NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
58 reportsClear category filter40,000 miles · Oct 20, 2010
Electrical SystemExterior LightingFuel System, Gasoline
TL*THE CONTACT OWNS A 1999 CHEVROLET MALIBU. THE CONTACT WAS INFORMED BY ANOTHER MOTORIST THAT HER BRAKE LIGHTS WERE NOT FUNCTIONING. THE CONTACT REPLACED THE BRAKE LIGHTS HERSELF. THE FAILURE OCCURRED AT LEAST FIVE TIMES A YEAR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT A MECHANISM WITHIN…
Read full complaint
TL*THE CONTACT OWNS A 1999 CHEVROLET MALIBU. THE CONTACT WAS INFORMED BY ANOTHER MOTORIST THAT HER BRAKE LIGHTS WERE NOT FUNCTIONING. THE CONTACT REPLACED THE BRAKE LIGHTS HERSELF. THE FAILURE OCCURRED AT LEAST FIVE TIMES A YEAR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT A MECHANISM WITHIN THE BRAKE LIGHTS NEEDED TO BE REPLACED; THE VEHICLE WAS REPAIRED BUT THE FAILURE CONTINUED. ADDITIONALLY, THE CONTACT STATED THAT SHE EXPERIENCED DIFFICULTY STARTING THE VEHICLE. WHEN SHE TURNED THE KEY IN THE IGNITION, IT TOOK APPROXIMATELY 15 MINUTES FOR THE VEHICLE TO START. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED FOR THE PROBLEM. THE CONTACT ALSO NOTICED THAT FUEL WOULD SPILL OUT OF THE TANK WHEN THE VEHICLE WAS BEING FUELED. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 114,000.
NHTSA ODI #10361373
109,000 miles · Jun 19, 2010
Exterior Lighting
THE TURN SIGNALS WORK ONLY ONCE IN A WHILE, MORE OFTEN THEY DO NOT WORK. THE VEHICLE WAS PURCHASED IN 12/2009, THE PROBLEM BEGAN LATER IN 12/2009. WITH OUR EXTENDED WARRANTY WE TOOK IT BACK TO WHERE WE PURCHASED IT, AFTER 8 HOURS, THEY SAID THEY THINK THEY FOUND THE PROBLEM AND CORRECTED IT. TWO WEEKS LATER, THE SAME PROBLEM …
Read full complaint
THE TURN SIGNALS WORK ONLY ONCE IN A WHILE, MORE OFTEN THEY DO NOT WORK. THE VEHICLE WAS PURCHASED IN 12/2009, THE PROBLEM BEGAN LATER IN 12/2009. WITH OUR EXTENDED WARRANTY WE TOOK IT BACK TO WHERE WE PURCHASED IT, AFTER 8 HOURS, THEY SAID THEY THINK THEY FOUND THE PROBLEM AND CORRECTED IT. TWO WEEKS LATER, THE SAME PROBLEM BEGAN AGAIN AND IS STILL A PROBLEM. IT IS ILLEGAL TO DRIVE WITHOUT TURN SIGNALS AND EXTREMELY DANGEROUS. WE WERE NOT TOLD OF THE PART PUT ONTO THE CAR, BUT WE DID SEE THEM TAKE A PART OFF OF ANOTHER CAR TO PUT INTO OURS. *TR
NHTSA ODI #10339121
90,000 miles · Sep 7, 2009
Exterior Lighting
SOMETIMES THE BRAKE AND TAIL LIGHTS WONT WORK. *TR
NHTSA ODI #10283051
Mileage unknown · Dec 31, 2008
Exterior Lighting
1999 MALIBU LS- (R) BRAKE LIGHT KEEPS GOING OUT- HAVE HAD TO REPLACE BULBS EVERY OTHER MONTH FOR THE LAST 3 YEARS. HAVE HAD WORK DONE IN 2005,2006 REPLACE HOUSING AND 2008 REPLACE SOCKET PLATE. *TR
NHTSA ODI #10253379
Mileage unknown · Sep 25, 2008
Engine And Engine CoolingExterior Lighting
