence: If the inflator explodes, sharp metal fragments may strike the driver or other occupants resulting in serious injury or death.

Remedy: GM has notified owners, and dealers will replace the front driver air bag module, free of charge. The recall began February 25, 2019. Owners may contact GM customer service at 1-800-522-9559. GM's number for this recall is N182206630.

15V269000 · Seat Belts

May 8, 2015

General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.

Consequence & remedy

Consequence: If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)