IllustrationDT: CONTACT STATES THE TAIL LIGHTS FILL UP WITH WATER. *AK
2000 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2000 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
370–25K
8825–50K
12250–75K
8375–100K
89100–150K
38150K+
457 reports with mileage · 465 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 241 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 228 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 199 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
45 crash reports6 fire reports31 injury reports
Exterior Lighting complaints
241 reportsI HAVE ALREADY FILED COMPLAINT IN REGARDS TO THE HAZARD LIGHT RECALL, WHICH FOR SOME REASON DOES NOT COVER MY 2000 MALIBU. I NOTICED OTHER COMPLAINTS ON THE MALIBU AND FIGURED I WOULD THROW MY TWO CENTS IN. I TO HAVE HAD TO DROP OVER $1000 DOLLARS INTO THE MOST DEFECTIVE CAR I HAVE PURCHASED THIS INCLUDES THE $200 PIECE OF JUN…
Read full complaint
I HAVE ALREADY FILED COMPLAINT IN REGARDS TO THE HAZARD LIGHT RECALL, WHICH FOR SOME REASON DOES NOT COVER MY 2000 MALIBU. I NOTICED OTHER COMPLAINTS ON THE MALIBU AND FIGURED I WOULD THROW MY TWO CENTS IN. I TO HAVE HAD TO DROP OVER $1000 DOLLARS INTO THE MOST DEFECTIVE CAR I HAVE PURCHASED THIS INCLUDES THE $200 PIECE OF JUNKS I BOUGHT WHEN I WAS A TEENAGER. MY LIST OF PROBLEMS. 1. COOLANT SYSTEM LEAK COST $700 NOTE: MECHANIC LAUGHED AND SAID THIS HAPPENS ALL THE TIME IS THIS TYPE OF ENGINE. IN REVIEWING OTHER COMPLAINTS, THE ONE REALLY STANDS OUT. NICE I AM GLAD GM OWNS UP TO ITS PROBLEMS. 2. BRAKES CONSTANTLY NEED TO BE REPLACED WELL BELOW MILEAGE. GLAD GM SAVED A FEW BUCKS UNDER SIZING THE ROTORS. 3. WITHIN A YEAR THE FANS SWITCH (LEVELS 1,2) AND LIGHTER STOPPED WORKING. BOY GM IS SAVING LOTS MONEY NOW. 4. WITHIN THE PAST YEAR I HAD FUEL PUMP FAILURE, NOTHING LIKE TRAVELING IN RUSH HOUR TRAFFIC DOING 75MPH AND CAR TOTALLY DIEING. BOY GM HAS MADE ONE QUALITY CAR. 5. THE LAST INSULT, MY FIRST AND LIKELY LAST GM PRODUCT IS WHEN I THOUGHT BOY I FINALLY GET SOMETHING FROM GM IN REGARDS TO ONE SMALL DEFECT, THE HAZARD SWITCH, I FIND OUT THAT MY VEHICLE IS NOT COVERED BY THIS RECALL. WOW NOT ONLY I AM OUT AT LEAST $1000 BUCKS ON PIECE OF CRAP PRODUCT, GM DOES NOT EVEN WANT TO GIVE A BONE TO HUNGRY MAN. WITH THIS TYPE OF PRODUCT IT IS NO WONDER GM IS LOSING MARKET SHARE FASTER THAN ANY OTHER AUTOMOTIVE COMPANY. KEEP UP THE GOOD WORK GM. CLEARLY THE ARE SOME SERIOUS DEFECTS WITH THIS VEHICLE AND THE GMS OWNERSHIP WITH DEFECTS.
