IllustrationWHEN I FILLED UP MY GAS TANK IT STARTED READING INCORRECTLY, AND WOULD SHOW EMPTY. OVER THE PERIOD OF A WEEK THE GAS GAUGE DOES NOT WORK AT ALL AND MY CHECK ENGINE LIGHT IS ON ALL THE TIME. TOOK IT TO MECHANIC AND HE STATED THAT THE SENOR NEEDS TO BE REPLACED. THIS IS OVER A $500 COST. *TR
2006 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2006 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
650–25K
11925–50K
18850–75K
17475–100K
229100–150K
138150K+
913 reports with mileage · 202 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 810 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports6 fire reports17 injury reports
Fuel System, Gasoline complaints
41 reportsFUEL LEVEL SENSOR FAILURE. FUEL READS EMPTY EVEN THOUGH THE GAS TANK IS FILLED. IT TOOK 3 HOURS AND 322 DOLLARS TO FIX.. UNREASONABLE IS ALL I CAN SAY... *TR
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT AFTER REFUELING, THE FUEL GAUGE WOULD DISPLAY AN INACCURATE READING. THE CONTACT MENTIONED THAT THE LOW FUEL GAUGE AND THE FUEL CAP WARNING LIGHTS ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGN…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT AFTER REFUELING, THE FUEL GAUGE WOULD DISPLAY AN INACCURATE READING. THE CONTACT MENTIONED THAT THE LOW FUEL GAUGE AND THE FUEL CAP WARNING LIGHTS ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT TWO FUEL LEVEL SENSORS AND THE FUEL LEVEL SENDING UNIT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11E009000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 146,800 AND THE CURRENT MILEAGE WAS 147,414.
I HAD JUST FILLED MY GAS TANK TO FULL. I DROVE DOWN THE STREET FOR A FEW BLOCKS AND THE FUEL GAUGE ALL OF A SUDDEN WENT TO EMPTY. I PULLED OVER TO THE SIDE OF THE ROAD AND TURN THE CAR OFF, THEN TURNED IT BACK ON AGAIN. THE FUEL GAUGE WENT BACK TO FULL. BUT AS I CONTINUED TO DRIVE DOWN THE STREET, IT WENT BACK DOWN TO EMPTY.…
Read full complaint
I HAD JUST FILLED MY GAS TANK TO FULL. I DROVE DOWN THE STREET FOR A FEW BLOCKS AND THE FUEL GAUGE ALL OF A SUDDEN WENT TO EMPTY. I PULLED OVER TO THE SIDE OF THE ROAD AND TURN THE CAR OFF, THEN TURNED IT BACK ON AGAIN. THE FUEL GAUGE WENT BACK TO FULL. BUT AS I CONTINUED TO DRIVE DOWN THE STREET, IT WENT BACK DOWN TO EMPTY. I TOOK IT TO THE REPAIR SHOP AND WAS TOLD THAT I NEEDED TO REPLACE THE FUEL SENSOR FOR WHICH I DID. HOWEVER, UPON RESEARCHING THE LATEST RECALL OF GM'S THAT ADDRESSES THE STEERING COLUMN ISSUE (I'M HAVING THIS PROBLEM TOO), I DISCOVERED THAT THE FUEL SENSOR ISSUE WAS RECALLED PREVIOUSLY. SO I CALLED CHEVY AND WAS TOLD THAT MY VIN WAS NOT RECALLED. I NEED SOME DIRECTION/GUIDANCE ON HOW TO GET MY VIN INCLUDED IN THE PREVIOUS RECALL, IF AT ALL POSSIBLE SO I MAY BE REIMBURSED. IS THERE ANYTHING I CAN DO SINCE MY MALIBU ALSO EXPERIENCED THE SAME PROBLEM WITH THE FUEL SENSOR AS OTHER MALIBU'S? YOUR ASSISTANCE/GUIDANCE WOULD BE MUCH APPRECIATED. THANK YOU. *TR
I SEE THAT THERE HAS BEEN A RECALL FOR CHEVY MALIBU 2004-2007 ON FUEL PUMPS WITH A PART NUMBER OF TU456. MY FUEL PUMP HAS NOT BEEN WORKING CORRECTLY, AND I AM NOT SURE IF THIS WAS PART OF THE RECALL OR NOT. I AM HOPING THIS IS ONE OF THE VEHICLES THAT WAS IN THE RECALL, SO NOTHING HAPPENS TO ME OR MY FAMILY WHILE DRIVING DOWN TH…
