TL* THE CONTACT OWNED A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT THE DRIVER LOST CONTROL OF THE VEHICLE, DROVE DOWN AN EMBANKMENT, AND CRASHED INTO A CREEK. DURING THE CRASH, THE FRONT END OF THE VEHICLE SUSTAINED SIGNIFICANT DAMAGE. THE AIR BAGS DID NOT DEPLOY AND NO INJURIES WERE REPORTED. THE VEHICLE WAS DESTROY…
Read full complaint
TL* THE CONTACT OWNED A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT THE DRIVER LOST CONTROL OF THE VEHICLE, DROVE DOWN AN EMBANKMENT, AND CRASHED INTO A CREEK. DURING THE CRASH, THE FRONT END OF THE VEHICLE SUSTAINED SIGNIFICANT DAMAGE. THE AIR BAGS DID NOT DEPLOY AND NO INJURIES WERE REPORTED. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 195,000.
NHTSA ODI #10789884
Mileage unknown · Aug 10, 2015
Air BagsCrashInjury
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED AND COMING TO A STOP, ANOTHER VEHICLE REAR ENDED THE CONTACT'S VEHICLE WHILE DRIVING AT APPROXIMATELY 60 TO 70 MPH. THE AIR BAGS DID NO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED MINOR INJURIES AND THE OT…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED AND COMING TO A STOP, ANOTHER VEHICLE REAR ENDED THE CONTACT'S VEHICLE WHILE DRIVING AT APPROXIMATELY 60 TO 70 MPH. THE AIR BAGS DID NO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED MINOR INJURIES AND THE OTHER DRIVER SUSTAINED UNKNOWN INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10747412
Mileage unknown · Jan 14, 2009
Air BagsCrashInjury
AIR BAGS DID NOT DEPLOY IN A 2004 CHEVORLET MALIBU IN 2 ACCIDENTS. THE FIRST ACCIDENT WAS ON 8/29/05 IN WHICH I WAS T-BONED BY AN SUV THAT RAN A STOP SIGN IN WHICH IN COURT THE SUV WAS FOUND GUILTY. THE SECOND ACCIDENT WAS ON 1/8/09 IN WHICH MY DAUGHTER GABRIELLE THREADGILL SLID INTO THE BACK OF A HUGE VAN DUE TO WEATHER CONDITI…
Read full complaint
AIR BAGS DID NOT DEPLOY IN A 2004 CHEVORLET MALIBU IN 2 ACCIDENTS. THE FIRST ACCIDENT WAS ON 8/29/05 IN WHICH I WAS T-BONED BY AN SUV THAT RAN A STOP SIGN IN WHICH IN COURT THE SUV WAS FOUND GUILTY. THE SECOND ACCIDENT WAS ON 1/8/09 IN WHICH MY DAUGHTER GABRIELLE THREADGILL SLID INTO THE BACK OF A HUGE VAN DUE TO WEATHER CONDITIONS AND SLID INTO THE VAN GOING AT LEAST 30 MILES PER HOUR, NO CITATION WAS GIVEN DUE TO THE ICE. MY DAUGHTER AND I WERE BOTH INJURED IN BOTH ACCIDENTS DUE TO THE AIR BAGS NOT DEPLOYING. *TR
NHTSA ODI #10255018
Mileage unknown · Dec 24, 2005
Air BagsSeat BeltsService Brakes, HydraulicCrashInjury
I AM A FORMER STATE LAW ENFORCEMENT OFFICER WITH EXTENSIVE SAFE DRIVING TECHNIQUES FOR OVER TWENTY YEARS. I NOW WORK WITH UPS AND HAVE EXTENSIVE SAFE HABITS WITH THIS CORPORATION. TODAY WAS A CLEAR, COOL AND CRISP DAY WITH NO WATER OR OIL SPOTS ON THE HIGHWAY. MY 15 MONTH OLD WAS IN HER CHILD RESTRAINT SEAT IN THE REAR A…
Read full complaint
I AM A FORMER STATE LAW ENFORCEMENT OFFICER WITH EXTENSIVE SAFE DRIVING TECHNIQUES FOR OVER TWENTY YEARS. I NOW WORK WITH UPS AND HAVE EXTENSIVE SAFE HABITS WITH THIS CORPORATION. TODAY WAS A CLEAR, COOL AND CRISP DAY WITH NO WATER OR OIL SPOTS ON THE HIGHWAY. MY 15 MONTH OLD WAS IN HER CHILD RESTRAINT SEAT IN THE REAR AND I WAS IN THE DRIVER SEAT. WHILE COMING TO A STOP MY BRAKES LOCKED UP AND THE ABS DID NOT WORK. THE SEAT BELT I WAS WEARING DID NOT WORK PROPERLY CAUSING ME TO BREAK MY GLASSES AS MY HEAD HIT THE STEERING WHEEL. THE AIRBAGS FAILED TO WORK ALSO. *JB THERE WAS EXTENSIVE DAMAGE TO MY VEHICLE WHICH WAS CAUSED BY THE IMPACT OF RUNNING INTO THE REAR OF A DUMP TRUCK. HAD THE ABS AND SEAT BELT WORKED PROPERLY THE ACCIDENT COULD HAVE BEEN AVOIDED BY MANEUVERING MY VEHICLE AROUND THE DUMP TRUCK.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA04018 · Loss Of Electric Power Steering
