Illustration2004 CHEVROLET MALIBU. CUSTOMER STATES THAT HE HAS RECEIVED THREE RECALL NOTICES FOR VEHICLE IN JUNE 2014 AND JULY 2014. ALL THREE NOTICED INDICATED THE PARTS ARE NOT AVAILABLE AND HASN'T HEARD ANY RESPONSE SINCE. *TA
2004 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2004 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2010–25K
10225–50K
15550–75K
14175–100K
232100–150K
116150K+
947 reports with mileage · 200 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 798 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 151 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
47 crash reports7 fire reports18 injury reports
Service Brakes, Hydraulic complaints
28 reports2004 CHEVROLET MALIBU EXPERIENCING POWER STEERING PROBLEMS, ABS AND SHIFT CABLE, ALL REPLACED. *CW THE CONSUMER STATED THE VEHICLE WAS TAKEN TO THE REPAIR SHOP SEVEN TIMES, DUE TO POWER STEERING FAILURE, WHICH RESULTED IN THE STEERING LOCKING UP. THE CONSUMER WAS INVOLVED IN TWO ACCIDENTS, IN WHICH THE AIR BAGS FAILED TO DEPLO…
Read full complaint
2004 CHEVROLET MALIBU EXPERIENCING POWER STEERING PROBLEMS, ABS AND SHIFT CABLE, ALL REPLACED. *CW THE CONSUMER STATED THE VEHICLE WAS TAKEN TO THE REPAIR SHOP SEVEN TIMES, DUE TO POWER STEERING FAILURE, WHICH RESULTED IN THE STEERING LOCKING UP. THE CONSUMER WAS INVOLVED IN TWO ACCIDENTS, IN WHICH THE AIR BAGS FAILED TO DEPLOY. THE CONSUMER RECEIVED A TRANSMISSION, STEERING AND BRAKE RECALL. HOWEVER, THE PARTS WERE NOT AVAILABLE. *JB
2004 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO GM RECALL #13036* LD THE CONSUMER STATED THE RECALL FIX, DID NOT FIX THE PROBLEM. THE CONSUMER STATED HE DID NOT KNOW, IF THE BRAKE LIGHTS WORKED AND THE CRUISE CONTROL RARELY WORKED. THE TRACTION CONTROL AND ABS LIGHT WAS ON. THE CONSUMER RETURNED TO THE DEALER. AN INSPECTIO…
Read full complaint
2004 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO GM RECALL #13036* LD THE CONSUMER STATED THE RECALL FIX, DID NOT FIX THE PROBLEM. THE CONSUMER STATED HE DID NOT KNOW, IF THE BRAKE LIGHTS WORKED AND THE CRUISE CONTROL RARELY WORKED. THE TRACTION CONTROL AND ABS LIGHT WAS ON. THE CONSUMER RETURNED TO THE DEALER. AN INSPECTION REVEALED A PROBLEM WAS SPEED SENSOR ON THE RIGHT FRONT WHEEL, WHICH WAS NOT RELATED TO THE RECALL. THE COST TO REPLACE THE SENSOR WAS $460. *JB
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE STEERING COLUMN WOULD BECOME LOOSE WHILE DRIVING AT ANY SPEED AND THE WHEEL WOULD SPORADICALLY SHAKE WHEN DRIVING OVER 50 MPH. IN ADDITION THE POWER STEERING WARNING LIGHT WAS ILLUMINATED WHEN THE FAILURE WOULD OCCUR. THE CONTACT STATED THE FAILURE WAS TH…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE STEERING COLUMN WOULD BECOME LOOSE WHILE DRIVING AT ANY SPEED AND THE WHEEL WOULD SPORADICALLY SHAKE WHEN DRIVING OVER 50 MPH. IN ADDITION THE POWER STEERING WARNING LIGHT WAS ILLUMINATED WHEN THE FAILURE WOULD OCCUR. THE CONTACT STATED THE FAILURE WAS THE SECOND OCCURRENCE AND THE STEERING COLUMN WAS REPLACED IN 2007. THE VEHICLE WAS NOT INSPECTED OR REPAIRED FOR THE RECENT FAILURE. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 115,000. THE CONSUMER STATED THE VEHICLE MADE A CLUNKING, KNOCKING AND RATTLING SOUND WHEN DRIVEN AT A LOW GRADE SPEED AND WHEN THE STEERING WHEEL WAS TURNED. THE VEHICLE ALSO SHOOK VIOLENTLY. THE DRIVER SEAT DIDN'T TO STAY ON TRACK AND WAS DIFFICULT TO ADJUST FORWARD AND BACKWARD. THE HORN AND CRUISE CONTROL WERE INOPERATIVE. THE BRAKE AND ACCELERATOR PEDALS NO LONGER ADJUSTED. THE SAFETY LOCKS DID NOT LATCH AT TIMES WHEN THE BUTTON WAS PUSHED AND THE GAS CAP CONTINUED TO OPEN AFTER IT WAS LOCKED CAUSING THE ENGINE LIGHT TO ILLUMINATE. UPDATED 02/01/12
TL*THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 60 MPH THE VEHICLE SUDDENLY STALLED WHEN THE ANTI-THEFT LIGHTS FLASHED ON THE DASHBOARD. THE CONTACT HAD TO DRIVE ONTO THE EMERGENCY LANE AND WAIT FOR THE ANTI-THEFT LIGHT TO STOP FLASHING IN ORDER TO RESTART THE VEHICLE. THE CONTACT HAD NOT …
Read full complaint
TL*THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 60 MPH THE VEHICLE SUDDENLY STALLED WHEN THE ANTI-THEFT LIGHTS FLASHED ON THE DASHBOARD. THE CONTACT HAD TO DRIVE ONTO THE EMERGENCY LANE AND WAIT FOR THE ANTI-THEFT LIGHT TO STOP FLASHING IN ORDER TO RESTART THE VEHICLE. THE CONTACT HAD NOT TAKEN THE VEHICLE TO A DEALER NOR NOTIFIED THE MANUFACTURER. THE CONTACT WAS CONCERNED THAT THE SAFETY ISSUE COULD CAUSE CRASH TO OCCUR. THE FAILURE MILEAGE WAS 105,000.
ALL BRAKES SEEM TO ENGAGE WHILE DRIVING AND WILL NOT RELEASE UNTIL CAR SEATS FOR SEVERAL HOURS. BRAKES BECAME VERY HOT AND CAUSED STEERING PROBLEMS. *TR
TL*THE CONTACT OWNS A 2004 CHEVROLET MALIBU. IN JULY OF 2006, THE STEERING COLUMN WAS REPLACED AT ONLY 15,000 MILES. RECENTLY, THE CONTACT FELT THE STEERING LOOSEN WHILE DRIVING 20 MPH. ON JULY 21, 2009, THE STEERING KNUCKLE FAILED AND SHE LOST CONTROL OF THE STEERING. SHE HAD TO PLACE THE GEAR INTO PARK IN ORDER TO STOP THE…
Read full complaint
TL*THE CONTACT OWNS A 2004 CHEVROLET MALIBU. IN JULY OF 2006, THE STEERING COLUMN WAS REPLACED AT ONLY 15,000 MILES. RECENTLY, THE CONTACT FELT THE STEERING LOOSEN WHILE DRIVING 20 MPH. ON JULY 21, 2009, THE STEERING KNUCKLE FAILED AND SHE LOST CONTROL OF THE STEERING. SHE HAD TO PLACE THE GEAR INTO PARK IN ORDER TO STOP THE VEHICLE. A REPORT WAS FILED WITH THE MANUFACTURER. THE CURRENT AND FAILURE MILEAGES WERE 56,000.
