IllustrationBRAKES FAILED WHILE DRIVING, CAUSING ME TO CRASH INTO ANOTHER CAR.
2004 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2004 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2010–25K
10225–50K
15550–75K
14175–100K
232100–150K
116150K+
947 reports with mileage · 200 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 798 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 151 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
47 crash reports7 fire reports18 injury reports
What owners actually said
1,147 reportsTL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING AT 20 MPH, THE POWER STEERING BECAME DIFFICULT TO MANEUVER AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STATED THAT THE HIGH PRESSURE FUEL LINE FRACTURED AND LEAKED FUEL INTO THE MUFFLER. THE FAILURE RECURRED ONCE. THE VEHICLE WAS NOT DIAGNOSED OR …
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING AT 20 MPH, THE POWER STEERING BECAME DIFFICULT TO MANEUVER AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STATED THAT THE HIGH PRESSURE FUEL LINE FRACTURED AND LEAKED FUEL INTO THE MUFFLER. THE FAILURE RECURRED ONCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 159,672.
WHILE DRIVING I5 NORTH I ADJUSTED MY ELECTRONIC FRONT SEAT FOR MORE COMFORT, AND WHEN I DID I FOUND THE SEAT MOVING CLOSER TO THE DASH BOARD, I COULDN'T STOP IT OR REVERSE IT SO I FRANTICALLY WENT FROM THE FAST LANE TO THE SHOULDER OF THE ROAD ALMOST CRASHING INTO SOMEONE. WHEN I STOPPED I FOUND MYSELF ALMOST TRAPPED BETWEEN THE…
Read full complaint
WHILE DRIVING I5 NORTH I ADJUSTED MY ELECTRONIC FRONT SEAT FOR MORE COMFORT, AND WHEN I DID I FOUND THE SEAT MOVING CLOSER TO THE DASH BOARD, I COULDN'T STOP IT OR REVERSE IT SO I FRANTICALLY WENT FROM THE FAST LANE TO THE SHOULDER OF THE ROAD ALMOST CRASHING INTO SOMEONE. WHEN I STOPPED I FOUND MYSELF ALMOST TRAPPED BETWEEN THE STEERING WHEEL AND THE SEAT MY LEGS WERE ALMOST JAMMED INTO THE UNDERSIDE OF THE DASH BOARD AND THE ELECTRONIC SEAT NON RESPONSIVE. WHAT I FOUND OUT WAS THAT THE SWITCH HAD COME OFF THE CONTROL KNOBS AND WHEN THAT HAPPENS THE SEAT WENT ALL THE WAY FORWARD AND YOU HAVE NO CONTROL OVER IT. SOMEBODY SHOULD LOOK INTO THIS MATTER. THERE IS NO RECALLS FOR THIS BUT THERE SHOULD BE.
POWER DRIVERS SEAT FRAME BROKE AT A WELD. THIS OCCURRED WHILE I WAS TRAVELLING AT 65MPH ON THE HIGHWAY. I STARTLED ME AND I SWERVED ALMOST HITTING ANOTHER CAR. I HAVE SEEN MANY PEOPLE COMPLAIN OF THE SEAT FRAME BREAKING IN THE EXACT SAME SPOT AT A WELD. THIS IS OBVIOUSLY A MANUFACTURING DEFECT AND BECAUSE THIS CAN BE A SAFET…
Read full complaint
POWER DRIVERS SEAT FRAME BROKE AT A WELD. THIS OCCURRED WHILE I WAS TRAVELLING AT 65MPH ON THE HIGHWAY. I STARTLED ME AND I SWERVED ALMOST HITTING ANOTHER CAR. I HAVE SEEN MANY PEOPLE COMPLAIN OF THE SEAT FRAME BREAKING IN THE EXACT SAME SPOT AT A WELD. THIS IS OBVIOUSLY A MANUFACTURING DEFECT AND BECAUSE THIS CAN BE A SAFETY ISSUE A RECALL SHOULD BE ISSUED. ALSO - I BELIEVE THE SEATBELT IS CONNECTED TO THE SEAT. DEFINITELY A SAFETY ISSUE. I HAVE SEEN COMPLAINTS FROM MANY PEOPLE OF VARYING SIZES/WEIGHTS. EVEN A SMALLER, 125LB WOMAN HAD THE SAME THING HAPPEN.
