NHTSA owner reports · September 18, 2026 snapshot.
Electronic Stability Control (esc) complaints
32 reportsClear category filter75,907 miles · Apr 14, 2014
Electronic Stability Control (esc)Service BrakesSteering
FOR THE SECOND TIME IN A WEEK, THE VEHICLE IS BEING SERVICED BECAUSE THE ELECTRONIC STABILITY CONTROL (ESC) ACTIVATED SEVERAL TIMES SINCE THE LAST SERVICE WHILE TRAVELING STRAIGHT ON DRY PAVEMENT AT SPEEDS BETWEEN 15 AND 30 MPH. THE VEHICLE BRIEFLY LOSES STEERING AND PULLS TO THE RIGHT WHILE BRAKE IS INVOLUNTARILY ACTIVATED.…
Read full complaint
FOR THE SECOND TIME IN A WEEK, THE VEHICLE IS BEING SERVICED BECAUSE THE ELECTRONIC STABILITY CONTROL (ESC) ACTIVATED SEVERAL TIMES SINCE THE LAST SERVICE WHILE TRAVELING STRAIGHT ON DRY PAVEMENT AT SPEEDS BETWEEN 15 AND 30 MPH. THE VEHICLE BRIEFLY LOSES STEERING AND PULLS TO THE RIGHT WHILE BRAKE IS INVOLUNTARILY ACTIVATED. AFTER TURNING THE CAR OFF AND RESTARTING, THE CAR CONTINUES NORMALLY. FORTUNATELY, THIS HAS NOT YET CAUSED AN ACCIDENT. ON THIS OCCASION, THE DEALER COULD NOT DUPLICATE THE PROBLEM. THE DEALER HAS VARIOUSLY ATTRIBUTED THE PROBLEM TO MISMATCHED TIRES (REPLACED WITH ALL NEW), BAD HUBS (BOTH REPLACED), BAD SPEED SENSORS (REPLACED), BAD ALIGNMENT (FIXED) AND A WRONGLY CALIBRATED STEERING POSITION SENSOR (RE-CALIBRATED). THE VEHICLE HAS BEEN TOWED, REPAIRED REPEATEDLY, AND THE PROBLEM IS BACK AGAIN. THIS NEEDS TO BE ELEVATED TO A RECALL. *JS
NHTSA ODI #10579498
75,692 miles · Apr 14, 2014
Electronic Stability Control (esc)Service BrakesSteering
THIS IS ON OF REPEATED INCIDENTS WHERE THE ELECTRONIC STABILITY CONTROL (ESC) ACTIVATES WHILE TRAVELING STRAIGHT ON DRY PAVEMENT AT SPEEDS BETWEEN 15 AND 30 MPH. A CHIME SOUNDS, A MESSAGE APPEARS ON THE DISPLAY, THE VEHICLE BRIEFLY LOSES STEERING AND PULLS TO THE RIGHT WHILE BRAKE IS INVOLUNTARILY ACTIVATED. AFTER TURNING THE CA…
Read full complaint
THIS IS ON OF REPEATED INCIDENTS WHERE THE ELECTRONIC STABILITY CONTROL (ESC) ACTIVATES WHILE TRAVELING STRAIGHT ON DRY PAVEMENT AT SPEEDS BETWEEN 15 AND 30 MPH. A CHIME SOUNDS, A MESSAGE APPEARS ON THE DISPLAY, THE VEHICLE BRIEFLY LOSES STEERING AND PULLS TO THE RIGHT WHILE BRAKE IS INVOLUNTARILY ACTIVATED. AFTER TURNING THE CAR OFF AND RESTARTING, THE CAR CONTINUES NORMALLY. FORTUNATELY, THIS HAS NOT YET CAUSED AN ACCIDENT. ON THIS OCCASION, THE RIGHT FRONT HUB WAS REPLACED. THE DEALER HAS VARIOUSLY ATTRIBUTED THE PROBLEM TO MISMATCHED TIRES (REPLACED WITH ALL NEW), BAD HUBS (BOTH REPLACED), BAD SPEED SENSORS (REPLACED), BAD ALIGNMENT (FIXED) AND A WRONGLY CALIBRATED STEERING POSITION SENSOR (RE-CALIBRATED). THE VEHICLE HAS BEEN TOWED, REPAIRED REPEATEDLY, AND THE PROBLEM IS BACK AGAIN. THIS NEEDS TO BE ESCALATED TO A RECALL. *JS
NHTSA ODI #10579496
16,234 miles · Apr 10, 2014
Electronic Stability Control (esc)Steering
LOST POWER STEERING VERY HARD TO TURN STEERING WHEEL. *TR
NHTSA ODI #10578857
35,000 miles · Apr 1, 2014
Electronic Stability Control (esc)Service BrakesSteering
SINCE PURCHASING THIS VEHICLE AS A RENTAL RETURN, THERE HAVE BEEN REPEATED INCIDENTS WHERE THE ELECTRONIC STABILITY CONTROL (ESC) ACTIVATES WHILE TRAVELING STRAIGHT ON DRY PAVEMENT AT SPEEDS BETWEEN 15 AND 30 MPH. THE VEHICLE BRIEFLY LOSES STEERING AND PULLS TO THE RIGHT WHILE BRAKE IS INVOLUNTARILY ACTIVATED. AFTER TURNING THE …
Read full complaint
SINCE PURCHASING THIS VEHICLE AS A RENTAL RETURN, THERE HAVE BEEN REPEATED INCIDENTS WHERE THE ELECTRONIC STABILITY CONTROL (ESC) ACTIVATES WHILE TRAVELING STRAIGHT ON DRY PAVEMENT AT SPEEDS BETWEEN 15 AND 30 MPH. THE VEHICLE BRIEFLY LOSES STEERING AND PULLS TO THE RIGHT WHILE BRAKE IS INVOLUNTARILY ACTIVATED. AFTER TURNING THE CAR OFF AND RESTARTING, THE CAR CONTINUES NORMALLY. FORTUNATELY, THIS HAS NOT YET CAUSED AN ACCIDENT. THE DEALER HAS VARIOUSLY ATTRIBUTED THE PROBLEM TO MISMATCHED TIRES (REPLACED WITH ALL NEW), BAD HUBS (BOTH REPLACED), BAD SPEED SENSORS (REPLACED), BAD ALIGNMENT (FIXED) AND A WRONGLY CALIBRATED STEERING POSITION SENSOR (RE-CALIBRATED). THE VEHICLE HAS BEEN TOWED, REPAIRED REPEATEDLY, AND THE PROBLEM IS BACK AGAIN. THIS NEEDS TO BE ELEVATED TO A RECALL. *TR
NHTSA ODI #10576107
35,000 miles · Feb 8, 2014
Electronic Stability Control (esc)Service BrakesSteering
ON TWO OCCASIONS WITHIN THE 3YR/36,000MILE WARRANTY, THE ESC AND ANTILOCK TEMPORARILY WENT OUT WITH DASHBOARD NOTIFICATION. NO ESC PROBLEMS SINCE, SO IT WAS NOT TAKEN TO DEALERSHIP. IN THE MEANTIME, WE HAVE A POWER STEERING PROBLEM THAT ONLY OCCURRED ONCE DURING THE WARRANTY PERIOD AT 35,000 MILES. NOW, AT 40,000, THE PROBLEM HA…
Read full complaint
ON TWO OCCASIONS WITHIN THE 3YR/36,000MILE WARRANTY, THE ESC AND ANTILOCK TEMPORARILY WENT OUT WITH DASHBOARD NOTIFICATION. NO ESC PROBLEMS SINCE, SO IT WAS NOT TAKEN TO DEALERSHIP. IN THE MEANTIME, WE HAVE A POWER STEERING PROBLEM THAT ONLY OCCURRED ONCE DURING THE WARRANTY PERIOD AT 35,000 MILES. NOW, AT 40,000, THE PROBLEM HAS WORSENED SO THE POWER STEERING FAILS EVERY TRIP. THE CAR STEERS HARD WHEN THIS OCCURS, OBVIOUSLY. RESTARTING THE CAR RESOLVES THE PROBLEM FOR A FEW MINUTES. *TR
NHTSA ODI #10563496
57,270 miles · Jan 16, 2014
Electronic Stability Control (esc)Steering
I,WAS DRIVING ON THE FWY!LUCKY ON THE EXIT AT RAMONA BLVD FROM THE 605 FWY MY CAR POWER WHEEL STAR TO TURNING HARD TO TURN RIGHT AND THE LIGHT ON THE PANEL SHOW POWER STEERING AND LUCKY ME! I,MANAGE TO TURNED VERY HARD BUT,I DID TURN THE WHEEL AND PARK MY CAR ON SHOULDER, I,TURN OFF THE CAR AND TURNED ON AGAIN AND THE WHEEL TURN…
Read full complaint