AT 37500 MILES INSPECTION OF ALL (4) FOUR ROTORS AND RESPECTIVE BRAKE PADS FOLLOWED HEARING SCREECHING SCRAPING NOISES AND SLIGHT INCREASE IN BREAKING DISTANCE. EXCESSIVE WEAR WAS OBSERVED ON ROTOR DISCS. DRIVEN MILEAGE WAS CITY (35) THIRTY-FIVE PERCENT AND INTERSTATE (65) SIXTY-FIVE PERCENT. NON-DEALERSHIP TIRE/BRAKE SPECI…
Read full complaint
AT 37500 MILES INSPECTION OF ALL (4) FOUR ROTORS AND RESPECTIVE BRAKE PADS FOLLOWED HEARING SCREECHING SCRAPING NOISES AND SLIGHT INCREASE IN BREAKING DISTANCE. EXCESSIVE WEAR WAS OBSERVED ON ROTOR DISCS. DRIVEN MILEAGE WAS CITY (35) THIRTY-FIVE PERCENT AND INTERSTATE (65) SIXTY-FIVE PERCENT. NON-DEALERSHIP TIRE/BRAKE SPECIALTY SHOP WITH KNOWN COMPETENT BUSINESS REPUTATION OF (25) TWENTY-FIVE YEARS STATED THE GM PRODUCT OF RECENT (2002-2004) MAKE HAVE EXHIBITED EARLY FAILURE RATES DUE TO 'SOFT ALLOY" USED IN THE OEM BRAKE DISCS. *TR
MY 2004 CHEVROLET MALIBU WAS PARKED LEGALLY IN FRONT OF MY HOUSE. THE STREET WAS COVERED WITH BLACK ICE. THE DRIVER OF A 1999 FORD RANGER TRUCK SLIPPED ON THE ICE AND HIT THE FRONT OF MY CAR. HIS AUTO INSURANCE, STATE FARM, PAID FOR A RENTAL CAR FOR 40 DAYS AND PAID $5,338.10 IN BODY REPAIRS, INCLUDING REPLACING THE RADIATOR.…
Read full complaint
MY 2004 CHEVROLET MALIBU WAS PARKED LEGALLY IN FRONT OF MY HOUSE. THE STREET WAS COVERED WITH BLACK ICE. THE DRIVER OF A 1999 FORD RANGER TRUCK SLIPPED ON THE ICE AND HIT THE FRONT OF MY CAR. HIS AUTO INSURANCE, STATE FARM, PAID FOR A RENTAL CAR FOR 40 DAYS AND PAID $5,338.10 IN BODY REPAIRS, INCLUDING REPLACING THE RADIATOR. HOWEVER, WHEN IT CAME TIME TO PAY $527.18 TO REPLACE THE STEERING SHAFT AND THE GEAR SHIFTER, THEY REFUSED. THE REASON GIVEN WAS THAT THESE PARTS IN THE 2004 CHEVROLET MALIBU HAVE A HISTORY OF WEARING OUT PREMATURELY. THE CAR RAN FINE BEFORE THE ACCIDENT. HOWEVER, AFTER READING THE COMPLAINTS ON YOUR WEB SITE, I WOULD ALSO LIKE TO ADD MY COMPLAINT. I BOUGHT THIS CAR AS A GM CERTIFIED USED VEHICLE ON AUGUST 2, 2007, 17 MONTHS BEFORE THE ACCIDENT. THE CAR HAD 31,720 MILES ON IT WHEN I BOUGHT IT AND 34,517 MILES AT THE TIME OF THE ACCIDENT, A DIFFERENCE OF 2,797 MILES I THINK PEOPLE SHOULD KNOW THAT INSURANCE COMPANIES DO NOT PAY FOR CERTAIN COMPONENTS ON THE 2004 CHEVROLET MALIBU. THIS CAR IS STILL BEING SOLD ALL OVER THE COUNTRY. I FOUND 7 GM CERTIFIED USED VEHICLES, CHEVROLET 2004 MALIBU'S FOR SALE WITHIN A RADIUS OF 250 MILES RANGING IN PRICE FROM $9,500 TO $14,000. PEOPLE THINK THEY ARE SAFE WHEN THEY BUY THESE 2004 MALIBU'S; THEY ARE NOT. IS THERE SOME WAY THEY CAN BE TAKEN OFF THE ROAD? *TR THE INTERMEDIATE SHAFT NEEDED TO BE REPLACED. UPDATED 03/18/09.*JB THE CONSUMER WAS ALSO INFORMED THE BRAKES AND GEAR SHIFT NEEDED TO BE REPLACED. UPDATED 04/09/09. *JB
TL*THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE ATTEMPTING TO SLOW DOWN FROM 60 MPH, THE BRAKES WOULD APPLY AUTOMATICALLY. AS A RESULT, THE CONTACT EXPERIENCED DIFFICULTY WHEN SHE ATTEMPTED TO ACCELERATE. THE FAILURE WAS INTERMITTENT. THROUGH ONLINE RESEARCH, THE CONTACT DISCOVERED A RECALL FOR THE ABS. IN MAY OF 2008, S…
Read full complaint
TL*THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE ATTEMPTING TO SLOW DOWN FROM 60 MPH, THE BRAKES WOULD APPLY AUTOMATICALLY. AS A RESULT, THE CONTACT EXPERIENCED DIFFICULTY WHEN SHE ATTEMPTED TO ACCELERATE. THE FAILURE WAS INTERMITTENT. THROUGH ONLINE RESEARCH, THE CONTACT DISCOVERED A RECALL FOR THE ABS. IN MAY OF 2008, SHE TOOK THE VEHICLE TO THE DEALER AND THEY REPROGRAMMED THE ABS ACTIVATION MODULE IN REGARDS TO NHTSA CAMPAIGN ID NUMBER 04V190000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE).; HOWEVER, THE FAILURE WORSENED A COUPLE OF DAYS LATER. THE CONTACT FELT AS IF SHE WERE DRIVING ON FOUR FLAT TIRES. SHE CALLED THE MANUFACTURER AND DEALER MULTIPLE TIMES, BUT HAS NOT RECEIVED ANY ASSISTANCE OR SATISFACTION. THE CURRENT MILEAGE WAS 81,318 AND FAILURE MILEAGE WAS APPROXIMATELY 80,000.
Official recalls
614V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
04V190000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Apr 19, 2004
SOME OF THESE PASSENGER VEHICLES HAVE AN ELECTRONIC CONTROL UNIT (ECU) THAT MAY CALCULATE A HIGHER THAN ACTUAL VEHICLE SPEED BECAUSE OF AN ERRATIC REAR-WHEEL SPEED SENSOR SIGNAL, AND CAUSE ABS ACTIVATION WHERE IT IS NOT NEEDED OR NEEDED ABS ACTIVATION TO BE EXTENDED DURING BRAKING AS THE VEHICLE SPEED DROPS TO ABOUT 3 MPH.
Consequence & remedy
Consequence: UNEXPECTED ABS ACTIVIATION COULD INCREASE STOPPING DISTANCE UP TO ABOUT 11 FEET DPENDING ON THE GRADE OF THE ROAD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ABS CONTROLLER. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
04V188000 · Seat Belts:front:anchorage
Apr 16, 2004
ON CERTAIN PASSENGER VEHICLES, ANALYSIS OF AN A SIDE IMPACT CRASH TEST CONDUCTED BY THE NHTSA;S NEW CAR ASSESSMENT PROGRAM (NCAP) INDICATED THAT THE OUTBOARD ANCHORAGE OF THE DRIVER'S SEAT BELT COULD DISCONNECT BECAUSE OF CONTACT BETWEEN THE SEAT TRIM AND THE ANCHORAGE CONNECTOR WHEN THE SEAT WAS ADJUSTED TO ITS LOWEST POSITION.
Consequence & remedy
Consequence: IF THIS OCCURRED IN A CRASH, THE DRIVER COULD RECEIVE GREATER INJURIES.
Remedy: DEALERS WILL INSERT A RETAINER ON BOTH THE DRIVER'S AND PASSENGER'S BELT ANCHORAGES. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
04V094000 · Equipment:other:labels
Feb 24, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES THAT WERE NOT EQUIPPED WITH AN ADVANCED OCCUPANT RESTRAINT SYSTEM (AORS) HAVE DRIVER AND PASSENGER SIDE SUN VISORS WITH AORS LABELS. THE AORS LABELS DO NOT INCLUDE STATEMENTS AND THE ILLUSTRATION REQUIRED BY FMVSS NO. 208 FOR VEHICLES WITHOUT AORS.
Consequence & remedy
Consequence: Not supplied
Remedy: OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA09004 · Turn Signal Lamps
Opened Mar 20, 2009 · Closed Aug 12, 2010
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:headlights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a DRL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.
Additional source detail variants (4)
Exterior Lighting:brake Lights
GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a DRL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.
Exterior Lighting:headlights
GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a DRL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.
Exterior Lighting:tail Lights
GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a DRL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.
Exterior Lighting:turn Signal
GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a DRL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.
