IllustrationTHE FUEL LINE RUSTED OUT IN FRONT OF DRIVERS SIDE REAR TIRE, SPRAYING A FINE STREAM OF GAS WHEN UNDER PRESSURE. I UNDERSTAND THIS IS A COMMON PROBLEM WITH HHR'S, LUCKILY, I CAUGHT IT EARLY COMPARED TO OTHERS. VEHICLE HAD JUST OVER 100,000 MILES AT THE TIME, AND HAS BEEN VERY WELL TAKEN CARE OF.
2010 Chevrolet Hhr
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2010 Chevrolet Hhr do not stand out strongly from the model-year median of 565.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Hhr years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
340–25K
9425–50K
13950–75K
7575–100K
50100–150K
21150K+
413 reports with mileage · 102 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 231 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
19 crash reports1 fire reports9 injury reports
What owners actually said
515 reportsMY AIRBAG LIGHT CAME ON CAUSING THE AIRBAG NOT ABLE TO OPERATE. BECAUSE MY VEHICLE WAS NOT PART OF THE RECALL IT DID HAVE ISSUES WITH THE WIRING STATING IT WAS CORRODED. IT COST A LOT OF MONEY TO HAVE THESE DEFECTS CORRECTED AND WAS TOLD NO SUCH RECALLS EXIST ON THE AIRBAG.
ON APRIL 25,2018, WHILE DRIVING ON THE FREEWAY RT PASSENGER BACK DOOR OPENED, NO INDICATOR LIGHT CAME ON DASH BOARD TO SHOW RT BACK DOOR AJARED... ON APRIL 19,2018 WHILE DRIVING ON CITY STREET RT FRONT PASSENGER DOOR OPENED, NO INDICATOR LIGHT APPEARED ON DASH. BOTH RT FRONT AND BACK PASSENGER DOORS OPENED WITH IN FIVE DAYS APAR…
Read full complaint
ON APRIL 25,2018, WHILE DRIVING ON THE FREEWAY RT PASSENGER BACK DOOR OPENED, NO INDICATOR LIGHT CAME ON DASH BOARD TO SHOW RT BACK DOOR AJARED... ON APRIL 19,2018 WHILE DRIVING ON CITY STREET RT FRONT PASSENGER DOOR OPENED, NO INDICATOR LIGHT APPEARED ON DASH. BOTH RT FRONT AND BACK PASSENGER DOORS OPENED WITH IN FIVE DAYS APART WHILE DRIVING.I WAS INFORMED BY DEALERSHIP THAT THE VEHICLE WAS OLD. CAUSE: FAULTY LATCH SPRING LOADER A15 BODY & ELECTRICAL, 10470C LOCK, REPLACED RT FRONT PASSENGER DOOR LATCH ASSEMBLY. I PURCHASED IT IN 2011AND THE PRESENT MILEAGE IS 17,000MI. I FEEL IF THE HATCH DOOR OPENS WHILE ON THE FREEWAY AND MY WHEEL CHAIR ROLLS OUT A FATAL ACCIDENT WOULD OCCUR. I FEEL THE MATERIAL USED IN THE LATCH SPRING LOADER AND DOOR LATCH ASSEMBLY IS UNSAFE. PARTS SHOULD BE RECALLED AND REPLACED BY THE MANUFACTURER, AS WELL AS NOTIFYING OWNER.THANK U FOR YOUR HELP.
TAKATA RECALL 4/11/2018 PURCHASED CAR. DEALER DID A SAFTEY INSPECTION ON THIS USED HHR .IN MY DRIVE HOME ON EXPRESSWAY AIR BAG LITE CAME ON @ 59 MILES DRIVEN AFTER THE PURCHASE. I CHECKED AND NOW SEE THERE ARE TONS OF ISSUED COMPLAINTS ON THE LT HHR MODEL. PLEASE RESPOND
A FAINT NOISE WAS HEARD AND I PULLED THE VEHICLE OVER TO THE SIDE OF ROAD WALKED AROUND THE ENTIRE VEHICLE LOOKING TO SEE IF ANYTHING STOOD OUT, ASSESSED THE TIRES, ENGINE AND NOTHING APPEARED TO BE WRONG. I PROCEEDED TO GET ON THE RAMP ON AND AS I WENT THROUGH THE TOLL BOOTH DRIVING AROUND 40 MPH, THE CAR ACCELERATED TO A SPEE…
Read full complaint
A FAINT NOISE WAS HEARD AND I PULLED THE VEHICLE OVER TO THE SIDE OF ROAD WALKED AROUND THE ENTIRE VEHICLE LOOKING TO SEE IF ANYTHING STOOD OUT, ASSESSED THE TIRES, ENGINE AND NOTHING APPEARED TO BE WRONG. I PROCEEDED TO GET ON THE RAMP ON AND AS I WENT THROUGH THE TOLL BOOTH DRIVING AROUND 40 MPH, THE CAR ACCELERATED TO A SPEED OF ABOUT 87 MPH, THE STEERING COULD NOT BE CONTROLLED IT WAS ALMOST AS IF IT WAS IN A LOCKED POSITION. ONCE THE VEHICLE TOOK OFF AT THE HIGH SPEED, IT THEN CAME ALMOST TO A COMPLETE STOP. THE SOUND OF THE ENGINE WAS REVVING BUT THE SPEED WAS NOT SUPPORTING THE SOUND. I PROCEEDED TO BRAKE, USE THE ACCELERATOR AND WAS GOING BACK AND FORTH BETWEEN THE TWO FUNCTIONS BUT NEITHER WOULD WORK. SCARED TO GO INTO THE FLOW OF HEAVY TRAFFIC, I PLACED THE VEHICLE IN NEUTRAL WHICH ALLOWED ME TO ROLL DOWN THE RAMP AND ONTO THE SHOULDER. I THEN TURNED THE VEHICLE OFF AND LET IT SIT AND ATTEMPTED TO TURN IT BACK ON TO REMOVE IT MORE OUT OF THE DRIVING LANE, BUT THE VEHICLE WOULD NOT MOVE
CAR LOST POWER STEERING & STEERING SYSTEM LIGHT CAME ON . OUR MECHANIC ADVISED 'GO TO CHEVROLET, IT'S A RECALL BUT THEY REFUSED TO FIX FREE & CHARGED $268.17 FOR FIX . CLAIMED IT WAS TURBO BUT WHAT'S THE DIFFERENCE? CAN I GET REIMBURSED? WEB SITE SAYS THIS YEAR WAS RECALLED.
FIRST MY AIRBAG SYSTEM STARTED COMING ON SAYING SERVICE AIRBAGS AND THE SENSORS ARE ALL NEW, SECOND THE SERVICE ESC COMES ON INTERMITTENTLY CAUSING VEHICLE TO SHIFT EXTREMELY HARD FROM 1ST GEAR (AUTOMATIC TRANNY) BRAKING SYSTEM WAS WORKING FINE AND ALL OF A SUDDEN THE BRAKE PEDAL GOES TO THE FLOOR NO BRAKES AND THE FLUID IS FUL…
Read full complaint
FIRST MY AIRBAG SYSTEM STARTED COMING ON SAYING SERVICE AIRBAGS AND THE SENSORS ARE ALL NEW, SECOND THE SERVICE ESC COMES ON INTERMITTENTLY CAUSING VEHICLE TO SHIFT EXTREMELY HARD FROM 1ST GEAR (AUTOMATIC TRANNY) BRAKING SYSTEM WAS WORKING FINE AND ALL OF A SUDDEN THE BRAKE PEDAL GOES TO THE FLOOR NO BRAKES AND THE FLUID IS FULL AND THE SYSTEM WAS WORKING JUST FINE AFTER MAKING GM AWARE OF THIS THEIR RESPONSE TO IT ALL IS THE VEHICLE IS OUT OF WARRANTY AND THERE IS NOTHING THEY CAN DO BUT THIS WAS AN ISSUE FROM DATE OF MFG AND GM REFUSES TO FIX OR CORRECT THE ONGOING ISSUES ALL OF THESE THINGS HAVE HAPPENED ON CITY STREETS AND HIGHWAYS IF NHTSA CANT HELP WITH THIS ISSUE THEN I HAVE NO WHERE LEFT TO TURN EXCEPT EITHER TO A MORGUE OR A SCRAP YARD
THE CAR WAS PURCHASED IN JANUARY 2016 & WAS GAVE TO ME VIA MY GRANDPAS WILL AFTER HE PASSED AWAY IN JULY 2016. THE CAR NEVER RAN CORRECTLY & IT WAS PARKED FOR A TOTAL OF 9 MONTHS, WHILE GETTING WORKED ON IN THE MEANTIME. IVE PUT ALMOST 1000 INTO THIS CAR & REPLACED EVERY PART IT NEEDED. NOW THE CAR WONT START & SHOWS THE AIR BAG…
Read full complaint
THE CAR WAS PURCHASED IN JANUARY 2016 & WAS GAVE TO ME VIA MY GRANDPAS WILL AFTER HE PASSED AWAY IN JULY 2016. THE CAR NEVER RAN CORRECTLY & IT WAS PARKED FOR A TOTAL OF 9 MONTHS, WHILE GETTING WORKED ON IN THE MEANTIME. IVE PUT ALMOST 1000 INTO THIS CAR & REPLACED EVERY PART IT NEEDED. NOW THE CAR WONT START & SHOWS THE AIR BAG ICON IS ALWAYS ON WHILE THE CAR TELLS ME THAT MY ECS IS "OFF" & SERVICE ECS. I OWN THE VEHICLE & IT IS PAID OFF.
ON NOVEMBER 29TH, 2017 I WAS DRIVING SOUTH ON THE HIGHWAY AND I WAS ABOUT 200 FEET BACK WHEN I NOTICED THAT THE BREAKS WENT DOWN TO THE FLOOR BOARD AND I FREAKED OUT AND DIDNT KNOW WHAT TO DO. THERE WAS KNOW LIGHT THAT CAME ON FOR BREAK OR ABS LIGHT. I HIT A CAR IN FRONT AT THE STOP LIGHT AHEAD AND RAN INTO TO HER MY CAR IS TOTA…
Read full complaint
ON NOVEMBER 29TH, 2017 I WAS DRIVING SOUTH ON THE HIGHWAY AND I WAS ABOUT 200 FEET BACK WHEN I NOTICED THAT THE BREAKS WENT DOWN TO THE FLOOR BOARD AND I FREAKED OUT AND DIDNT KNOW WHAT TO DO. THERE WAS KNOW LIGHT THAT CAME ON FOR BREAK OR ABS LIGHT. I HIT A CAR IN FRONT AT THE STOP LIGHT AHEAD AND RAN INTO TO HER MY CAR IS TOTALED. I HAD A TOW TRUCK COME AND GET THE CAR AND HE SAID AS WELL THERE WERE NO BREAKS WHAT SO EVER. ABOUT TWO WEEKS AGO I WAS NOTICING MY CAR WAS ACTING UP WITH THE ELECTRICIAL SYSTEM I HAD A OFFICER AT THE HOSPITAL COME OUT AND HELP ME AND HE SAID THATS WHAT IT LOOKS LIKE AND HE HAS NEVER SEEN THAT BEFORE.
TL* THE CONTACT'S SON OWNS A 2010 CHEVROLET HHR. WHILE ATTEMPTING TO EXIT THE VEHICLE, THE FRONT DRIVER'S DOOR LATCH INADVERTENTLY DETACHED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO RAMEY AUTOMOTIVE, INC. AT (276) 964-2511 (2750 CLINCH ST, RICHLANDS, VA 24641), BUT THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS REPAIRED. T…
Read full complaint
TL* THE CONTACT'S SON OWNS A 2010 CHEVROLET HHR. WHILE ATTEMPTING TO EXIT THE VEHICLE, THE FRONT DRIVER'S DOOR LATCH INADVERTENTLY DETACHED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO RAMEY AUTOMOTIVE, INC. AT (276) 964-2511 (2750 CLINCH ST, RICHLANDS, VA 24641), BUT THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. WHEN THE CONTACT ATTEMPTED TO EXIT THE VEHICLE FROM THE FRONT PASSENGER SIDE, THE DOOR HANDLE INADVERTENTLY DETACHED AS WELL AS THE REAR PASSENGER SIDE DOOR HANDLE. THE SAME DEALER WAS CONTACTED AGAIN, BUT THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 88,000.
Official recalls
314V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.