NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
228 reportsClear category filter43,000 miles · Jul 6, 2004
Electrical SystemEngine And Engine CoolingEquipment
WE UNFORTUNATELY OWN A 2000 CHEVY MALIBU. WE HAVE ALREADY REPLACED THE ROTORS SEVERAL TIMES FOR GOING OUT OF ROUND. WE HAVE ALSO REPLACED THE FUEL PUMP AT LESS THEN 50,000 MILES AT THE COST OF $728.00. THE AIR CONDITIONER POPS ON AND OFF ON ITS OWN NOT COOLING FOR THE MOST PART. THE TURN SIGNALS ARE NONFUNCTIONAL AND OUR VIN NU…
Read full complaint
WE UNFORTUNATELY OWN A 2000 CHEVY MALIBU. WE HAVE ALREADY REPLACED THE ROTORS SEVERAL TIMES FOR GOING OUT OF ROUND. WE HAVE ALSO REPLACED THE FUEL PUMP AT LESS THEN 50,000 MILES AT THE COST OF $728.00. THE AIR CONDITIONER POPS ON AND OFF ON ITS OWN NOT COOLING FOR THE MOST PART. THE TURN SIGNALS ARE NONFUNCTIONAL AND OUR VIN NUMBER IS NOT INCLUDED IN THE RECALL ALTHOUGH IT SHOULD BE. THEN THERE IS THE TRANSMISSION SLIPPING AND THE COOLANT LEAKING AND THE CAR OVERHEATING WE ARE TOLD THIS IS A MANIFOLD INTAKE GASKET AND WILL COST AROUND 800.00 TO FIX. THE NEWEST PROBLEM IS THE FACTORY INSTALLED RADIO TUNER IS BURNED OUT AND NOW WE HAVE TO REPLACE THE RADIO COSTING YET ANOTHER $100.00 DOLLARS OR SO THIS CAR HAS NICKEL AND DIMED US TOO MUCH. AFTER LOOKING OVER YOUR SITE I FOUND THESE TO BE NUMEROUS COMPLAINTS ON THE SAME YEAR AND MODEL. I FEEL THIS CAR WAS A LEMON ACROSS THE BOARD NOT JUST OURS BUT, ALL 2000 MALIBU'S. PLEASE LOOK INTO THESE CARS ON A WHOLE THEY WERE VERY BADLY MANUFACTURED AND WE ALL DESERVE SOME COMPENSATION FOR IT. *JB
NHTSA ODI #10080442
7,000 miles · Jul 6, 2004
Electrical SystemEngine And Engine CoolingEquipment
INTERMITTENTLY WHEN THE BRAKE PEDAL WAS APPLIED, THE BRAKES GRABBED SO HARD THAT THE ENTIRE VEHICLE VIBRATED SEVERELY. WHEN THIS OCCURRED, THE VEHICLE FAILED TO STOP IMMEDIATELY. THIS RESULTED IN EXTENDED STOPPING DISTANCE. THE BRAKE ROTORS WARPED. ON ONE OCCASION THIS FAILURE CAUSED LOST OF CONTROL, IN WHICH THE CONSUMER ALM…
Read full complaint
INTERMITTENTLY WHEN THE BRAKE PEDAL WAS APPLIED, THE BRAKES GRABBED SO HARD THAT THE ENTIRE VEHICLE VIBRATED SEVERELY. WHEN THIS OCCURRED, THE VEHICLE FAILED TO STOP IMMEDIATELY. THIS RESULTED IN EXTENDED STOPPING DISTANCE. THE BRAKE ROTORS WARPED. ON ONE OCCASION THIS FAILURE CAUSED LOST OF CONTROL, IN WHICH THE CONSUMER ALMOST CRASHED INTO AN 18 WHEELER, BUT WAS ABLE TO PULL OVER TO THE MEDIUM. THE DEALERSHIP HAS ACKNOWLEDGED THAT THERE WAS A PROBLEM WITH THE BRAKING SYSTEM, BUT WAS UNABLE TO CORRECT THE PROBLEM, AND WAS NOW REFUSING TO WORK ON THE VEHICLE. *AK THERE WAS A RATTLE UNDER THE HOOD AT THE FIREWALL AREA WHILE THE VEHICLE WAS IN MOTION, THE HOSE ASSEMBLY WAS FOUND RUBBING UNDER THE VEHICLE, BOTH FRONT ROTORS HAD WORE THIN, THE FUEL PUMP SENDER DID NOT HOLD THE CORRECT AMOUNT OF FUEL PRESSURE, THERE WAS AN OPEN CIRCUIT IN THE 24X CRANK SENSOR, THERE WAS A RATTLE IN THE FRONT SUSPENSION DUE TO WEAK FRONT LOWER CONTROL ARMS WHICH WERE NOISY (THE RIGHT LOWER CONTROL ARM WAS REPLACED), THE COOLANT LEVEL SENSOR SHORTED, THE WATER PUMP ASSEMBLY LEAKED COOLANT, THERE WAS A VIBRATION AT HIGHWAY SPEEDS, HARDWARE WAS BAD AND WAS LOOSE IN THE CALIPER, ROTOR PULSATION WHICH WAS REPLACED PER BULLETIN, THE TURN SIGNAL WAS INOPERATIVE, AND THE A/C HAD INTERNAL DAMAGE AND WOULD CUT ON AND OFF. *SC