THE HEADLIGHTS GET CONDENSATION BEHIND THEM AND I HAVE SEEN SEVERAL COMPLAINTS ON INTERNET. ALSO THE COOLANT TANK NEEDS TO BE REFILLED MORE THAN AVERAGE. *TR
NHTSA ODI #10243436
98,000 miles · Aug 16, 2008
Exterior Lighting
THIS IS THE 2ND CHEVY THAT I'VE OWNED WHOSE BRAKE LIGHTS FAIL (CENTER BRAKE LIGHT CONTINUES TO WORK) TO ILLUMINATE DUE TO A FAULTY TURN SIGNAL SWITCH. ALTHOUGH THE TURN SIGNAL, CRUISE CONTROL, WIPER CONTROL, ETC. WORK FINE, THERE IS SOMETHING INTERNAL TO THIS TURN SIGNAL/MULTI-FUNCTION SWITCH THAT SUDDENLY CAUSES THE LEFT AND RI…
Read full complaint
THIS IS THE 2ND CHEVY THAT I'VE OWNED WHOSE BRAKE LIGHTS FAIL (CENTER BRAKE LIGHT CONTINUES TO WORK) TO ILLUMINATE DUE TO A FAULTY TURN SIGNAL SWITCH. ALTHOUGH THE TURN SIGNAL, CRUISE CONTROL, WIPER CONTROL, ETC. WORK FINE, THERE IS SOMETHING INTERNAL TO THIS TURN SIGNAL/MULTI-FUNCTION SWITCH THAT SUDDENLY CAUSES THE LEFT AND RIGHT BRAKE LIGHTS TO NOT ILLUMINATE. THE DRIVER IS UNAWARE OF THE PROBLEM UNTIL ANOTHER DRIVER ON THE ROAD BRINGS IT TO THEIR ATTENTION. THERE ARE NUMEROUS GM CAR OWNERS WHO COMPLAIN OF THE SAME PROBLEM ON THE INTERNET, YET GM HAS NOT OFFERED TO REPLACE THIS SWITCH FOR THE OWNER. THE DEALER WANTS $170 FOR THE PART AND CHARGE 2 HOURS LABOR AT $90/HOUR FOR A WHOPPING COST OF $350 + TAX AND ONLY OFFER A 12-MONTH WARRANTY FOR THEIR PARTS/LABOR. TO ME, THIS IS A VERY UNSAFE CONDITION THAT GM FAILS TO RECOGNIZE BY RECALLING OR SIMPLY REPAIRING FREE OF CHARGE. APPARENTLY, GM SAYS THE LEFT/RIGHT BRAKE LIGHT SWITCH IS WIRED THROUGH THE MULTI-FUNCTION/TURN SIGNAL SWITCH SO THE CRUISE CONTROL WILL CANCEL ONCE THE BRAKE PEDAL IS PRESSED, BUT THAT FEATURE STILL WORKS EVEN THOUGH THE BRAKE LIGHTS DON'T ILLUMINATE! OTHER CAR MANUFACTURERS' CRUISE CONTROL SWITCHES OFF WHEN THE BRAKE IS PRESSED, YET THEY DON'T HAVE THE ISSUE OF THE MULTI-FUNCTION/TURN SIGNAL SWITCH FAILING INTERNALLY CAUSING THE LEFT/RIGHT BRAKE LIGHT TO NOT ILLUMINATE. PLEASE DO WHATEVER YOU CAN TO GET GM TO REPLACE THIS POORLY DESIGNED SWITCH, FREE OF CHARGE TO THE CUSTOMER. IT SHOULD BE NOTED THAT BOTH THIS 99 MALIBU AND 96 MONTE CARLO WERE BOTH VERY WELL CARED FOR BY US AND STILL, THESE BRAKE LIGHTS FAILED WITH LESS THAN 100K MILES. THANK YOU. RESPECTFULLY, SCOTT STEFFES *TR
NHTSA ODI #10238476
125,000 miles · Mar 23, 2008
Exterior Lighting
TURN SIGNALS AND HAZARD LIGHTS WORK WHEN THEY WANT TO, WHICH BEGAN LAST YEAR 07/07. I REPLACED FUSES TO SEE IF THIS WAS THE PROBLEM. IT CONTINUES TO HAPPEN. AFTER ALMOST BEING REAR-ENDED WITH MY INFANT SON IN A CARSEAT THE BACK SEAT AS MY TURN SIGNALS FLASHED TWICE AND FAILED I FOUND OUT LATER THERE HAD BEEN A RECALL ON THE HAZA…
Read full complaint