THE TURN SIGNALS WORK INTERMITTENTLY. NO SERVICE HAS BEEN PERFORMED ON THE VEHICLE FOR THE EXISTING PROBLEM.*AK
CONSUMER STATED THE SIGNAL LIGHTS WORKED INTERMITTENTLY OR SOMETIMES THEY DID NOT WORK AT ALL. RECALL 03V327000 CONCERNING HAZARD WARNING SWITCH WAS ISSUED. CONSUMER INDICATED THAT THE RECALL WAS THE PROBLEM WITH THE VEHICLE. *AK
CONSUMER EXPERIENCED PROBLEM AFTER PROBLEM WITH 2000 MALIBU. INTERIOR WORKMANSHIP FALLING APART, OUTSIDE MIRROR PAINT FADING, REPLACED FUEL PUMP AND OTHER PROBLEMS. *BF THE VEHICLE TURN SIGNAL MALFUNCTIONED AND THE TRUCK LID WOULD OPEN INTERMITTENTLY ON IT'S OWN. *NM
CHEV. 2000 MALIBU RECALL 03043 (03V327000). UNABLE TO GET RECALL COMPLETED DUE TO NO PARTS AVAILABLE. AT SLOANE CHEVROLET SERVICE DEPARTMENT (COTTMAN AVE., PHILA, PA.) ON 1/17/05: ARRANGEMENTS WERE MADE OVER 1 WEEK IN ADVANCE TO COME IN FOR THE RECALL. RECALL DESCRIPTION & RECALL NUMBER & VIN NUMBER WERE GIVEN TO THE CHEVROLET D…
Read full complaint
CHEV. 2000 MALIBU RECALL 03043 (03V327000). UNABLE TO GET RECALL COMPLETED DUE TO NO PARTS AVAILABLE. AT SLOANE CHEVROLET SERVICE DEPARTMENT (COTTMAN AVE., PHILA, PA.) ON 1/17/05: ARRANGEMENTS WERE MADE OVER 1 WEEK IN ADVANCE TO COME IN FOR THE RECALL. RECALL DESCRIPTION & RECALL NUMBER & VIN NUMBER WERE GIVEN TO THE CHEVROLET DEALER SERVICE DEPARTMENT SO THEY COULD BR SURE TO HAVE WHAT'S NECESSARY TO COMPLETE THE SERVICE. DESPITE THIS, THE DEALER DID NOT HAVE THE PARTS NECESSARY TO DO THE RECALL! THIS IS AFTER I MADE ARRANGEMENTS TO GET THE WORK DONE WHILE I WAS OFF FROM WORK, AND TRAVELED THERE ON A TREACHEROUS SNOWY DAY. SUGGESTION WAS MADE BY THE DEALER (SLOANE CHEV.) TO CONTACT ANOTHER DEALERSHIP, MAKE ARRANGEMENTS TO BRING THE CAR IN FOR THE RECALL, AND THEN HOPE THAT THEY HAVE THE PART. OBVIOUSLY CHEVROLET/GM DOES NOT WANT TO GET THIS RECALL COMPLETED! *JB
CONSUMER COMPLAINED ABOUT HAZARD WARNING LIGHTS. THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE. CONSUMER CONTACTED THE DEALER WHO OFFERED A DIAGNOSTIC TEST TO DETERMINE THE CAUSE. CONSUMER LATER CONTACTED MANUFACTURER, WHO NOTIFIED CONSUMER THAT THIS VEHICLE WAS NOT INCLUDED IN A RECALL DUE TO VIN ALTHOUGH SH…
Read full complaint
CONSUMER COMPLAINED ABOUT HAZARD WARNING LIGHTS. THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE. CONSUMER CONTACTED THE DEALER WHO OFFERED A DIAGNOSTIC TEST TO DETERMINE THE CAUSE. CONSUMER LATER CONTACTED MANUFACTURER, WHO NOTIFIED CONSUMER THAT THIS VEHICLE WAS NOT INCLUDED IN A RECALL DUE TO VIN ALTHOUGH SHE EXPERIENCED THE SAME DEFECT THAT WAS MENTIONED IN THE RECALL. *AK *JB
CONSUMER COMPLAINED ABOUT TURN SIGNALS PROBLEM. WHEN DRIVING TURN SIGNALS WORKED OFF AND ON. THE CAUSE OF THIS WAS STILL UNKNOWN.*AK THE CONSUMER STATED THAT CAPITOL CHEVROLET REPLACED THE HAZZARD SWITCH AND THE PROBLEM HAS BEEN CORRECTED. *TC
THE CONSUMER STATED THAT THE TURN SIGNAL INTERMITTENTLY FAILED. A RECALL WAS ISSUED. HOWEVER, THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. *AK THE PROBLEM WOULD ALSO OCCUR WHILE IN MOTION MAKING A LEFT OR RIGHT HAND TURN. *SC *JB
TURN SIGNAL AND FLASHER WOULD INTERMITTENTLY TURN ON, MAKING IT DIFFICULT FOR VEHICLES IN THE REAR TO SEE WHEN DRIVER NEEDED TO TURN. CONSUMER WILL TAKE VEHICLE TO DEALER FOR CHECK UP.*AK
Official recalls
314V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
03V327000 · Exterior Lighting:hazard Flashing Warning Lights:switch
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
99V302000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Oct 29, 1999
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN THE TANK IS MORE THAN HALF FULL.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE02066 · Engine Stall Due To Fuel Starvation
Opened Sep 6, 2002 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other; Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
PE02064 · Turn Signal Failure
Opened Aug 22, 2002 · Closed Dec 23, 2002
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:hazard Flashing Warning Lights:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
SQ00004 · Accelerator Cable Detaches From Throttle
Opened Feb 2, 2000 · Closed Jan 19, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available