Opened Jul 1, 2004 · Closed May 10, 2005
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: - GM ISSUED CUSTOMER SATISFACTION CAMPAIGN (CSC) 04050A INDECEMBER 2004 TO ADDRESS THE ALLEGED DEFECT IN APPROXIMATELY58,700 SUBJECT VEHICLES, ENCOMPASSING AT LEAST 97 PERCENT OF THECOMPLAINT AND WARRANTY CLAIMS POPULATION.VEHICLES OUTSIDE THECSC 04050A POPULATION CONTAIN A NEWLY DESIGNED TORQUE ANDPOSITION SENSOR AND HAVE EXPERIENCED A RELATIVELY LOW COMPLAINTRATE.THIS CUSTOMER SATISFACTION CAMPAIGN PRESENTLY HAS ACOMPLETION RATE OF 52%. - THE IMPACT ON THE DRIVER?S ABILITY TO CONTROL THESE RELATIVELYSMALL AND LIGHT VEHICLES WAS LIMITED.VRTC TEST ENGINEERS WEREUNABLE TO INDUCE A FAILURE MODE THAT WOULD CAUSE THE EPS TOSUBSTANTIALLY LIMIT THE DRIVER?S ABILITY TO TURN THE VEHICLE IN APARTICULAR DIRECTION OR TO PROVIDE THE DRIVER WITH UNINTENDEDPOWER ASSISTANCE.- THERE IS NO RISK OF FIRE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED BY THE CIRCUMSTANCES.(FOR FURTHER DETAILS SEE ATTACHED ENGINEERING ANALYSIS (EA04-018)CLOSING REPORT.)
Additional source detail variants (2)
Steering:electric Power Assist System
IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: - GM ISSUED CUSTOMER SATISFACTION CAMPAIGN (CSC) 04050A INDECEMBER 2004 TO ADDRESS THE ALLEGED DEFECT IN APPROXIMATELY58,700 SUBJECT VEHICLES, ENCOMPASSING AT LEAST 97 PERCENT OF THECOMPLAINT AND WARRANTY CLAIMS POPULATION.VEHICLES OUTSIDE THECSC 04050A POPULATION CONTAIN A NEWLY DESIGNED TORQUE ANDPOSITION SENSOR AND HAVE EXPERIENCED A RELATIVELY LOW COMPLAINTRATE.THIS CUSTOMER SATISFACTION CAMPAIGN PRESENTLY HAS ACOMPLETION RATE OF 52%. - THE IMPACT ON THE DRIVER?S ABILITY TO CONTROL THESE RELATIVELYSMALL AND LIGHT VEHICLES WAS LIMITED.VRTC TEST ENGINEERS WEREUNABLE TO INDUCE A FAILURE MODE THAT WOULD CAUSE THE EPS TOSUBSTANTIALLY LIMIT THE DRIVER?S ABILITY TO TURN THE VEHICLE IN APARTICULAR DIRECTION OR TO PROVIDE THE DRIVER WITH UNINTENDEDPOWER ASSISTANCE.- THERE IS NO RISK OF FIRE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED BY THE CIRCUMSTANCES.(FOR FURTHER DETAILS SEE ATTACHED ENGINEERING ANALYSIS (EA04-018)CLOSING REPORT.)
Steering
IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: - GM ISSUED CUSTOMER SATISFACTION CAMPAIGN (CSC) 04050A INDECEMBER 2004 TO ADDRESS THE ALLEGED DEFECT IN APPROXIMATELY58,700 SUBJECT VEHICLES, ENCOMPASSING AT LEAST 97 PERCENT OF THECOMPLAINT AND WARRANTY CLAIMS POPULATION.VEHICLES OUTSIDE THECSC 04050A POPULATION CONTAIN A NEWLY DESIGNED TORQUE ANDPOSITION SENSOR AND HAVE EXPERIENCED A RELATIVELY LOW COMPLAINTRATE.THIS CUSTOMER SATISFACTION CAMPAIGN PRESENTLY HAS ACOMPLETION RATE OF 52%. - THE IMPACT ON THE DRIVER?S ABILITY TO CONTROL THESE RELATIVELYSMALL AND LIGHT VEHICLES WAS LIMITED.VRTC TEST ENGINEERS WEREUNABLE TO INDUCE A FAILURE MODE THAT WOULD CAUSE THE EPS TOSUBSTANTIALLY LIMIT THE DRIVER?S ABILITY TO TURN THE VEHICLE IN APARTICULAR DIRECTION OR TO PROVIDE THE DRIVER WITH UNINTENDEDPOWER ASSISTANCE.- THERE IS NO RISK OF FIRE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED BY THE CIRCUMSTANCES.(FOR FURTHER DETAILS SEE ATTACHED ENGINEERING ANALYSIS (EA04-018)CLOSING REPORT.)
2004 Chevrolet Malibu Classic Problems, Complaints & Recalls | Skip That Year
Illustration