PE08062 · Turn Signal Lamps
Opened Oct 21, 2008 · Closed Mar 20, 2009
Status: closed (inferred from source dates) · Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
THE SUBJECT VEHICLES MAY EXPERIENCE LOSS OF FUNCTION OF ONE OR MORE OF THE PARK, TURN, STOP OR DAYTIME RUNNING LAMPS (DRL).FAILURE OF THE BULB MAY ALSO INCLUDE DISCOLORATION (HEAT DAMAGE) TO THE BULB SOCKET.GENERAL MOTORS (GM) TECHNICAL SERVICE BULLETIN (TSB) NUMBER 06-08-42-004C INSTRUCTS TECHNICIANS TO EXAMINE THE LAMP HOUSING FOR SIGNS OF DISCOLORATION AND TO REPLACE THE BULBS AND OR SOCKETS DEPENDING ON THE SEVERITY OF THE DISCOLORATION AND THE CONDITION OF THE BULBS AND SOCKETS.THE SCOPE OF INVESTIGATION IN THE PRELIMINARY EVALUATION (PE08-062) WAS THE 2004 MALIBU/MAXX.HOWEVER, THE AGENCY EVALUATED GM'S WARRANTY DATA WHICH INDICATES THAT THE 2005 MODEL YEAR (MY) MALIBU AND MALIBU MAXX VEHICLES ARE ALSO AFFECTED BY THIS CONDITION.THIS INVESTIGATION IS UPGRADED TO AN ENGINEERING ANALYSIS (EA09-004).
Additional source detail variants (2)
Exterior Lighting:tail Lights
THE SUBJECT VEHICLES MAY EXPERIENCE LOSS OF FUNCTION OF ONE OR MORE OF THE PARK, TURN, STOP OR DAYTIME RUNNING LAMPS (DRL).FAILURE OF THE BULB MAY ALSO INCLUDE DISCOLORATION (HEAT DAMAGE) TO THE BULB SOCKET.GENERAL MOTORS (GM) TECHNICAL SERVICE BULLETIN (TSB) NUMBER 06-08-42-004C INSTRUCTS TECHNICIANS TO EXAMINE THE LAMP HOUSING FOR SIGNS OF DISCOLORATION AND TO REPLACE THE BULBS AND OR SOCKETS DEPENDING ON THE SEVERITY OF THE DISCOLORATION AND THE CONDITION OF THE BULBS AND SOCKETS.THE SCOPE OF INVESTIGATION IN THE PRELIMINARY EVALUATION (PE08-062) WAS THE 2004 MALIBU/MAXX.HOWEVER, THE AGENCY EVALUATED GM'S WARRANTY DATA WHICH INDICATES THAT THE 2005 MODEL YEAR (MY) MALIBU AND MALIBU MAXX VEHICLES ARE ALSO AFFECTED BY THIS CONDITION.THIS INVESTIGATION IS UPGRADED TO AN ENGINEERING ANALYSIS (EA09-004).
Exterior Lighting:turn Signal
THE SUBJECT VEHICLES MAY EXPERIENCE LOSS OF FUNCTION OF ONE OR MORE OF THE PARK, TURN, STOP OR DAYTIME RUNNING LAMPS (DRL).FAILURE OF THE BULB MAY ALSO INCLUDE DISCOLORATION (HEAT DAMAGE) TO THE BULB SOCKET.GENERAL MOTORS (GM) TECHNICAL SERVICE BULLETIN (TSB) NUMBER 06-08-42-004C INSTRUCTS TECHNICIANS TO EXAMINE THE LAMP HOUSING FOR SIGNS OF DISCOLORATION AND TO REPLACE THE BULBS AND OR SOCKETS DEPENDING ON THE SEVERITY OF THE DISCOLORATION AND THE CONDITION OF THE BULBS AND SOCKETS.THE SCOPE OF INVESTIGATION IN THE PRELIMINARY EVALUATION (PE08-062) WAS THE 2004 MALIBU/MAXX.HOWEVER, THE AGENCY EVALUATED GM'S WARRANTY DATA WHICH INDICATES THAT THE 2005 MODEL YEAR (MY) MALIBU AND MALIBU MAXX VEHICLES ARE ALSO AFFECTED BY THIS CONDITION.THIS INVESTIGATION IS UPGRADED TO AN ENGINEERING ANALYSIS (EA09-004).
EA04018 · Loss Of Electric Power Steering
Opened Jul 1, 2004 · Closed May 10, 2005
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: - GM ISSUED CUSTOMER SATISFACTION CAMPAIGN (CSC) 04050A INDECEMBER 2004 TO ADDRESS THE ALLEGED DEFECT IN APPROXIMATELY58,700 SUBJECT VEHICLES, ENCOMPASSING AT LEAST 97 PERCENT OF THECOMPLAINT AND WARRANTY CLAIMS POPULATION.VEHICLES OUTSIDE THECSC 04050A POPULATION CONTAIN A NEWLY DESIGNED TORQUE ANDPOSITION SENSOR AND HAVE EXPERIENCED A RELATIVELY LOW COMPLAINTRATE.THIS CUSTOMER SATISFACTION CAMPAIGN PRESENTLY HAS ACOMPLETION RATE OF 52%. - THE IMPACT ON THE DRIVER?S ABILITY TO CONTROL THESE RELATIVELYSMALL AND LIGHT VEHICLES WAS LIMITED.VRTC TEST ENGINEERS WEREUNABLE TO INDUCE A FAILURE MODE THAT WOULD CAUSE THE EPS TOSUBSTANTIALLY LIMIT THE DRIVER?S ABILITY TO TURN THE VEHICLE IN APARTICULAR DIRECTION OR TO PROVIDE THE DRIVER WITH UNINTENDEDPOWER ASSISTANCE.- THERE IS NO RISK OF FIRE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED BY THE CIRCUMSTANCES.(FOR FURTHER DETAILS SEE ATTACHED ENGINEERING ANALYSIS (EA04-018)CLOSING REPORT.)
Additional source detail variants (2)
Steering:electric Power Assist System
IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: - GM ISSUED CUSTOMER SATISFACTION CAMPAIGN (CSC) 04050A INDECEMBER 2004 TO ADDRESS THE ALLEGED DEFECT IN APPROXIMATELY58,700 SUBJECT VEHICLES, ENCOMPASSING AT LEAST 97 PERCENT OF THECOMPLAINT AND WARRANTY CLAIMS POPULATION.VEHICLES OUTSIDE THECSC 04050A POPULATION CONTAIN A NEWLY DESIGNED TORQUE ANDPOSITION SENSOR AND HAVE EXPERIENCED A RELATIVELY LOW COMPLAINTRATE.THIS CUSTOMER SATISFACTION CAMPAIGN PRESENTLY HAS ACOMPLETION RATE OF 52%. - THE IMPACT ON THE DRIVER?S ABILITY TO CONTROL THESE RELATIVELYSMALL AND LIGHT VEHICLES WAS LIMITED.VRTC TEST ENGINEERS WEREUNABLE TO INDUCE A FAILURE MODE THAT WOULD CAUSE THE EPS TOSUBSTANTIALLY LIMIT THE DRIVER?S ABILITY TO TURN THE VEHICLE IN APARTICULAR DIRECTION OR TO PROVIDE THE DRIVER WITH UNINTENDEDPOWER ASSISTANCE.- THERE IS NO RISK OF FIRE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED BY THE CIRCUMSTANCES.(FOR FURTHER DETAILS SEE ATTACHED ENGINEERING ANALYSIS (EA04-018)CLOSING REPORT.)
Steering
IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: - GM ISSUED CUSTOMER SATISFACTION CAMPAIGN (CSC) 04050A INDECEMBER 2004 TO ADDRESS THE ALLEGED DEFECT IN APPROXIMATELY58,700 SUBJECT VEHICLES, ENCOMPASSING AT LEAST 97 PERCENT OF THECOMPLAINT AND WARRANTY CLAIMS POPULATION.VEHICLES OUTSIDE THECSC 04050A POPULATION CONTAIN A NEWLY DESIGNED TORQUE ANDPOSITION SENSOR AND HAVE EXPERIENCED A RELATIVELY LOW COMPLAINTRATE.THIS CUSTOMER SATISFACTION CAMPAIGN PRESENTLY HAS ACOMPLETION RATE OF 52%. - THE IMPACT ON THE DRIVER?S ABILITY TO CONTROL THESE RELATIVELYSMALL AND LIGHT VEHICLES WAS LIMITED.VRTC TEST ENGINEERS WEREUNABLE TO INDUCE A FAILURE MODE THAT WOULD CAUSE THE EPS TOSUBSTANTIALLY LIMIT THE DRIVER?S ABILITY TO TURN THE VEHICLE IN APARTICULAR DIRECTION OR TO PROVIDE THE DRIVER WITH UNINTENDEDPOWER ASSISTANCE.- THERE IS NO RISK OF FIRE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED BY THE CIRCUMSTANCES.(FOR FURTHER DETAILS SEE ATTACHED ENGINEERING ANALYSIS (EA04-018)CLOSING REPORT.)