TURN SIGNALS AND HAZARD LIGHTS WORK WHEN THEY WANT TO, WHICH BEGAN LAST YEAR 07/07. I REPLACED FUSES TO SEE IF THIS WAS THE PROBLEM. IT CONTINUES TO HAPPEN. AFTER ALMOST BEING REAR-ENDED WITH MY INFANT SON IN A CARSEAT THE BACK SEAT AS MY TURN SIGNALS FLASHED TWICE AND FAILED I FOUND OUT LATER THERE HAD BEEN A RECALL ON THE HAZARD/TURN SWITCH ON THE 2000 MODELS OF MALIBU AND NOT THE 99'S. *TR
NHTSA ODI #10222082
148,000 miles · Feb 11, 2008
Exterior Lighting
NO PRIOR CRASHES OR PROBLEMS BRAKE LIGHTS STOPPED WORKING UNABLE TO FIND SHORT IN SYSTEM TO THE POINT THAT THE HOSING ON THE REAR BRAKE LIGHTS ARE MELTING AROUND BULBS RUNNING LIGHTS WORK STILL YET NO REAR BRAKE LIGHTS ON DRIVERS SIDE OUTER AND PASSENGER SIDE INNER. *TR
NHTSA ODI #10217726
92,000 miles · Aug 20, 2007
EquipmentExterior Lighting
TL*THE CONTACT OWNS A 1999 CHEVROLET MALIBU. SINCE 2000 THE BACK UP LIGHTS FAILED. THE DEALER REPLACED THE INTERNAL BRIGHT LIGHTS IN 2000 AND 2002. THE AIR CONDITIONER ALSO COMES ON AND OFF WITHOUT WARNING. THE FAILURE OCCURS EVERY TIME THE CONTACT ATTEMPTS TO BACK UP OR USE THE AIR CONDITIONER. AFTER PERFORMING AN ELECTRICAL TE…
Read full complaint
TL*THE CONTACT OWNS A 1999 CHEVROLET MALIBU. SINCE 2000 THE BACK UP LIGHTS FAILED. THE DEALER REPLACED THE INTERNAL BRIGHT LIGHTS IN 2000 AND 2002. THE AIR CONDITIONER ALSO COMES ON AND OFF WITHOUT WARNING. THE FAILURE OCCURS EVERY TIME THE CONTACT ATTEMPTS TO BACK UP OR USE THE AIR CONDITIONER. AFTER PERFORMING AN ELECTRICAL TEST, THE DEALER REPLACED THE AIR CONDITIONER CONTROL ASSEMBLY AND THE AC CONTROL HEAD ON TWO OCCASIONS. THE CONTACT IS AWARE OF THE SAFETY RECALL FOR THE FUEL PRESSURE REGULATOR. THE CURRENT MILEAGE WAS 105000 AND THE APPROXIMATE FAILURE MILEAGE WAS 92000.
NHTSA ODI #10200304
92,000 miles · May 8, 2007
Exterior Lighting
TL*THE CONTACT OWNS A 1999 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE'S TURN SIGNALS AND HAZARD LIGHTS HAVE WORKED SPORADICALLY SINCE OCTOBER OF 2006. BEGINNING IN MAY OF 2007, THE LIGHTS DO NOT ILLUMINATE AT ALL. THE CURRENT MILEAGE IS 100,100 AND FAILURE MILEAGE WAS 92,000.
NHTSA ODI #10190119
Official recalls
1Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03021 · Front Suspension Coil Spring Fracture
Opened Nov 4, 2003 · Closed Oct 19, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Additional source detail variants (3)
Suspension:front
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
PE03031 · Front Suspension Coil Spring Fracture
Opened Jul 14, 2003 · Closed Nov 4, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Additional source detail variants (2)
Suspension:front
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
DP02008 · Engine Coolant Boils Over
Opened Sep 3, 2002 · Closed Sep 24, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
Illustration