Read full complaint
I SEE THAT THERE HAS BEEN A RECALL FOR CHEVY MALIBU 2004-2007 ON FUEL PUMPS WITH A PART NUMBER OF TU456. MY FUEL PUMP HAS NOT BEEN WORKING CORRECTLY, AND I AM NOT SURE IF THIS WAS PART OF THE RECALL OR NOT. I AM HOPING THIS IS ONE OF THE VEHICLES THAT WAS IN THE RECALL, SO NOTHING HAPPENS TO ME OR MY FAMILY WHILE DRIVING DOWN THE ROAD. IF SO I WOULD LIKE SOMEONE TO FIX THIS AS IN CHEVY FIXING THIS PROBLEM. THANK YOU. *TR
SOON AFTER I PURCHASED THIS CAR I STARTED HAVING PROBLEMS WITH THE POWER STEERING SYSTEM. IN MANY OCCASIONS WHEN I START THE ENGINE THE POWER STEERING DOES NOT WORK. I CANNOT MOVE THE STEERING WHEEL. I TURN THE ENGINE OFF, WAIT A FEW SECONDS AND START THE ENGINE AGAIN, AND THE POWER STEERING WORKS. I HAVE HAD THIS PROBLEMS AT LE…
Read full complaint
SOON AFTER I PURCHASED THIS CAR I STARTED HAVING PROBLEMS WITH THE POWER STEERING SYSTEM. IN MANY OCCASIONS WHEN I START THE ENGINE THE POWER STEERING DOES NOT WORK. I CANNOT MOVE THE STEERING WHEEL. I TURN THE ENGINE OFF, WAIT A FEW SECONDS AND START THE ENGINE AGAIN, AND THE POWER STEERING WORKS. I HAVE HAD THIS PROBLEMS AT LEAST 15 OR 20 TIMES SINCE I PURCHASED THE CAR IN JANUARY 9, 2012. IT HAS NEVER HAPPENED WITH THE CAR MOVING. ALSO WHEN I MOVE THE STEERING WHEEL FROM ONE SIDE TO THE OTHER THE POWER STEERING ALERT LIGHT COMES ON AND OFF AND I HEAR A CLUNK NOISE THAT I CAN FEEL IN THE STEERING WHEEL. IT IS LIKE IF SOMETHING IS LOOSE IN THE STEERING SYSTEM. I CHECKED THE RACK AND PINION IN SEVERAL OCCASIONS AND FOUND IT HAD THE SCREWS THAT HOLD IT TO THE FRAME LOOSE. I TIGHTENED THEM BUT THE NOISE DOES NOT GO AWAY. I DRIVE THIS CAR WITH CAUTION AND FEAR BECAUSE OF THE POWER STEERING PROBLEM AND THE NOISE IN THE STEERING SYSTEM. THIS MONTH (APRIL 2014) I STARTED HAVING PROBLEMS WITH THE FUEL LEVEL SENDING UNIT. SOMETIMES IT MARKS FULL AND OTHERS EMPTY WITH GAS IN THE TANK. AT THE SAME TIME THE CHECK ENGINE LIGHT COMES ON AND OFF. *TR
WAS AND THE STEERING WHEEL LOCKED UP WHILE IT WAS RAINING CAR STOPPED AND GOT FLOODED UNDER THE UNDER PASS COULDN'T MOVE THE CAR MOTOR WOULDN'T START ARE ANYTHING WE HAD TO GET RESCUED OUT OF THE CAR DUE TO THE POWER. *TR
I HAVE BEEN REPETITIVELY TURNED AWAY BY VARIOUS GM DEALERSHIPS TO ADDRESS SERIOUS ISSUES WITH MY VEHICLE & POTENTIAL RECALLS. MY ISSUES INCLUDE - STEERING MALFUNCTIONS MAKING THE VEHICLE DIFFICULT TO CONTROL, FAULTY FUEL PUMP SENDING UNIT CAUSING CHECK ENGINE LIGHT TO ILLUMINATE & VEHICLE TO STALL, UNCONTROLLABLE VIBRATIONS WHEN…
Read full complaint
I HAVE BEEN REPETITIVELY TURNED AWAY BY VARIOUS GM DEALERSHIPS TO ADDRESS SERIOUS ISSUES WITH MY VEHICLE & POTENTIAL RECALLS. MY ISSUES INCLUDE - STEERING MALFUNCTIONS MAKING THE VEHICLE DIFFICULT TO CONTROL, FAULTY FUEL PUMP SENDING UNIT CAUSING CHECK ENGINE LIGHT TO ILLUMINATE & VEHICLE TO STALL, UNCONTROLLABLE VIBRATIONS WHEN BREAKING AT HIGH SPEEDS NEARLY CAUSING ME TO WRECK, POPPING SOUNDS IN THE SUSPENSION SYSTEM, AND FINALLY UNEXPLAINED ELECTRICAL MALFUNCTIONS SUCH AS RADIO SWITCHING CHANNELS ON ITS OWN, FAILURE OF KEYLESS ENTRY SYSTEM, FAILURE OF REMOTE ENTRY SYSTEM, BUZZING OF LIGHTS WHEN DIMMING, AND FLICKERING OF HEADLIGHTS. I HAVE BEEN TOLD BY DEALERSHIPS THAT BECAUSE MY VEHICLE IS A "FLEET CAR" THAT IT DOES NOT QUALIFY FOR ANY RECALLS. PROBLEMS BEGAN WHILE UNDER WARRANTY. STEERING WIRING HARNESS WAS REPLACED WHILE UNDER WARRANTY. AT AROUND 65,000 MILES, SYSTEMS BEGAN TO FAIL DESPITE MY REGULAR CARE OF THE VEHICLE WHICH I HAVE DOCUMENTED. AFTER WARRANTY EXPIRED, I WAS ROUTINELY TURNED DOWN FOR RECALL INSPECTIONS. A RECENT EMISSIONS INSPECTION CAUSED CONCERN BY THE MECHANIC OVER THE STEERING OF THE VEHICLE AND I WAS ENCOURAGED TO ADDRESS THESE PROBLEMS AGAIN. I CANNOT AFFORD A NEW CAR. *TR
I RECEIVED A RECALL NOTICE GM STATING THAT THERE WAS A RECALL CONCERNING THE FUEL SYSTEM IE FUEL PUMP ON MY 2006 CHEVY MALIBU. THIS RECALL CAUTIONED THAT INTERMITTENT STALLING MAY CREATE A HAZARDOUS CONDITION THAT COULD POSSIBLY RESULT IN VEHICLE. AS A RESULT I SCHEDULED AN APPOINTMENT TO HAVE THIS CONDITION CORRECTED ON THE DA…
Read full complaint
I RECEIVED A RECALL NOTICE GM STATING THAT THERE WAS A RECALL CONCERNING THE FUEL SYSTEM IE FUEL PUMP ON MY 2006 CHEVY MALIBU. THIS RECALL CAUTIONED THAT INTERMITTENT STALLING MAY CREATE A HAZARDOUS CONDITION THAT COULD POSSIBLY RESULT IN VEHICLE. AS A RESULT I SCHEDULED AN APPOINTMENT TO HAVE THIS CONDITION CORRECTED ON THE DATE OF THE APPOINTMENT I ARRIVED WITH THE VEHICLE IN QUESTION AND WAS TURNED AWAY. THE DEALERSHIP CLAIMED THAT THIS WAS A LIMITED RECALL AND THE RECALL FOR REPAIR HAD EXPIRED. I WAS ADVISED OF THIS RECALL BY MY REGULAR MECHANIC WHILE IN FOR UNRELATED MAINTENANCE. IT WAS THEN THAT HE INSTRUCTED ME TO MAKE AN APPOINTMENT WITH GM TO REPAIR THIS PROBLEM WITH NOT CHARGE TO ME. BEFORE I HAD KNOWLEDGE OF THIS RECALL, MY DAUGHTER WAS INVOLVED WITH A MOTOR VEHICLE ACCIDENT THAT DIRECTLY RELATED TO THIS PROBLEM IE FUEL SYSTEM. THE ACCIDENT OCCURRED WHEN THE ENGINE STALLED ON THIS VEHICLE, AS A RESULT ANOTHER VEHICLE COLLIDED WITH MINE CAUSING MAJOR DAMAGE TO BOTH VEHICLES AND POTENTIAL INJURY TO THE 2 OCCUPANTS OF MY VEHICLE. IF YOU NEED FURTHER INFORMATION CONCERNING THE ACCIDENT I WILL HAVE TO GET EITHER A COPY OF THE POLICE REPORT AND INSURANCE CLAIM INFORMATION. PLEASE LET ME KNOW IF THIS IS NECESSARY. THANK YOU *TR
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT AFTER REFUELING, THE FUEL GAUGE WOULD DISPLAY AN INACCURATE READING. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT AFTER REFUELING, THE FUEL GAUGE WOULD DISPLAY AN INACCURATE READING. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 02/11/14*LJ
Official recalls
615V064000 · Steering:electric Power Assist System
Feb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
05V486000 · Equipment:other:labels
Oct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
Consequence & remedy
Consequence: A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
Remedy: OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.