REPORTING MULTIPLE ISSUES. INCREASED PROBLEMS AFTER RECALL WORK PERFORMED..ITEMS 2 AND 3. ITEM 1 FROM THE ORIGINAL PURCHASE AND NO GM SOLUTION ON WHAT HAS BEEN A WIDE SPREAD PART QUALITY PROBLEM DOCUMENTED. DRIVERS SIDE SEAT EARLY ON FROM PURCHASE DEALER WELDED BREAK ONCE. BROKE AGAIN DRIVING WITH BROKEN SEAT NOW LEG NERV…
Read full complaint
REPORTING MULTIPLE ISSUES. INCREASED PROBLEMS AFTER RECALL WORK PERFORMED..ITEMS 2 AND 3. ITEM 1 FROM THE ORIGINAL PURCHASE AND NO GM SOLUTION ON WHAT HAS BEEN A WIDE SPREAD PART QUALITY PROBLEM DOCUMENTED. DRIVERS SIDE SEAT EARLY ON FROM PURCHASE DEALER WELDED BREAK ONCE. BROKE AGAIN DRIVING WITH BROKEN SEAT NOW LEG NERVE BACK PROBLEMS. CONCERN ON SAFETY IF IN ACCIDENT A..NO RECALL WHY NO OPTION TO GET REPLACEMENT PARTS OR SEAT WHY????? WHILE DRIVING VEHICLE POWER STEERING WENT OUT REDUCED ACCELERATION DASHBOARD VARYING LIGHTS RANDOM VARIES OFF AND ON ABLE TO COAST OUT OF TRAFFIC. NO ABILITY TO RESTART. TOWED DEALER INDICATED NEED TO REPLACE GENERATOR AND BATTERY BOTH PERFORMED VEHICLE DRAINS UNABLE TO START JUMP START RUNS FAILS AGAIN LATER - NO SOLUTION PROBLEM STARTED AFTER DEALERSHIP RECALL WORK DONE ON IGNITION SWITCH RELATED TO RECALL WORK???? SITTING IN DRIVEWAY - DO WE TOW BACK TO DEALERSHIP THAT HAD US REPLACE THE GENERATOR AS AN UNNECESSARY EXPENSE??? SELECTOR MALFUNCTION NOT WORKING SERVICED NOW NO ABILITY TO USE LOW GEAR SELECTION PUSH BUTTON. STAYS ON 3 WHY AGAIN RELATED TO RECALL WORK PERFORMED??? SOME SENSATIONS OF SLIPPAGE BETWEEN GEARS AS WELL. WHY?? LIKE THE VEHICLE AND WANT IT TO BE SAFE TO DRIVE AND KEEP IN SERVICE. LOYAL GM FAMILY MEMBER THAT IS CONSIDERING CHANGING MANUFACTURERS. SATURN OWNER - NO LONGER AVAILABLE PONTIAC OWNER GRAND AM NO LONER AVAILABLE PONTIAC VIBE OWNER CHEVROLET BLAZER OWNER CHEVROLET CAMERO. CHEVROLET IMPALA OUR FAMILY LIST GOES ON. MORE DIFFICULT TO KEEP THE FAMILY LOYAL DROP DOWN BOX ON VEHICLE NEVER DISPLAYED.
I WAS STOPPED AT A RED LIGHT, WHEN THE CAR SHUTS OFF. I TURNED THE CAR BACK ON, BUT IF I WENT SLOWER THEN 10 MPH THE CAR WOULD SHUT OFF. I PULLED INTO A LOCAL GROCERY STORE PARKING LOT, AND THE CAR WAS RUNNING HOT. I CHECKED THE OIL AND FOUND THAT THE OIL WAS COMPLETELY EMPTY. I HAD CHANGED THE OIL JUST A WEEK BEFORE AND HAD NO …
Read full complaint
I WAS STOPPED AT A RED LIGHT, WHEN THE CAR SHUTS OFF. I TURNED THE CAR BACK ON, BUT IF I WENT SLOWER THEN 10 MPH THE CAR WOULD SHUT OFF. I PULLED INTO A LOCAL GROCERY STORE PARKING LOT, AND THE CAR WAS RUNNING HOT. I CHECKED THE OIL AND FOUND THAT THE OIL WAS COMPLETELY EMPTY. I HAD CHANGED THE OIL JUST A WEEK BEFORE AND HAD NO ISSUES WITH THE OIL. THE CAR WOULD NOT START. I HAD TO GET THE CAR TOWED HOME.I CHECKED THE OIL PLUG AND FILTER AND NOTHING SEEMED TO BE OUT OF THE ORDINARY. EVERYTHING WAS TIGHT AND IN PLACE. THE NEXT DAY THE CAR WOULD START, BUT HAD A HORRIBLE KNOCKING NOISE COMING FROM THE MOTOR. HAVING TWO LITTLE BABIES, I HAVE NOT DRIVEN IT SINCE. I DO NOT WANT TO TAKE A CHANCE ON THIS PROBLEM HAPPENING AGAIN, NOR TO ANYONE ELSE.
DRIVING GRAND CHILDREN HOME FROM SCHOOL, TURNED IN DRIVEWAY AND CAR MADE LOUD CHATTER AND CLUNK SOUND LIKE SOMETHING WAS COMING APART OR FALLING OUT. WHEN THE NOISE HAPPENED STEERING WHEEL KEPT SPINNING FREELY! RECEIVED A LETTER SAYING THIS EXACT THING MAY HAPPEN WOULD BE FIXED FREE OF CHARGE UNDER 150,000 MILES. CAR IS AT 170,0…
Read full complaint
DRIVING GRAND CHILDREN HOME FROM SCHOOL, TURNED IN DRIVEWAY AND CAR MADE LOUD CHATTER AND CLUNK SOUND LIKE SOMETHING WAS COMING APART OR FALLING OUT. WHEN THE NOISE HAPPENED STEERING WHEEL KEPT SPINNING FREELY! RECEIVED A LETTER SAYING THIS EXACT THING MAY HAPPEN WOULD BE FIXED FREE OF CHARGE UNDER 150,000 MILES. CAR IS AT 170,000 THEY WILL NOT REPAIR SAYING EXTENDED WARRANTY ISSUE AND NOT RECALL. MIND BOGGLING HOW THEY CAN BE ALLOWED TO ISSUE RECALL FOR STEERING MOTOR THAT MAY CAUSE VECHILE TO STEER HARDER A SAFETY ISSUE AND WHEN YOUR IN THE PROCESS OF TURNING AND STEERING WHEEL SPINS FREELY ISN'T A SAFETY ISSUE BUT EXTENDED WARRANTY ISSUE. HAD WE BEEN TURNING AS WE WERE A SHORT TIME BEFORE THAT AT A BUSY INTERSECTION WE COULD HAVE BEEN INJURED OR KILLED!! THIS SEEMS COMPLETELY IDIOTIC HOW HARD STEERING THAT COULD HAPPEN SUCH AS LIKE WHEN A CAR DIDN'T HAVE POWER STEERING WAS DECLARED SAFETY ISSUE BUT EXTENDED WARRANTY ISSUE WHEN YOU LOSE THE ABILITY TO STEER AND STEERING WHEEL JUST SPINS. HOW MANY INJURIES OR DEATHS HAVE TO OCCUR BEFORE THEY ARE MADE TO FIX THIS ISSUE. THEY WANT $900 FOR PART ALONE. HOW COULD THEY POSSIBLY PUT A MILE LIMIT OF 150,000 ON SOMETHING THAT CAN CAUSE CRASH CAUSING INJURY OR DEATH!!! THIS DANGEROUS CONDITION NEEDS TO BE MADE PUBLIC AND CORRECTED. BECAUSE MANUFACTURER NEGLECTED TO PUT AN UMBRELLA SEAL A VERY CHEAP PART PEOPLES LIVES ARE AT RISK AND IT IS A COSTLY REPAIR DUE TO NEGLECT ON MANUFACTURERS PART!!
I WAS LEAVING OUT OF WALMART TO ENTER ONTO HWY 301 WHEN I ACCELERATED MY STEERING WHEEL HAD TIGHTENED UP LIKE THE CAR WAS GOING TO SHUT DOWN. IT HAPPENED AGAIN ON APRIL 24, 2015 SAME THING. THEY HAD A RECALL ON THE POWER STEERING (RECALL #14116). I HAD IT SERVICED ON 10/27/2014. WHICH I THOUGHT WAS CORRECTED UNTIL THIS HAPPENED.…
Read full complaint
I WAS LEAVING OUT OF WALMART TO ENTER ONTO HWY 301 WHEN I ACCELERATED MY STEERING WHEEL HAD TIGHTENED UP LIKE THE CAR WAS GOING TO SHUT DOWN. IT HAPPENED AGAIN ON APRIL 24, 2015 SAME THING. THEY HAD A RECALL ON THE POWER STEERING (RECALL #14116). I HAD IT SERVICED ON 10/27/2014. WHICH I THOUGHT WAS CORRECTED UNTIL THIS HAPPENED. I TOOK MY CAR BACK TO THE DEALERSHIP ON MAY 6, 2015,WHICH WAS STILL THE POWER STEERING, AND I END UP PAYING 525.76, FOR SOMETHING GMC WAS SUPPOSED TO HAVE FIXED IN THE RECALL. I SURE I'M NOT THE ONLY WHO IS HAVING THIS PROBLEM. BECAUSE I COULD'VE BEEN HIT NOT ONCE BUT TWICE. *TR
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE KEY WAS PERMANENTLY STUCK IN THE IGNITION SWITCH AND WOULD NOT EJECT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING AT APPROXIMATELY 10 MPH AND TURNING THE STEERING WHEEL, THE TIRES FAILED TO TURN. THE FAILURE RECURRED ONCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE RACK AND PINION FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRE…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING AT APPROXIMATELY 10 MPH AND TURNING THE STEERING WHEEL, THE TIRES FAILED TO TURN. THE FAILURE RECURRED ONCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE RACK AND PINION FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 168,000.
Official recalls
614V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
04V190000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Apr 19, 2004
SOME OF THESE PASSENGER VEHICLES HAVE AN ELECTRONIC CONTROL UNIT (ECU) THAT MAY CALCULATE A HIGHER THAN ACTUAL VEHICLE SPEED BECAUSE OF AN ERRATIC REAR-WHEEL SPEED SENSOR SIGNAL, AND CAUSE ABS ACTIVATION WHERE IT IS NOT NEEDED OR NEEDED ABS ACTIVATION TO BE EXTENDED DURING BRAKING AS THE VEHICLE SPEED DROPS TO ABOUT 3 MPH.
Consequence & remedy
Consequence: UNEXPECTED ABS ACTIVIATION COULD INCREASE STOPPING DISTANCE UP TO ABOUT 11 FEET DPENDING ON THE GRADE OF THE ROAD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ABS CONTROLLER. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
04V188000 · Seat Belts:front:anchorage
Apr 16, 2004
ON CERTAIN PASSENGER VEHICLES, ANALYSIS OF AN A SIDE IMPACT CRASH TEST CONDUCTED BY THE NHTSA;S NEW CAR ASSESSMENT PROGRAM (NCAP) INDICATED THAT THE OUTBOARD ANCHORAGE OF THE DRIVER'S SEAT BELT COULD DISCONNECT BECAUSE OF CONTACT BETWEEN THE SEAT TRIM AND THE ANCHORAGE CONNECTOR WHEN THE SEAT WAS ADJUSTED TO ITS LOWEST POSITION.
Consequence & remedy
Consequence: IF THIS OCCURRED IN A CRASH, THE DRIVER COULD RECEIVE GREATER INJURIES.
Remedy: DEALERS WILL INSERT A RETAINER ON BOTH THE DRIVER'S AND PASSENGER'S BELT ANCHORAGES. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
04V094000 · Equipment:other:labels
Feb 24, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES THAT WERE NOT EQUIPPED WITH AN ADVANCED OCCUPANT RESTRAINT SYSTEM (AORS) HAVE DRIVER AND PASSENGER SIDE SUN VISORS WITH AORS LABELS. THE AORS LABELS DO NOT INCLUDE STATEMENTS AND THE ILLUSTRATION REQUIRED BY FMVSS NO. 208 FOR VEHICLES WITHOUT AORS.
Consequence & remedy
Consequence: Not supplied
Remedy: OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA09004 · Turn Signal Lamps
Opened Mar 20, 2009 · Closed Aug 12, 2010
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:headlights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a DRL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.
Additional source detail variants (4)
Exterior Lighting:brake Lights
GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a DRL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.
Exterior Lighting:headlights
GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a DRL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.
Exterior Lighting:tail Lights
GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a DRL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.
Exterior Lighting:turn Signal
GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a DRL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.
PE08062 · Turn Signal Lamps
Opened Oct 21, 2008 · Closed Mar 20, 2009
Status: closed (inferred from source dates) · Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
THE SUBJECT VEHICLES MAY EXPERIENCE LOSS OF FUNCTION OF ONE OR MORE OF THE PARK, TURN, STOP OR DAYTIME RUNNING LAMPS (DRL).FAILURE OF THE BULB MAY ALSO INCLUDE DISCOLORATION (HEAT DAMAGE) TO THE BULB SOCKET.GENERAL MOTORS (GM) TECHNICAL SERVICE BULLETIN (TSB) NUMBER 06-08-42-004C INSTRUCTS TECHNICIANS TO EXAMINE THE LAMP HOUSING FOR SIGNS OF DISCOLORATION AND TO REPLACE THE BULBS AND OR SOCKETS DEPENDING ON THE SEVERITY OF THE DISCOLORATION AND THE CONDITION OF THE BULBS AND SOCKETS.THE SCOPE OF INVESTIGATION IN THE PRELIMINARY EVALUATION (PE08-062) WAS THE 2004 MALIBU/MAXX.HOWEVER, THE AGENCY EVALUATED GM'S WARRANTY DATA WHICH INDICATES THAT THE 2005 MODEL YEAR (MY) MALIBU AND MALIBU MAXX VEHICLES ARE ALSO AFFECTED BY THIS CONDITION.THIS INVESTIGATION IS UPGRADED TO AN ENGINEERING ANALYSIS (EA09-004).
Additional source detail variants (2)
Exterior Lighting:tail Lights
THE SUBJECT VEHICLES MAY EXPERIENCE LOSS OF FUNCTION OF ONE OR MORE OF THE PARK, TURN, STOP OR DAYTIME RUNNING LAMPS (DRL).FAILURE OF THE BULB MAY ALSO INCLUDE DISCOLORATION (HEAT DAMAGE) TO THE BULB SOCKET.GENERAL MOTORS (GM) TECHNICAL SERVICE BULLETIN (TSB) NUMBER 06-08-42-004C INSTRUCTS TECHNICIANS TO EXAMINE THE LAMP HOUSING FOR SIGNS OF DISCOLORATION AND TO REPLACE THE BULBS AND OR SOCKETS DEPENDING ON THE SEVERITY OF THE DISCOLORATION AND THE CONDITION OF THE BULBS AND SOCKETS.THE SCOPE OF INVESTIGATION IN THE PRELIMINARY EVALUATION (PE08-062) WAS THE 2004 MALIBU/MAXX.HOWEVER, THE AGENCY EVALUATED GM'S WARRANTY DATA WHICH INDICATES THAT THE 2005 MODEL YEAR (MY) MALIBU AND MALIBU MAXX VEHICLES ARE ALSO AFFECTED BY THIS CONDITION.THIS INVESTIGATION IS UPGRADED TO AN ENGINEERING ANALYSIS (EA09-004).
Exterior Lighting:turn Signal
THE SUBJECT VEHICLES MAY EXPERIENCE LOSS OF FUNCTION OF ONE OR MORE OF THE PARK, TURN, STOP OR DAYTIME RUNNING LAMPS (DRL).FAILURE OF THE BULB MAY ALSO INCLUDE DISCOLORATION (HEAT DAMAGE) TO THE BULB SOCKET.GENERAL MOTORS (GM) TECHNICAL SERVICE BULLETIN (TSB) NUMBER 06-08-42-004C INSTRUCTS TECHNICIANS TO EXAMINE THE LAMP HOUSING FOR SIGNS OF DISCOLORATION AND TO REPLACE THE BULBS AND OR SOCKETS DEPENDING ON THE SEVERITY OF THE DISCOLORATION AND THE CONDITION OF THE BULBS AND SOCKETS.THE SCOPE OF INVESTIGATION IN THE PRELIMINARY EVALUATION (PE08-062) WAS THE 2004 MALIBU/MAXX.HOWEVER, THE AGENCY EVALUATED GM'S WARRANTY DATA WHICH INDICATES THAT THE 2005 MODEL YEAR (MY) MALIBU AND MALIBU MAXX VEHICLES ARE ALSO AFFECTED BY THIS CONDITION.THIS INVESTIGATION IS UPGRADED TO AN ENGINEERING ANALYSIS (EA09-004).
EA04018 · Loss Of Electric Power Steering
Opened Jul 1, 2004 · Closed May 10, 2005
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: - GM ISSUED CUSTOMER SATISFACTION CAMPAIGN (CSC) 04050A INDECEMBER 2004 TO ADDRESS THE ALLEGED DEFECT IN APPROXIMATELY58,700 SUBJECT VEHICLES, ENCOMPASSING AT LEAST 97 PERCENT OF THECOMPLAINT AND WARRANTY CLAIMS POPULATION.VEHICLES OUTSIDE THECSC 04050A POPULATION CONTAIN A NEWLY DESIGNED TORQUE ANDPOSITION SENSOR AND HAVE EXPERIENCED A RELATIVELY LOW COMPLAINTRATE.THIS CUSTOMER SATISFACTION CAMPAIGN PRESENTLY HAS ACOMPLETION RATE OF 52%. - THE IMPACT ON THE DRIVER?S ABILITY TO CONTROL THESE RELATIVELYSMALL AND LIGHT VEHICLES WAS LIMITED.VRTC TEST ENGINEERS WEREUNABLE TO INDUCE A FAILURE MODE THAT WOULD CAUSE THE EPS TOSUBSTANTIALLY LIMIT THE DRIVER?S ABILITY TO TURN THE VEHICLE IN APARTICULAR DIRECTION OR TO PROVIDE THE DRIVER WITH UNINTENDEDPOWER ASSISTANCE.- THERE IS NO RISK OF FIRE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED BY THE CIRCUMSTANCES.(FOR FURTHER DETAILS SEE ATTACHED ENGINEERING ANALYSIS (EA04-018)CLOSING REPORT.)
Additional source detail variants (2)
Steering:electric Power Assist System
IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: - GM ISSUED CUSTOMER SATISFACTION CAMPAIGN (CSC) 04050A INDECEMBER 2004 TO ADDRESS THE ALLEGED DEFECT IN APPROXIMATELY58,700 SUBJECT VEHICLES, ENCOMPASSING AT LEAST 97 PERCENT OF THECOMPLAINT AND WARRANTY CLAIMS POPULATION.VEHICLES OUTSIDE THECSC 04050A POPULATION CONTAIN A NEWLY DESIGNED TORQUE ANDPOSITION SENSOR AND HAVE EXPERIENCED A RELATIVELY LOW COMPLAINTRATE.THIS CUSTOMER SATISFACTION CAMPAIGN PRESENTLY HAS ACOMPLETION RATE OF 52%. - THE IMPACT ON THE DRIVER?S ABILITY TO CONTROL THESE RELATIVELYSMALL AND LIGHT VEHICLES WAS LIMITED.VRTC TEST ENGINEERS WEREUNABLE TO INDUCE A FAILURE MODE THAT WOULD CAUSE THE EPS TOSUBSTANTIALLY LIMIT THE DRIVER?S ABILITY TO TURN THE VEHICLE IN APARTICULAR DIRECTION OR TO PROVIDE THE DRIVER WITH UNINTENDEDPOWER ASSISTANCE.- THERE IS NO RISK OF FIRE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED BY THE CIRCUMSTANCES.(FOR FURTHER DETAILS SEE ATTACHED ENGINEERING ANALYSIS (EA04-018)CLOSING REPORT.)
Steering
IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: - GM ISSUED CUSTOMER SATISFACTION CAMPAIGN (CSC) 04050A INDECEMBER 2004 TO ADDRESS THE ALLEGED DEFECT IN APPROXIMATELY58,700 SUBJECT VEHICLES, ENCOMPASSING AT LEAST 97 PERCENT OF THECOMPLAINT AND WARRANTY CLAIMS POPULATION.VEHICLES OUTSIDE THECSC 04050A POPULATION CONTAIN A NEWLY DESIGNED TORQUE ANDPOSITION SENSOR AND HAVE EXPERIENCED A RELATIVELY LOW COMPLAINTRATE.THIS CUSTOMER SATISFACTION CAMPAIGN PRESENTLY HAS ACOMPLETION RATE OF 52%. - THE IMPACT ON THE DRIVER?S ABILITY TO CONTROL THESE RELATIVELYSMALL AND LIGHT VEHICLES WAS LIMITED.VRTC TEST ENGINEERS WEREUNABLE TO INDUCE A FAILURE MODE THAT WOULD CAUSE THE EPS TOSUBSTANTIALLY LIMIT THE DRIVER?S ABILITY TO TURN THE VEHICLE IN APARTICULAR DIRECTION OR TO PROVIDE THE DRIVER WITH UNINTENDEDPOWER ASSISTANCE.- THERE IS NO RISK OF FIRE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED BY THE CIRCUMSTANCES.(FOR FURTHER DETAILS SEE ATTACHED ENGINEERING ANALYSIS (EA04-018)CLOSING REPORT.)