NHTSA ODI #10075995
Mileage unknown · Jun 3, 2004
Service Brakes, Hydraulic
WHEN DEPRESSING THE BRAKE PEDAL IS DELAYED. THE CONSUMER HAS MADE CONTACT WITH THE DEALERSHIP. PLEASE PROVIDE ANY FURTHER DETAILS. *NM
NHTSA ODI #10075602
Mileage unknown · May 28, 2004
Service Brakes, Hydraulic
I HAVE A 2000 CHEVY MALIBU AND IT WEARS OUT BRAKE PADS ON LESS THEN 10,000 MILES. GM REFUSES TO DO ANYTHING ABOUT IT AND BLAMES THE CUSTOMER'S DRIVING HABITS. IT IS OUT OF WARRANTY, SO THERE IS NOT MUCH I CAN DO SINCE GM SAYS IT IS THE BRAKE PADS. THERE HAS TO BE SOMETHING ELSE CAUSING THIS TO HAPPEN, BUT GM REFUSES TO LISTEN…
Read full complaint
I HAVE A 2000 CHEVY MALIBU AND IT WEARS OUT BRAKE PADS ON LESS THEN 10,000 MILES. GM REFUSES TO DO ANYTHING ABOUT IT AND BLAMES THE CUSTOMER'S DRIVING HABITS. IT IS OUT OF WARRANTY, SO THERE IS NOT MUCH I CAN DO SINCE GM SAYS IT IS THE BRAKE PADS. THERE HAS TO BE SOMETHING ELSE CAUSING THIS TO HAPPEN, BUT GM REFUSES TO LISTEN. *LA
NHTSA ODI #10073302
Mileage unknown · Apr 7, 2004
Service Brakes, Hydraulic
I PURCHASED A USED 2000 CHEVY MALIBU WITH 18,000 MILE IN MARCH OF 2002. THE CAR WAS TAKEN BACK TO THE DEALERSHIP A WEEK LATER DUE TO PROBLEMS WITH THE BRAKES/ROTORS AND THE BRAKES/ROTORS WERE REPLACED. I CONTINUE TO HAVE PROBLEMS WITH THE BRAKES AND ROTORS. IN THE 2 YEARS I HAVE OWNED THIS CAR, I HAVE REPLACED THE BRAKES AND…
Read full complaint
I PURCHASED A USED 2000 CHEVY MALIBU WITH 18,000 MILE IN MARCH OF 2002. THE CAR WAS TAKEN BACK TO THE DEALERSHIP A WEEK LATER DUE TO PROBLEMS WITH THE BRAKES/ROTORS AND THE BRAKES/ROTORS WERE REPLACED. I CONTINUE TO HAVE PROBLEMS WITH THE BRAKES AND ROTORS. IN THE 2 YEARS I HAVE OWNED THIS CAR, I HAVE REPLACED THE BRAKES AND ROTORS 2 TIMES AND REPLACED THE BRAKES 3 TIMES. THIS IS TOTALLY RIDICULOUS. MY CAR ONLY HAS 54,000 MILES. I CONTACTED THE CHEVROLET CUSTOMER SERVICE LINE AND WAS TOLD THIS WAS A WEAR ISSUE AND NOT COVERED BY WARRANTY. I FEEL A RECALL IS WARRANTED AS THIS IS OBVIOULSY A DEFECT WITH THIS MAKE AND MODEL.*AK
NHTSA ODI #10065691
120,350 miles · Mar 3, 2004
Engine And Engine CoolingService Brakes, Hydraulic
2000 CHEVROLET MALIBU BOUGHT WITH 120,000 MILES ON IT. LESS THAN A WEEK AFTER GETTING THIS CAR FOR 5500.00, WHEN RETAIL ON THE CAR WAS 8300.00, I HAD TO REPLACE THE INTAKE MANIFOLD GASKET AND THE VALVE COVER GASKETS BECAUSE THEY WERE LEAKING COOLANT. ALSO, THE BRAKES SHUDDER AND VIBRATE WHENEVER APPLIED, EVEN AT SPEEDS LESS T…
Read full complaint
2000 CHEVROLET MALIBU BOUGHT WITH 120,000 MILES ON IT. LESS THAN A WEEK AFTER GETTING THIS CAR FOR 5500.00, WHEN RETAIL ON THE CAR WAS 8300.00, I HAD TO REPLACE THE INTAKE MANIFOLD GASKET AND THE VALVE COVER GASKETS BECAUSE THEY WERE LEAKING COOLANT. ALSO, THE BRAKES SHUDDER AND VIBRATE WHENEVER APPLIED, EVEN AT SPEEDS LESS THAN 25 MPH. HALF A WEEK LATER, THE GAS GAUGE FELL TO ZERO WHILE NORMAL DRIVING AND THE LOW GAS LIGHT CAME ON, EVEN THOUGH I HAD JUST FILLED THE CAR UP TWO DAYS PRIOR. THERE WAS PLENTY OF GAS IN THE CAR, ABOUT 3/4 OF A TANK. ALSO, THE TRANMISSION IS SLIPPING NOW WHEN I SPEED UP. WHEN I SPEED UP THE CAR DOES NOT SHIFT INTO 1ST GEAR RIGHT AWAY UNTIL 4000 RPM. WHEN IT DOES SHIFT, IT SHIFT WITH A LARGE JOLT THAT SHAKES THE ENTIRE CAR. THERE WAS NO WARNING BEFORE THE GAS LIGHT CAME ON, AND I FIND THE CAR TO ONLY NOW HAVE ALL OF THESE PROBLEMS. ALSO, THE CAR SMELLS OF GASOLINE AND LEAKS, EVEN THOUGH I HAD IT FIXED. *AK
NHTSA ODI #10060269
30,000 miles · Feb 19, 2004
Service Brakes, Hydraulic
WHEN THE DRIVER APPLIED THE BRAKES THE VEHICLE SHOOK. THE CONSUMER STATED THAT THE VEHICLE NEEDED TO HAVE NEW BRAKE PADS AND ROTORS EVERY 6,000 MILES. *NM
NHTSA ODI #10059380
41,000 miles · Feb 19, 2004
Service Brakes, Hydraulic
THE CONSUMER COMPLAINED ABOUT BRAKE PROBLEMS. WHEN APPLYING BRAKES THE PEDAL GOES ALL THE WAY TO THE FLOOR, THERE WAS EXTENSIVE PULSATION, AND EXTENDED STOPPING DISTANCE. *AK THE ABS LIGHT WAS ON AND WAS INTERMITTENT. THIS MADE THE STOPPING DISTANCE LONGER ALMOST CAUSING ACCIDENTS. *SC
NHTSA ODI #10046076
Mileage unknown · Jan 30, 2004
Service Brakes, Hydraulic
2000 CHEVY MALIBU SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
NHTSA ODI #10056195
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
THIS CAR HAS BEEN ONE PROBLEM AFTER ANOTHER. THE DAY AFTER WE LEASED THE CAR IT WAS IN THE SHOP FOR THE BRAKES, THE CAR HAS HAD 2 ENGINES IN IT. THE TRANSMISSION HAS BEEN REBUILT. THE BRAKES ARE STILL NOT CORRECT. TRANSMISSION IS SLIPPING AGAIN AND THE 3 YEAR WARRANTY IS UP. WE COMPLAINED TO CHEVROLET AND THE BBB. TO NO AVAIL …
Read full complaint
THIS CAR HAS BEEN ONE PROBLEM AFTER ANOTHER. THE DAY AFTER WE LEASED THE CAR IT WAS IN THE SHOP FOR THE BRAKES, THE CAR HAS HAD 2 ENGINES IN IT. THE TRANSMISSION HAS BEEN REBUILT. THE BRAKES ARE STILL NOT CORRECT. TRANSMISSION IS SLIPPING AGAIN AND THE 3 YEAR WARRANTY IS UP. WE COMPLAINED TO CHEVROLET AND THE BBB. TO NO AVAIL THEY SEEMED TO BE ON CHEVROLET'S SIDE IN THE CASE. WE WERE TO THE POINT THAT WE WERE JUST GOING TO LET THE CAR GO BACK BUT THAT WOULD ONLY HURT MY HUSBAND'S CREDIT MORE THEN IT WAS ALREADY. WE HAD TO KEEP THE CAR THROUGH THE LEASE. THIS LEFT A REALLY BAD TAST IN MY MOUTH FOR PURCHASING NEW VEHICLES BECAUSE YOU ARE STUCK WITH IT FOR THE DURATION OF THE LEASE OR PURCHASE.
NHTSA ODI #10070331
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Oct 29, 1999
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN THE TANK IS MORE THAN HALF FULL.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE02066 · Engine Stall Due To Fuel Starvation
Opened Sep 6, 2002 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other; Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
PE02064 · Turn Signal Failure
Opened Aug 22, 2002 · Closed Dec 23, 2002
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:hazard Flashing Warning Lights:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
SQ00004 · Accelerator Cable Detaches From Throttle
Opened Feb 2, 2000 · Closed Jan 19, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration