NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
174 reportsClear category filterMileage unknown · May 23, 2001
Electrical SystemEngine And Engine CoolingEquipment
I BOUGHT MY 2000 MALIBU BRAND NEW IN SEPTEMBER 1999.... MY ENGINE WAS PINGING AND MAKING ALL KINDS OF NOISE, EVEN WHEN WARM.... BRAKES ARE VERY HAZARDOUS TO PUBLIC SAFETY... I HAVE BEEN TO THE DEALER NUMERIOUS TIMES FOR ROTOR AND PAD REPLACEMENTS AND EVEN GM'S SO CALLED NEW THICKER AND IMPROVED ROTORS THEY INSTALLED ON MY CAR WA…
Read full complaint
I BOUGHT MY 2000 MALIBU BRAND NEW IN SEPTEMBER 1999.... MY ENGINE WAS PINGING AND MAKING ALL KINDS OF NOISE, EVEN WHEN WARM.... BRAKES ARE VERY HAZARDOUS TO PUBLIC SAFETY... I HAVE BEEN TO THE DEALER NUMERIOUS TIMES FOR ROTOR AND PAD REPLACEMENTS AND EVEN GM'S SO CALLED NEW THICKER AND IMPROVED ROTORS THEY INSTALLED ON MY CAR WAS JUST AS BAD AS ALL THE OTHER ONES ... I ALMOST LOST CONTROL OF MY CAR WHEN I WAS TRAVELING 65 MILES PER HOUR ON OUR LOCAL HIGHWAY WHEN I WAS ALMOST HAD A WRECK DUE TO COMPLETE FAILURE OF MY BRAKES... MY CAR VIBRATED SO BADLY AND DID NOT SLOW DOWN...AT ALL!!....I THOUGHT I HAD 2 FRONT TIRE BLOWOUTS... I PULLED OVER ON THE EXPRESSWAY AND MY TIRES WERE FINE IT WAS MY BRAKES...... I WENT STRAIGHT TO A LOCAL AUTOZONE AND PURCHASED NEW ROTORS AND PADS....GM NEEDS TO ISSUE A RECALL ASAP BEFORE SOMEONE GETS SERIOUSLY INJURED OR KILLED!......I HAVE CALLED GM AND MADE A COMPLAINT AND WAS TOLD NO RECALLS WERE MADE..... ANOTHER ISSUE IM HAVING IS IT TAKES 3 OR 4 TIMES TO GET MY CAR STARTED ... NOT SURE WHY MY CAR IS HAVING ALL OF THESE PROBLEMS BUT IT IS AT A LOCAL GM DEALERSHIP AS I TYPE THIS .......I HOPE THEY WILL BE ABLE TO FIX THE NOISE FROM THE ENGINE AND MY CD PLAYER THAT GOES IN AND OUT OF POWER AND SOMETIMES WONT RELEASE MY CD'S .... I HAVE GIVEN UP ON GM BRAKES. *AK
NHTSA ODI #745751
Mileage unknown · Apr 2, 2001
Engine And Engine Cooling
VEHICLE WILL STALL AT SPEEDS OF 50-65 MPH, TO DEALER 5-6 TIMES, CANNOT REMEDY PROBLEM. *AK
NHTSA ODI #884763
Mileage unknown · Mar 26, 2001
Engine And Engine Cooling
WHILE DRIVING AT ANY SPEED WITHOUT PRIOR WARNING VEHICLE CUTS OFF, CAUSING LOSS OF ALL POWER. CONSUMER HAS CONTACTED DEALER, DEALER HAS ATTEMPTED TO CORRECT PROBLEM. HOWEVER, PROBLEM HAS REOCCURRED. PLEASE PROVIDE ANY FURTHER DETAILS.*AK
NHTSA ODI #884068
Mileage unknown · Mar 22, 2001
Engine And Engine Cooling
AFTER THE VEHICLE WAS TAKEN FOR AN OIL CHANGE ENGINE BEGAN TO MAKE A LOUD KNOCKING AND TICKING NOISE UNTIL VEHICLE WARMED UP. MANUFACTURER HAS RECOGNIZED THE PROBLEM ,AND SAID THAT IT WAS CURRENTLY UNDER INVESTIGATION, BUT IT WAS NORMAL. DEFECT WAS IN THE PISTONS.*AK
NHTSA ODI #883894
Mileage unknown · Mar 12, 2001
Electrical SystemEngine And Engine CoolingEquipment
THE VEHICLE EXPERIENCED EXCESSIVE BRAKE SHIMMY DUE TO WARPED ROTORS, ALSO THE FRONT BRAKE PADS HAVE UNEVEN WEAR. NLM
NHTSA ODI #560347
Mileage unknown · Mar 5, 2001
Engine And Engine CoolingFuel System, OtherService Brakes, Hydraulic
REPLACED ROTORS AND PADS10/26/2000 AND02/09/2001.REPLACED FUEL TANK SENDING UNIT 03/02/2001 REPLACING PISTONS IN ENGINE 03/05/2001
NHTSA ODI #741953
Mileage unknown · Mar 1, 2001
Engine And Engine Cooling
WHEN IN ON POSITION THERE IS A KNOCKING NOISE COMING FROM ENGINE COMPARTMENT. PLEASE PROVIDE MORE INFORMATION.*AK
NHTSA ODI #881815
Mileage unknown · Feb 27, 2001
Engine And Engine CoolingService Brakes, Hydraulic
ENGINE MAKES A KNOCKING NOISE. DEALERR HAS CHECKED AND SAID IT MAY BE AIR CONDITIONER COMPRESSOR. *AK ENGINE WAS REPLACED, BRAKES MAKE NOISE. FIRESTONE AFFINITY TIRES MAKE NOISE IN THE FRONT, 15 INCH. *SLC
NHTSA ODI #881579
Mileage unknown · Feb 23, 2001
Engine And Engine CoolingService Brakes, Hydraulic
IN BOTH FAILURES THE SERVICE SUPPORT WAS NOT IN EXCISTING,OR VERY INSULTING,BOTH PROBLEMS HAVE INJURY OR DEATH POSSIBILITYS,ROTOR WARRANTY ONLY 12.000 MILES,BUT THE PROBLEM IS A DEFECT WHICH IS IN ALL MODELS STARTING IN 1998 TILL NOW.IT IS NOT ACCEPTABLE,EVERY 7000 MILES NEW ROTORS OR DIE?? ENGINE LOSING POWER AT HIGH SPEED AND …
Read full complaint
IN BOTH FAILURES THE SERVICE SUPPORT WAS NOT IN EXCISTING,OR VERY INSULTING,BOTH PROBLEMS HAVE INJURY OR DEATH POSSIBILITYS,ROTOR WARRANTY ONLY 12.000 MILES,BUT THE PROBLEM IS A DEFECT WHICH IS IN ALL MODELS STARTING IN 1998 TILL NOW.IT IS NOT ACCEPTABLE,EVERY 7000 MILES NEW ROTORS OR DIE?? ENGINE LOSING POWER AT HIGH SPEED AND GROUDED FREEWAY,NO POWER STEERING OR BRAKES,NO WARNING. DEALER TELLS ME THERE ARE NO CODES AND IT RUNS WELL,AFTER DEALER TOLD WIFE TO REMOVE VEHICLE,18 MILES LATER ,CAR IS STUCK AGAIN,CHEVROLET ASSISTANT SERVICE SAID PERHAPS WIFE CAN PUSH THE CAR TO THE RIGHT.MUST WE TOLERATE THIS,AND A SALES PERSON KNOWS ABOUT THE BULLITINS,AND WILL SAY THAT THERE IS NO ROTOR PROBLEM,BRAND NEW VEHICLE,NEVER MISS WORK ,LOSING JOB ,HOME AND WIFE BECAUSE OF NO ERROR CODES.SO MUCH FOR EMPTY PROMISES.SERVICE MANAGER DONT CARE IF YOU DIE OR LIVE ,DEALER HAS HIS 22.000.00 AND TELLS YOU TO REMOVE YOUR JUNK.CHEVYS IMAGE IS CLOUDED AND NOT HONEST. *AK
NHTSA ODI #741368
Mileage unknown · Jan 26, 2001
Engine And Engine CoolingService Brakes, Hydraulic
WHILE DRIVING THERE IS A NOISE WHEN BRAKING WHICH MAY INDICATE A PROBLEM WITH BRAKING SYSTEM. ALSO A NOISE COMING FROM ENGINE. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #879091
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Oct 29, 1999
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN THE TANK IS MORE THAN HALF FULL.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE02066 · Engine Stall Due To Fuel Starvation
Opened Sep 6, 2002 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other; Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
PE02064 · Turn Signal Failure
Opened Aug 22, 2002 · Closed Dec 23, 2002
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:hazard Flashing Warning Lights:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
SQ00004 · Accelerator Cable Detaches From Throttle
Opened Feb 2, 2000 · Closed Jan 19, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration