NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
54 reportsClear category filter100 miles · Aug 13, 2006
Service Brakes, Hydraulic
I HAVE 34000 MILES ON MY VEHICLE AND HAVE TO TAKE IT IN SOON AS THE BRAKES ARE AGAIN PULSATING. THIS WILL BE THE 6TH TIME I HAVE HAD TO HAVE THE BRAKES REPLACED. THERE IS A CONSTANT RUBBING SOUND WHICH I HAVE BEEN TOLD BY THE DEALER IS A "NORMAL" SOUND IN AN IMPALA. THERE IS NOTHING "NORMAL" ABOUT THIS SOUND. 12/11/03 IS THE …
Read full complaint
I HAVE 34000 MILES ON MY VEHICLE AND HAVE TO TAKE IT IN SOON AS THE BRAKES ARE AGAIN PULSATING. THIS WILL BE THE 6TH TIME I HAVE HAD TO HAVE THE BRAKES REPLACED. THERE IS A CONSTANT RUBBING SOUND WHICH I HAVE BEEN TOLD BY THE DEALER IS A "NORMAL" SOUND IN AN IMPALA. THERE IS NOTHING "NORMAL" ABOUT THIS SOUND. 12/11/03 IS THE FIRST TIME I REPORTED A BRAKE PROBLEM AND HAVE CONTINUED TO DO SO UNTIL THE PRESENT.
NHTSA ODI #10165352
14,954 miles · Jul 27, 2006
Service Brakes, Hydraulic
DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON NORMAL ROAD CONDITIONS THE BRAKES WERE NOT RESPONDING ADEQUATELY. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO DETERMINED THE FOUR ROTORS HAD TO BE RESURFACED, HOWEVER THE PADS WERE STILL IN GOOD CONDITIONS. THE CONTACT EXPRESSED CONCERN BECAUSE THE VEHICLE HAS ONLY 14950 MILES.
NHTSA ODI #10163734
25,053 miles · Jul 6, 2006
Service Brakes, Hydraulic
DT*: THE CONTACT STATED WHILE THE VEHICLE WAS AT THE SERVICE DEALER FOR AN OIL CHANGE, THE SERVICE TECHNICIAN DETERMINED THAT THE BREAK ROTORS WERE CRACKED. THE BREAK ROTORS AND BREAK PADS WERE REPLACED.
NHTSA ODI #10161661
45,000 miles · May 12, 2006
Service Brakes, Hydraulic
AT ABOUT 45,000 MILES THE BRAKE WARNING TAB STARTED MAKING THE SCRATCHING NOISE WHEN I PUT ON THE BRAKES. TWO DAYS LATER THE CAR WAS IN THE SHOP FOR FRONT BRAKE SERVICE. I WAS EXPECTING JUST PADS WERE NEEDED, BUT NOT THE CASE. I WAS TOLD AND SHOWN THE ROTORS HAD WORN DOWN TOO FAR TO CUT. BOTH FRONT ROTORS WERE BELOW SAFE DEPTH. …
Read full complaint
AT ABOUT 45,000 MILES THE BRAKE WARNING TAB STARTED MAKING THE SCRATCHING NOISE WHEN I PUT ON THE BRAKES. TWO DAYS LATER THE CAR WAS IN THE SHOP FOR FRONT BRAKE SERVICE. I WAS EXPECTING JUST PADS WERE NEEDED, BUT NOT THE CASE. I WAS TOLD AND SHOWN THE ROTORS HAD WORN DOWN TOO FAR TO CUT. BOTH FRONT ROTORS WERE BELOW SAFE DEPTH. I COULD NOT BELIEVE THIS WITH ONLY 45,000 ON THE CAR. THE ROTORS WERE JUNKED AND MY REPAIR BILL WENT TO TWICE AS MUCH. IS THIS AMERICAN QUALITY OR WHAT! OTHER THAN THIS, I HAVE AND DO LIKE MY IMPALA. CHEVY COULD CALL AND MAKE THIS RIGHT WOULD PUT THING 100% RIGHT WITH ME. WILL THEY DO THAT??? JB
NHTSA ODI #10157429
38,000 miles · Jan 4, 2006
Service Brakes, Hydraulic
DT*: THE CONTACT STATED THE REAR ROTORS RUSTED. THIS WAS FIRST NOTICED WHILE CHANGING THE FRONT BRAKES. EVEN THOUGH THE REAR ROTORS WERE RUSTED THE REAR BRAKE PADS WERE FINE. THE MANUFACTURER DETERMINED THE ROTORS MAY HAVE RUSTED DUE TO THE ENVIRONMENT. *AK UPDATED 01/25/06. *JB
NHTSA ODI #10146882
32,000 miles · Dec 30, 2005
Service Brakes, Hydraulic
AT APP. 32,000 MILES I HAD MY BRAKES CHECKED AND NEEDED TO REPLACE 2 ROTORS. THE VEHICLE IS A 2003 IMPALA, NOT DRIVEN IN HEAVY TRAFFIC, THE TERRAIN IS FLAT, MILD WINTERS WITH LITTLE ROAD SALT EXPOSURE. OLD PARTS NOT AVAILABLE. *NM
NHTSA ODI #10146552
27,512 miles · Dec 2, 2005
Service Brakes, Hydraulic
2003 CHEVY IMPALA, BOUGHT NEW. ALL FOUR BRAKES WORE OUT PREMATURELY. WARPED, SCORED ROTORS. CAR STILL UNDER WARRANTY, BUT NOT ROTORS. DEALERSHIP WAS NOTIFIED, BUT WAS UNABLE TO RESOLVE THE PROBLEM. THEY SAID MY DRIVING HABITS AND THE CLIMATE WERE TO BLAME. I'VE BEEN DRIVING GM CARS IN THIS AREA FOR 40 YEARS, AND NEVER HA…
Read full complaint
2003 CHEVY IMPALA, BOUGHT NEW. ALL FOUR BRAKES WORE OUT PREMATURELY. WARPED, SCORED ROTORS. CAR STILL UNDER WARRANTY, BUT NOT ROTORS. DEALERSHIP WAS NOTIFIED, BUT WAS UNABLE TO RESOLVE THE PROBLEM. THEY SAID MY DRIVING HABITS AND THE CLIMATE WERE TO BLAME. I'VE BEEN DRIVING GM CARS IN THIS AREA FOR 40 YEARS, AND NEVER HAD THIS PROBLEM. CALLED CHEVROLET CUSTOMER CARE CENTER TO REPORT DEFECTIVE PARTS. HAVE PARTS. CLAIM DENIED. I HAD MY OWN MECHANIC REPLACE PARTS WITH HEAVY DUTY ROTORS. LIGHTWEIGHT ROTORS SHOULD NEVER BE STANDARD ON CARS SOLD ON LOTS IN NORTH CONWAY, NH. *JB
NHTSA ODI #10144204
38,600 miles · Oct 5, 2005
Service Brakes, HydraulicCrashInjury
VEHICLE BRAKING SYSTEM MALFUNCTION. REFER TO ODI # 10134740. SYSTEM FAILURE RESULTED IN LOSS OF VEHICLE CONTROL RESULTING IN VEHICLE ACCIDENT RESULTING IN MAJOR VEHICLE DAMAGE TO RIGHT REAR OF VEHICLE FROM PASSENGER DOOR TO THE BUMPER. *JB
NHTSA ODI #10138741
Mileage unknown · Oct 5, 2005
Engine And Engine CoolingService Brakes, Hydraulic
I OWN A 2003 IMPALA I WAS VERY PLEASED WITH MY VEHICLE,EVEN THOUGH I HAVE HAD TO HAVE MY ROTORS AND BRAKES FIXED TWICE STILL PLEASED OVERALL. HOWEVER, ABOUT A MONTH AGO I TOOK MY CAR IN FOR A NORMAL OIL CHANGE AFTER RETURNING HOME, I NOTICED I DIDN'T HAVE ANY ANTI-FREEZE IN MY CAR. I CALLED A SPOKE TO A SERVICE TECH HE INFORME…
Read full complaint
I OWN A 2003 IMPALA I WAS VERY PLEASED WITH MY VEHICLE,EVEN THOUGH I HAVE HAD TO HAVE MY ROTORS AND BRAKES FIXED TWICE STILL PLEASED OVERALL. HOWEVER, ABOUT A MONTH AGO I TOOK MY CAR IN FOR A NORMAL OIL CHANGE AFTER RETURNING HOME, I NOTICED I DIDN'T HAVE ANY ANTI-FREEZE IN MY CAR. I CALLED A SPOKE TO A SERVICE TECH HE INFORMED ME THAT I PROBABLY HAD A LEAK SOMEWHERE. I BROUGHT IT IN HE INFORMED ME THERE WAS A HAIR LINE CRACK IN MY GASKET AND I NEEDED A NEW WATER PUMP. THE COST TO REPAIR IT WOULD BE OVER ONE THOUSAND DOLLARS. WHAT I CANNOT UNDERSTAND WHY DID MY LOW COOLANT INDICATOR LIGHT COME ON. WHY DID I HAVE TO DISCOVER THIS PROBLEM ON MY OWN? AFTER REVIEWING OTHER COMPLAINTS I FIND I AM NOT ALONE WITH HAVING A COOLANT CONCERN. I FEEL THAT THIS SHOULD BE LOOKED INTO MORE CAREFULLY. IT IS CERTAINLY A PROBLEM WITH THE COOLANT SYSTEM IN THE 2003 IMPALA AND THIS FAILURE SHOULD NOT BE AT THE EXPENSE OF THE CONSUMER. *NM
NHTSA ODI #10138631
Mileage unknown · Aug 30, 2005
Service Brakes, HydraulicCrashInjury
REFER TO THE GM RECALL ON 800,000 VEHICLES DUE CORROSION AFFECTS ANTILOCK BRAKE SYSTEM. I OWN A CHEVY IMPALA 2003 4DR SDN V6 FWD W/ANTILOCK BRAKES AND AWS. THE SYSTEM FAILED MUCH LIKE IN THE ABOVE STATED RECALL LAST WINTER IN MICHIGAN. WHILE APPROACHING A STOP SIGN, UPON ATTEMPTING SLOW THE VEHICLE USING THE BRAKE SYSTEM IT FAI…
Read full complaint
REFER TO THE GM RECALL ON 800,000 VEHICLES DUE CORROSION AFFECTS ANTILOCK BRAKE SYSTEM. I OWN A CHEVY IMPALA 2003 4DR SDN V6 FWD W/ANTILOCK BRAKES AND AWS. THE SYSTEM FAILED MUCH LIKE IN THE ABOVE STATED RECALL LAST WINTER IN MICHIGAN. WHILE APPROACHING A STOP SIGN, UPON ATTEMPTING SLOW THE VEHICLE USING THE BRAKE SYSTEM IT FAILED DOING JUST THE OPPOSITE OF WHAT IT WAS DESIGNED TO DO. THERE WERE GRINDING NOISES, VEHICLE PULLING TO ONE SIDE, LOSS OF CONTROL, VEHICLE TOOK OVER. THIS HAPPENED AT LOW SPEEDS UNDER 5 MPH. THE LOSS OF CONTROL DUE SYSTEM FAILURE RESULTED IN SAID VEHICLE ENDING UP IN A 70 FOOT DITCH WHEREUPON IT HAD TO BE TOWED OUT OF. DAMAGE WAS SUSTAINED TO THE FRONT LEFT FENDER, BUMPER AND DRIVING LIGHT. *NM
NHTSA ODI #10134740
Official recalls
5Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Feb 14, 2003
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Remedy: DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration