IllustrationRECENTLY, I HAVE HAD 3 OR 4 INSTANCES WHERE THE LIGHTS ON MY 2003 IMPALA WENT COMPLETELY OUT WHILE I WAS DRIVING. I HAD SWITCHED THE LIGHTS BETWEEN HIGH AND LOW BEAM. THIS IS RATHER CONCERTING. MY FRIEND REPORTED THAT HER 2002 IMPALA HAS ALSO RECENTLY BEGAN DOING THE SAME THING. MY LIMITED RESEARCH LED ME TO THIS SITE. *NM
2003 Chevrolet Impala
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Impala years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
670–25K
6625–50K
9150–75K
8175–100K
121100–150K
87150K+
513 reports with mileage · 181 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 264 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 88 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
32 crash reports32 fire reports23 injury reports
What owners actually said
694 reportsDT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS AT NIGHT WITH THE LOW BEAM HEADLIGHTS ENGAGED, THE HEADLIGHTS INTERMITTENTLY FAILED TO ILLUMINATE. THE VEHICLE WAS DRIVEN TO THE DEALER WHO REPLACED THE HEADLIGHT SWITCH. UPDATED 12/12/2006 - ON THREE SEPARATE OCCASIONS WHILE THE CONSUMER WAS DRIVING AT NIGHT THE HEADLIGHT …
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS AT NIGHT WITH THE LOW BEAM HEADLIGHTS ENGAGED, THE HEADLIGHTS INTERMITTENTLY FAILED TO ILLUMINATE. THE VEHICLE WAS DRIVEN TO THE DEALER WHO REPLACED THE HEADLIGHT SWITCH. UPDATED 12/12/2006 - ON THREE SEPARATE OCCASIONS WHILE THE CONSUMER WAS DRIVING AT NIGHT THE HEADLIGHT WENT OUT WHEN SWITCHED FROM HIGH BEAM TO LOW BEAM. THE LIGHTS DID NOT COME BACK ON UNTIL THE CONSUMER BEGUN TO JIGGLE THE MULTIFUNCTION SWITCH. THE POWER WINDOWS WOULD NOT GO DOWN. THE DEALER REPLACED THE MASTER WINDOW SWITCH. *NM
MY 2003 IMPALA STARTED WITH A SLOW LOOSE OF COOLANT. EVERY WEEK OR SO WOULD HAVE TO ADD TO THE OVERFLOW, BUT NEVER SAW A LEAK. WAS OVER-HEATING TOO. EVENTUALLY IT WOULD HAVE A TICKING FROM THE ENGINE AREA WHEN STARTING CAR. IT WASN'T ALL THE TIME THOUGH. I NOTICED THAT THERE WAS OIL ON MY DRIVEWAY AND THE OIL WAS ABOUT A 1/2 QU…
Read full complaint
MY 2003 IMPALA STARTED WITH A SLOW LOOSE OF COOLANT. EVERY WEEK OR SO WOULD HAVE TO ADD TO THE OVERFLOW, BUT NEVER SAW A LEAK. WAS OVER-HEATING TOO. EVENTUALLY IT WOULD HAVE A TICKING FROM THE ENGINE AREA WHEN STARTING CAR. IT WASN'T ALL THE TIME THOUGH. I NOTICED THAT THERE WAS OIL ON MY DRIVEWAY AND THE OIL WAS ABOUT A 1/2 QUART LOW. CHECKED AGAIN IN COUPLE DAYS AND NEEDED TO ADD A QUART BECAUSE LIGHT CAME ON. TWO DAYS LATER LIGHT CAME ON AGAIN. TOOK IT TO A CHEVY DEALERSHIP WHO INFORMED ME THAT THE GASKET NEEDED REPLACING IN THE INTAKE MANIFOLD BECAUSE COOLANT MIXED WITH OIL. ALSO NEEDED COOLANT FLUSH, AND OIL CHANGE AND ANOTHER GASKET. THEY TOLD ME THERE WAS LOTS OF SLUDGE IN ENGINE AND COULD CAUSE MORE PROBLEMS IN THE FUTURE. THE CAR HAS 68,000 MILES ON IT AND IT COST ME OVER $1300 TO REPAIR. WHAT A SHOCK TO THE POCKET BOOK. *NM
HEADLIGHTS GO OFF WHEN SWITCHING BETWEEN HIGH BEAM AND LOW BEAM. *NM
DT*: THE CONTACT STATED THE ABS LIGHT ILLUMINATED AND AT VARIOUS SPEEDS, THE BRAKES LOCKED UP CAUSING THE VEHICLE TO SKID. THE DEALERSHIP REPLACED MULTIPLE UNKNOWN COMPONENTS, BUT THE PROBLEM PERSISTED.
I HAVE 34000 MILES ON MY VEHICLE AND HAVE TO TAKE IT IN SOON AS THE BRAKES ARE AGAIN PULSATING. THIS WILL BE THE 6TH TIME I HAVE HAD TO HAVE THE BRAKES REPLACED. THERE IS A CONSTANT RUBBING SOUND WHICH I HAVE BEEN TOLD BY THE DEALER IS A "NORMAL" SOUND IN AN IMPALA. THERE IS NOTHING "NORMAL" ABOUT THIS SOUND. 12/11/03 IS THE …
Read full complaint
I HAVE 34000 MILES ON MY VEHICLE AND HAVE TO TAKE IT IN SOON AS THE BRAKES ARE AGAIN PULSATING. THIS WILL BE THE 6TH TIME I HAVE HAD TO HAVE THE BRAKES REPLACED. THERE IS A CONSTANT RUBBING SOUND WHICH I HAVE BEEN TOLD BY THE DEALER IS A "NORMAL" SOUND IN AN IMPALA. THERE IS NOTHING "NORMAL" ABOUT THIS SOUND. 12/11/03 IS THE FIRST TIME I REPORTED A BRAKE PROBLEM AND HAVE CONTINUED TO DO SO UNTIL THE PRESENT.
THE CAR STARTING SMELLING LIKE ANTI-FREEZE AND THEN A BIG PUDDLE APPEARED IN THE FRONT PASSENGER SIDE OF THE CAR. THE ONLY THING WE DID WAS DRIVE FROM NAMPA, ID TO BILLINGS, MT, WHICH WE HAVE DONE FOUR TIMES BEFORE. IT HAS BEEN DETERMINED THAT THE HEATER CORE NEEDS TO BE REPLACED. THE CAR HAS 68,000 MILES ON IT RIGHT NOW AS OF J…
Read full complaint
THE CAR STARTING SMELLING LIKE ANTI-FREEZE AND THEN A BIG PUDDLE APPEARED IN THE FRONT PASSENGER SIDE OF THE CAR. THE ONLY THING WE DID WAS DRIVE FROM NAMPA, ID TO BILLINGS, MT, WHICH WE HAVE DONE FOUR TIMES BEFORE. IT HAS BEEN DETERMINED THAT THE HEATER CORE NEEDS TO BE REPLACED. THE CAR HAS 68,000 MILES ON IT RIGHT NOW AS OF JULY 28TH, 2006. IN NOVEMEBER OF 2003, THREE MONTHS AFTER I BOUGHT THE CAR, THE HEATER CORE WAS REPLACED AT 31,000 BY THE LITHIA DEALERSHIP IN HELENA, MT. THE INTAKE MANIFOLD WAS ALSO REPLACED IN MAY 2006 BECAUSE THE CAR WAS OVERHEATING AND MAKING A TICKING NOISE. *JB
DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON NORMAL ROAD CONDITIONS THE BRAKES WERE NOT RESPONDING ADEQUATELY. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO DETERMINED THE FOUR ROTORS HAD TO BE RESURFACED, HOWEVER THE PADS WERE STILL IN GOOD CONDITIONS. THE CONTACT EXPRESSED CONCERN BECAUSE THE VEHICLE HAS ONLY 14950 MILES.
DT*: THE CONTACT STATED THE ENGINE AND ALL THE ELECTRICAL SYSTEM TURNED OFF WHILE DRIVING 40 MPH. THE IGNITION WAS TURNED ON RIGHT AFTER, HOWEVER THE VEHICLE STALLED AFTER FIVE MINUTES WHILE DRIVING 10 MPH. AN INDEPENDENT MECHANIC DETERMINED THAT THE TOGGLE SWITCH OF THE PASSLOCK SECURITY SYSTEM HAD BECOME DEFECTIVE. UPDATED 8/…
Read full complaint
DT*: THE CONTACT STATED THE ENGINE AND ALL THE ELECTRICAL SYSTEM TURNED OFF WHILE DRIVING 40 MPH. THE IGNITION WAS TURNED ON RIGHT AFTER, HOWEVER THE VEHICLE STALLED AFTER FIVE MINUTES WHILE DRIVING 10 MPH. AN INDEPENDENT MECHANIC DETERMINED THAT THE TOGGLE SWITCH OF THE PASSLOCK SECURITY SYSTEM HAD BECOME DEFECTIVE. UPDATED 8/1/2006 - *NM
IGNITION - KEY WOULD NOT TURN. UNABLE TO MOVE CAR. WARM, SUNNY DAY AT A LOCAL STORE PARKING LOT. CAR HAD TO BE TOWED TO DEALERSHIP. CAUSE: FROZEN LOCK CYLINDER. DEALERSHIP HAD CAR FOR TWO (2) DAYS TO ORDER PART, REPROGRAM AND REPLACED. SAFETY WAS A ISSUE. COST TO REPLACE WAS $600. *JB
Official recalls
515V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
03V051000 · Air Bags:frontal:driver Side:inflator Module
Feb 14, 2003
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Remedy: DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.
02V222000 · Air Bags:frontal
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.