PE04031 · Loss Of Electric Power Steering
Opened Mar 30, 2004 · Closed Jul 1, 2004
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI OPENED PE04-031 BASED ON EIGHT REPORTS OF ALLEGED POWER STEERING FAILURE IN THE SUBJECT VEHICLES.THE COMPLAINTS ALLEGE THAT THE DRIVER SUDDENLY LOST ALL ELECTRIC POWER STEERING ASSISTANCE WITHOUT WARNING MAKING THE VEHICLE DIFFICULT TO STEER. THE SUBJECT VEHICLE UTILIZES AN ELECTRIC POWER STEERING ASSIST SYSTEM (EPS) THAT PROVIDES VARIABLE STEERING ASSISTANCE BASED ON STEERING WHEEL TORQUE, STEERING WHEEL POSTION, AND VEHICLE SPEED.GENERAL MOTORS DOCUMENTS IDENTIFIED THE FOLLOWING TWO FACTORS THAT CONTRIBUTED TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES: A.CONTAMINATION OF THE TORQUE AND POSITION SENSOR FROM THESEPARATION OF GREASE APPLIED TO THE STEERING COLUMN ASSEMBLY. B.ELECTRICAL NOISE GENERATED ON THE POWER AND GROUND SLIP RING SURFACES OF THE TORQUE AND POSITION SENSOR.THE NOISE IS GENERATED AS THE SENSOR CONTACT BRUSHES MOVE ALONG THE SLIP RING SURFACES WHEN THE STEERING WHEEL IS ROTATED.ODI'S ANALYSIS SHOWED FAILURERATES THAT ARE OF CONCERN TO ODI AND INDICATED THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES. THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI OPENED PE04-031 BASED ON EIGHT REPORTS OF ALLEGED POWER STEERING FAILURE IN THE SUBJECT VEHICLES.THE COMPLAINTS ALLEGE THAT THE DRIVER SUDDENLY LOST ALL ELECTRIC POWER STEERING ASSISTANCE WITHOUT WARNING MAKING THE VEHICLE DIFFICULT TO STEER. THE SUBJECT VEHICLE UTILIZES AN ELECTRIC POWER STEERING ASSIST SYSTEM (EPS) THAT PROVIDES VARIABLE STEERING ASSISTANCE BASED ON STEERING WHEEL TORQUE, STEERING WHEEL POSTION, AND VEHICLE SPEED.GENERAL MOTORS DOCUMENTS IDENTIFIED THE FOLLOWING TWO FACTORS THAT CONTRIBUTED TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES: A.CONTAMINATION OF THE TORQUE AND POSITION SENSOR FROM THESEPARATION OF GREASE APPLIED TO THE STEERING COLUMN ASSEMBLY. B.ELECTRICAL NOISE GENERATED ON THE POWER AND GROUND SLIP RING SURFACES OF THE TORQUE AND POSITION SENSOR.THE NOISE IS GENERATED AS THE SENSOR CONTACT BRUSHES MOVE ALONG THE SLIP RING SURFACES WHEN THE STEERING WHEEL IS ROTATED.ODI'S ANALYSIS SHOWED FAILURERATES THAT ARE OF CONCERN TO ODI AND INDICATED THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES. THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Steering
ODI OPENED PE04-031 BASED ON EIGHT REPORTS OF ALLEGED POWER STEERING FAILURE IN THE SUBJECT VEHICLES.THE COMPLAINTS ALLEGE THAT THE DRIVER SUDDENLY LOST ALL ELECTRIC POWER STEERING ASSISTANCE WITHOUT WARNING MAKING THE VEHICLE DIFFICULT TO STEER. THE SUBJECT VEHICLE UTILIZES AN ELECTRIC POWER STEERING ASSIST SYSTEM (EPS) THAT PROVIDES VARIABLE STEERING ASSISTANCE BASED ON STEERING WHEEL TORQUE, STEERING WHEEL POSTION, AND VEHICLE SPEED.GENERAL MOTORS DOCUMENTS IDENTIFIED THE FOLLOWING TWO FACTORS THAT CONTRIBUTED TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES: A.CONTAMINATION OF THE TORQUE AND POSITION SENSOR FROM THESEPARATION OF GREASE APPLIED TO THE STEERING COLUMN ASSEMBLY. B.ELECTRICAL NOISE GENERATED ON THE POWER AND GROUND SLIP RING SURFACES OF THE TORQUE AND POSITION SENSOR.THE NOISE IS GENERATED AS THE SENSOR CONTACT BRUSHES MOVE ALONG THE SLIP RING SURFACES WHEN THE STEERING WHEEL IS ROTATED.ODI'S ANALYSIS SHOWED FAILURERATES THAT ARE OF CONCERN TO ODI AND INDICATED THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES. THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.