PE04031 · Loss Of Electric Power Steering
Opened Mar 30, 2004 · Closed Jul 1, 2004
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI OPENED PE04-031 BASED ON EIGHT REPORTS OF ALLEGED POWER STEERING FAILURE IN THE SUBJECT VEHICLES.THE COMPLAINTS ALLEGE THAT THE DRIVER SUDDENLY LOST ALL ELECTRIC POWER STEERING ASSISTANCE WITHOUT WARNING MAKING THE VEHICLE DIFFICULT TO STEER. THE SUBJECT VEHICLE UTILIZES AN ELECTRIC POWER STEERING ASSIST SYSTEM (EPS) THAT PROVIDES VARIABLE STEERING ASSISTANCE BASED ON STEERING WHEEL TORQUE, STEERING WHEEL POSTION, AND VEHICLE SPEED.GENERAL MOTORS DOCUMENTS IDENTIFIED THE FOLLOWING TWO FACTORS THAT CONTRIBUTED TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES: A.CONTAMINATION OF THE TORQUE AND POSITION SENSOR FROM THESEPARATION OF GREASE APPLIED TO THE STEERING COLUMN ASSEMBLY. B.ELECTRICAL NOISE GENERATED ON THE POWER AND GROUND SLIP RING SURFACES OF THE TORQUE AND POSITION SENSOR.THE NOISE IS GENERATED AS THE SENSOR CONTACT BRUSHES MOVE ALONG THE SLIP RING SURFACES WHEN THE STEERING WHEEL IS ROTATED.ODI'S ANALYSIS SHOWED FAILURERATES THAT ARE OF CONCERN TO ODI AND INDICATED THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES. THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI OPENED PE04-031 BASED ON EIGHT REPORTS OF ALLEGED POWER STEERING FAILURE IN THE SUBJECT VEHICLES.THE COMPLAINTS ALLEGE THAT THE DRIVER SUDDENLY LOST ALL ELECTRIC POWER STEERING ASSISTANCE WITHOUT WARNING MAKING THE VEHICLE DIFFICULT TO STEER. THE SUBJECT VEHICLE UTILIZES AN ELECTRIC POWER STEERING ASSIST SYSTEM (EPS) THAT PROVIDES VARIABLE STEERING ASSISTANCE BASED ON STEERING WHEEL TORQUE, STEERING WHEEL POSTION, AND VEHICLE SPEED.GENERAL MOTORS DOCUMENTS IDENTIFIED THE FOLLOWING TWO FACTORS THAT CONTRIBUTED TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES: A.CONTAMINATION OF THE TORQUE AND POSITION SENSOR FROM THESEPARATION OF GREASE APPLIED TO THE STEERING COLUMN ASSEMBLY. B.ELECTRICAL NOISE GENERATED ON THE POWER AND GROUND SLIP RING SURFACES OF THE TORQUE AND POSITION SENSOR.THE NOISE IS GENERATED AS THE SENSOR CONTACT BRUSHES MOVE ALONG THE SLIP RING SURFACES WHEN THE STEERING WHEEL IS ROTATED.ODI'S ANALYSIS SHOWED FAILURERATES THAT ARE OF CONCERN TO ODI AND INDICATED THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES. THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Steering
ODI OPENED PE04-031 BASED ON EIGHT REPORTS OF ALLEGED POWER STEERING FAILURE IN THE SUBJECT VEHICLES.THE COMPLAINTS ALLEGE THAT THE DRIVER SUDDENLY LOST ALL ELECTRIC POWER STEERING ASSISTANCE WITHOUT WARNING MAKING THE VEHICLE DIFFICULT TO STEER. THE SUBJECT VEHICLE UTILIZES AN ELECTRIC POWER STEERING ASSIST SYSTEM (EPS) THAT PROVIDES VARIABLE STEERING ASSISTANCE BASED ON STEERING WHEEL TORQUE, STEERING WHEEL POSTION, AND VEHICLE SPEED.GENERAL MOTORS DOCUMENTS IDENTIFIED THE FOLLOWING TWO FACTORS THAT CONTRIBUTED TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES: A.CONTAMINATION OF THE TORQUE AND POSITION SENSOR FROM THESEPARATION OF GREASE APPLIED TO THE STEERING COLUMN ASSEMBLY. B.ELECTRICAL NOISE GENERATED ON THE POWER AND GROUND SLIP RING SURFACES OF THE TORQUE AND POSITION SENSOR.THE NOISE IS GENERATED AS THE SENSOR CONTACT BRUSHES MOVE ALONG THE SLIP RING SURFACES WHEN THE STEERING WHEEL IS ROTATED.ODI'S ANALYSIS SHOWED FAILURERATES THAT ARE OF CONCERN TO ODI AND INDICATED THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES. THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.