IllustrationWHILE DRIVING MY BRAKE LIGHTS ARE STAYING ON, I ONLY KNOW WHEN SOMEONE TELLS ME I HAVE BEEN TAKING MY CAR TO THE DEALERSHIP SINCE 2007 AND THE PROBLEM STILL HAS NOT BEEN FIXED. I HAVE CARS HUNK THE HORNS AT ME AND OTHER DRIVERS ARE FLASHING THEIR LIGHTS BECAUSE THEY DON'T KNOW IF I AM STOPPING OR GOING. *TR
2006 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2006 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
650–25K
11925–50K
18850–75K
17475–100K
229100–150K
138150K+
913 reports with mileage · 202 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 810 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports6 fire reports17 injury reports
Exterior Lighting complaints
63 reportsTHE BRAKE LIGHTS ON MY 2006 CHEVY MALIBU WORK IN REVERSE. APPROX 45 SECONDS AFTER THE CAR IS PUT INTO DRIVE THE BRAKE LIGHTS COME ON AND STAY ON UNTIL THE BRAKE PEDAL IS DEPRESSED. THIS IS NOT AN INTERMITTENT PROBLEM BUT IS CONTINUOUS. I ALSO CANNOT ENGAGE MY CRUISE CONTROLS. IT IS A MATTER OF TIME BEFORE A REAR END COLLISIO…
Read full complaint
THE BRAKE LIGHTS ON MY 2006 CHEVY MALIBU WORK IN REVERSE. APPROX 45 SECONDS AFTER THE CAR IS PUT INTO DRIVE THE BRAKE LIGHTS COME ON AND STAY ON UNTIL THE BRAKE PEDAL IS DEPRESSED. THIS IS NOT AN INTERMITTENT PROBLEM BUT IS CONTINUOUS. I ALSO CANNOT ENGAGE MY CRUISE CONTROLS. IT IS A MATTER OF TIME BEFORE A REAR END COLLISION OCCURS. I HAVE RESEARCHED THIS PROBLEM ON LINE AND IT APPEARS THAT MANY OTHER CONSUMERS HAVE HAD THIS PROBLEM TOO. ALL OF WHICH COMMENT THAT THEIR AREA DEALERS CHARGED THEM A LOT OF MONEY, WERE UNSURE OF THE FIX, AND IN SOME CASES THE REPAIRS MADE WERE ONLY TEMPORARY FIXES. SEVERAL HAVE MENTIONED REPLACING PART # 15940467 WHICH IS A MODULE. *TR
THE BRAKE LIGHTS ON MY 2006 CHEVROLET MALIBU LTZ SOMETIMES WORK THE OPPOSITE FROM HOW THEY SHOULD (I.E. WHEN THE BRAKE PEDAL IS APPLIED THE BRAKE LIGHTS GO OUT, WHEN THE BRAKE PEDAL IS RELEASED THE BRAKE LIGHTS COME ON). THIS PROBLEM IS INTERMITTENT; SOMETIMES THE BRAKE LIGHTS WORK NORMALLY. THE ISSUE WAS FIRST NOTICED ABOUT A Y…
Read full complaint
THE BRAKE LIGHTS ON MY 2006 CHEVROLET MALIBU LTZ SOMETIMES WORK THE OPPOSITE FROM HOW THEY SHOULD (I.E. WHEN THE BRAKE PEDAL IS APPLIED THE BRAKE LIGHTS GO OUT, WHEN THE BRAKE PEDAL IS RELEASED THE BRAKE LIGHTS COME ON). THIS PROBLEM IS INTERMITTENT; SOMETIMES THE BRAKE LIGHTS WORK NORMALLY. THE ISSUE WAS FIRST NOTICED ABOUT A YEAR AGO AND I TOOK THE CAR TO THE DEALER. THEY THOUGHT IT WAS A BRAKE LIGHT INDICATOR SWITCH SO THEY REPLACED IT. THE PROBLEM REAPPEARED WITHIN A MONTH. I HAVE ALSO NOTICED THAT THE CRUISE CONTROL IS AFFECTED BY WHATEVER IS CAUSING THIS PROBLEM. WHEN THE BRAKE LIGHTS WORK NORMALLY, THE CRUISE CONTROL ALSO WORKS. WHEN THE BRAKE LIGHTS ARE OPPOSITE FROM NORMAL THE CRUISE CONTROL WILL NOT WORK. *TR
TL*THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT THE BRAKE LIGHTS REMAINED ILLUMINATED AND WOULD SHUT OFF WHEN THE BRAKE PEDAL WAS DEPRESSED. THE DEALER REPLACED THE BRAKE PEDAL SENSOR. THE FOLLOWING DAY, THE CONTACT COULD NOT GET SHIFT OUT OF PARK AND THE ABS BRAKING SYSTEM EXHIBITED A NOISE WHEN THE BRAKE…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT THE BRAKE LIGHTS REMAINED ILLUMINATED AND WOULD SHUT OFF WHEN THE BRAKE PEDAL WAS DEPRESSED. THE DEALER REPLACED THE BRAKE PEDAL SENSOR. THE FOLLOWING DAY, THE CONTACT COULD NOT GET SHIFT OUT OF PARK AND THE ABS BRAKING SYSTEM EXHIBITED A NOISE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE DEALER STATED THAT SINCE THE BRAKE PEDAL SENSOR DID NOT REPAIR THE FAILURE, THE ECM MAY NEED REPLACING. THE VEHICLE WAS NOT REPAIRED UNTIL THE DEALER SPOKE WITH THE MANUFACTURER. THE FAILURE MILEAGE WAS 25,000 AND THE CURRENT MILEAGE WAS 32,000. UPDATED 11/11/10 *BF
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED WHEN DRIVING AT NIGHT, THE BRAKE LIGHTS WOULD REMAIN ILLUMINATED AT ALL TIMES UNTIL THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT WAS ABLE TO LOCATE SEVERAL COMPLAINTS ONLINE PERTAINING TO THE FAILURE. NEITHER THE DEALER NOR MANUFACTURER WAS CONTACTED TO REPORT THE F…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED WHEN DRIVING AT NIGHT, THE BRAKE LIGHTS WOULD REMAIN ILLUMINATED AT ALL TIMES UNTIL THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT WAS ABLE TO LOCATE SEVERAL COMPLAINTS ONLINE PERTAINING TO THE FAILURE. NEITHER THE DEALER NOR MANUFACTURER WAS CONTACTED TO REPORT THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 50,700.
4/16/2010 - BRAKE LIGHTS FLICKER EVEN WHEN NOT DEPRESSED. TOOK TO DEALERSHIP FOR REPAIR ON 4/17/2010. DEALER STATED THAT BRAKE PEDAL WAS "OUT OF POSITION" AND REPOSITIONED PEDAL. 4/26/2010 - BRAKE LIGHTS ON SOLID WHEN THE CAR IS ON. TOOK TO A DEALERSHIP; REPLACED BRAKE SENSOR SWITCH. ONLY 28K MILES ON THE CAR. CONSEQUENCES - C…
Read full complaint
4/16/2010 - BRAKE LIGHTS FLICKER EVEN WHEN NOT DEPRESSED. TOOK TO DEALERSHIP FOR REPAIR ON 4/17/2010. DEALER STATED THAT BRAKE PEDAL WAS "OUT OF POSITION" AND REPOSITIONED PEDAL. 4/26/2010 - BRAKE LIGHTS ON SOLID WHEN THE CAR IS ON. TOOK TO A DEALERSHIP; REPLACED BRAKE SENSOR SWITCH. ONLY 28K MILES ON THE CAR. CONSEQUENCES - CARS BEHIND ARE UNABLE TO TELL WHETHER THE CAR IS TRULY BRAKING OR NOT, RESULTING IN INCREASED RISK OF ACCIDENT. *TR
TL*THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE AT A COMPLETE STOP, THE CONTACT WAS INFORMED BY ANOTHER MOTORIST THAT HER BRAKE LIGHTS WERE ILLUMINATING EVEN WHEN SHE WAS NOT BRAKING. IN ADDITION, THE BRAKE LIGHTS WOULD NOT ILLUMINATE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED T…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE AT A COMPLETE STOP, THE CONTACT WAS INFORMED BY ANOTHER MOTORIST THAT HER BRAKE LIGHTS WERE ILLUMINATING EVEN WHEN SHE WAS NOT BRAKING. IN ADDITION, THE BRAKE LIGHTS WOULD NOT ILLUMINATE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT A COMPUTER CHIP WAS FAILING, WHICH CAUSED THE MALFUNCTION. THE VEHICLE WAS REPAIRED AT THE COST OF $250. A YEAR LATER, THE FAILURE RECURRED. THE CONTACT IS IN THE PROCESS OF TAKING THE VEHICLE TO THE DEALER FOR INSPECTION AND NOTIFYING THE MANUFACTURER. THE FAILURE MILEAGE WAS 35,900 AND CURRENT MILEAGE WAS 72,000.
I JUST FOUND OUT LAST NIGHT THAT MY 2006 CHEVY MALIBU LTZ BRAKE LIGHTS ILLUMINATE WITHOUT PRESSING THE BRAKE PEDAL AND WHEN I DO PRESS THE PEDAL IT GOES OUT. THIS WOULD CAUSE ANYONE FOLLOWING MY VEHICLE NOT TO SEE THAT I AM BRAKING AND COULD CAUSE A CRASH. ALSO MY CRUISE CONTROL AND MY CIGARETTE LIGHTER WENT OUT. I AM NOT SURE I…
Read full complaint
I JUST FOUND OUT LAST NIGHT THAT MY 2006 CHEVY MALIBU LTZ BRAKE LIGHTS ILLUMINATE WITHOUT PRESSING THE BRAKE PEDAL AND WHEN I DO PRESS THE PEDAL IT GOES OUT. THIS WOULD CAUSE ANYONE FOLLOWING MY VEHICLE NOT TO SEE THAT I AM BRAKING AND COULD CAUSE A CRASH. ALSO MY CRUISE CONTROL AND MY CIGARETTE LIGHTER WENT OUT. I AM NOT SURE IF THEY ARE ALL CONNECTED SOMEHOW BUT THE BRAKES ARE DEFINITELY A CONCERN. I WILL SAY THAT MY CAR DOES HAVE A SALVAGED TITLE BUT I DON'T KNOW IF THAT WOULD CAUSE THE SAFETY ISSUE. I HAVE OWNED THE CAR FOR 4 MONTHS AND THEY HAVE WORKED UNTIL NOW. I HAVE AN APPOINTMENT TO GET IT FIXED AND AM NOT DRIVING IT TILL THAN. *TR
38K MILE 2006 CHEVY MALIBU V-6-CAR SHAKES/VIBRATES/SHIMMIES. IT ALSO RATTLES AND CLUNKS UNDERNEATH AT ALL SPEEDS, FEELS LIKE THE BOTTOM IS FALLING OUT. DEALER REFUSES TO ACKNOWLEDGE A MINIMUM OF 7 COMPLAINTS. HEADLIGHTS LENSES ARE LOOSE AND THE LIGHTS SHAKE ALL OVER THE PLACE. DEALER DID FINALLY ACKNOWLEDGE HEADLIGHT ISSUE AFTER…
Read full complaint
38K MILE 2006 CHEVY MALIBU V-6-CAR SHAKES/VIBRATES/SHIMMIES. IT ALSO RATTLES AND CLUNKS UNDERNEATH AT ALL SPEEDS, FEELS LIKE THE BOTTOM IS FALLING OUT. DEALER REFUSES TO ACKNOWLEDGE A MINIMUM OF 7 COMPLAINTS. HEADLIGHTS LENSES ARE LOOSE AND THE LIGHTS SHAKE ALL OVER THE PLACE. DEALER DID FINALLY ACKNOWLEDGE HEADLIGHT ISSUE AFTER THE 4TH COMPLAINT AND I WAS TOLD IT IS A GM PROBLEM BUT THEY HAVE NO FIX AND THERE IS NOTHING THEY CAN DO. NOW THAT THE WARRANTY IS UP, THEY ARE ACKNOWLEDGING ALL PREVIOUS COMPLAINTS (MANY MORE THAN JUST THE COUPLE I LISTED HERE) BUT AT MY EXPENSE WHEN THESE ISSUES S/H/B TAKEN CARE OF AT THE TIME OF THE ORIGINAL AND NUMEROUS COMPLAINTS. *TR
BRAKE LIGHTS TURN ON WITHOUT PRESSING PEDAL, YET LIGHTS TURN OFF WHEN PEDAL IS PRESSED. REQUIRES ALMOST FULL PEDAL PRESSURE TO ACTUATE BRAKE LIGHTS, SO LIGHTS ACTUALLY DO NOT OPERATE CORRECTLY UNTIL ALMOST FULLY BRAKING, SUCH AS DURING A QUICK STOP. HAVE HAD MANY INSTANCES IN TRAFFIC OF OTHER VEHICLES NEARLY COLLIDING WITH ME WH…
Read full complaint
BRAKE LIGHTS TURN ON WITHOUT PRESSING PEDAL, YET LIGHTS TURN OFF WHEN PEDAL IS PRESSED. REQUIRES ALMOST FULL PEDAL PRESSURE TO ACTUATE BRAKE LIGHTS, SO LIGHTS ACTUALLY DO NOT OPERATE CORRECTLY UNTIL ALMOST FULLY BRAKING, SUCH AS DURING A QUICK STOP. HAVE HAD MANY INSTANCES IN TRAFFIC OF OTHER VEHICLES NEARLY COLLIDING WITH ME WHILE SLOWING DOWN, OBVIOUSLY FROM THE LACK OF CORRECTLY FUNCTIONING BRAKE LIGHTS. *TR
Official recalls
615V064000 · Steering:electric Power Assist System
Feb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
05V486000 · Equipment:other:labels
Oct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
Consequence & remedy
Consequence: A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
Remedy: OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.