I,WAS DRIVING ON THE FWY!LUCKY ON THE EXIT AT RAMONA BLVD FROM THE 605 FWY MY CAR POWER WHEEL STAR TO TURNING HARD TO TURN RIGHT AND THE LIGHT ON THE PANEL SHOW POWER STEERING AND LUCKY ME! I,MANAGE TO TURNED VERY HARD BUT,I DID TURN THE WHEEL AND PARK MY CAR ON SHOULDER, I,TURN OFF THE CAR AND TURNED ON AGAIN AND THE WHEEL TURN SOFT AGAIN!SO I,CUT DRIVE SAFE TO MY HOME FROM THERE!!BUT I AM AFRAID GOING TO THE FWY AGAIN!!THIS HAPPEN 01_14_2014 PLEASE GIVE TO ME ANY FEEDBACK FROM THIS MATTER!!SCARE DRIVER..( THIS IS THE THIRD TIME HAPPEN) I AM AFRAID TO SOMETHING HAPPENS TO ME!!! *TR
NHTSA ODI #10560171
52,000 miles · Nov 26, 2013
Electrical SystemElectronic Stability Control (esc)Steering
I WAS DRIVING THE CAR GOT UP TO 25 MPH AND THE STEERING WENT OUT, THE CAR WAS HARD TO STEER I TURNAROUND FOR HOME. I TURN THE CAR OFF TOOK THE KEY OUT OF THE IGNITION PUT IT BACK IN STARTED THE CAR UP AND IT WORK FOR ONE MINUTE AND WENT OUT AGAIN. *TR
NHTSA ODI #10553807
68,000 miles · Sep 6, 2013
Electronic Stability Control (esc)
THE ELECTRICAL POWER SYSTEM IN MY 2010 CHEVY HHR COMPLETELY FAILED 3 DAYS AGO WHILE DRIVING DOWN THE ROAD. WE WERE UNABLE TO STEER THIS VEHICLE AND IT ALMOST CAUSED A BAD TRAFFIC ACCIDENT. THE POWER SYSTEM FAILED AT 68,000 MILES. IT IS APPARENT THAT NUMEROUS HHR OWNERS HAS EXPERIENCED THIS PROBLEM BUT GM HAS TAKEN NO ACTION TO …
Read full complaint
THE ELECTRICAL POWER SYSTEM IN MY 2010 CHEVY HHR COMPLETELY FAILED 3 DAYS AGO WHILE DRIVING DOWN THE ROAD. WE WERE UNABLE TO STEER THIS VEHICLE AND IT ALMOST CAUSED A BAD TRAFFIC ACCIDENT. THE POWER SYSTEM FAILED AT 68,000 MILES. IT IS APPARENT THAT NUMEROUS HHR OWNERS HAS EXPERIENCED THIS PROBLEM BUT GM HAS TAKEN NO ACTION TO RECALL THIS PART ON THIS VEHICLE. RESEARCHING THE ELECTRONIC POWER SYSTEM PART NUMBER 19257875 I DISCOVERED THAT GM HAS OTHER VEHICLES THAT HAVE A RECALL APPLICABLE TO THE HHR THAT MATCH THE PART NUMBER IN QUESTION. BUICK, CADILLAC, PONTIAC, COBALT HAVE RECALLS ON THIS SAME PART NUMBER WHICH COVER A LIFE TIME WARRANTY. THIS IS A VERY SERIOUS PROBLEM WITH THE HHR AND THE ELECTRONIC POWER SYSTEM AND GM SHOULD HAVE INITIATED A RECALL ON THE ELECTRONIC POWER SYSTEM AGES AGO. WHAT ARE THEY WAITING FOR. SOMEONE TO BE SERIOUSLY INJURED OR KILLED.
NHTSA ODI #10542212
50,000 miles · Apr 16, 2013
Electronic Stability Control (esc)Service BrakesSteering
I HAVE HAD TWO ISSUES WITH THIS CAR AND IT HAS MADE ME FEEL UNSAFE WHEN DRIVING IT. THE FIRST INVOLVES THE BRAKES. WHEN BRAKING AFTER DRIVING AT 45MPH OR MORE, THE STEERING WHEEL BEGINS SHAKING. I WAS TOLD THE BRAKE PADS NEEDED TO BE CHANGED. I DID AND THE PROBLEM STILL CONTINUED. LAST MONTH, THE POWER STEERING LIGHT CAME ON THE…
Read full complaint
I HAVE HAD TWO ISSUES WITH THIS CAR AND IT HAS MADE ME FEEL UNSAFE WHEN DRIVING IT. THE FIRST INVOLVES THE BRAKES. WHEN BRAKING AFTER DRIVING AT 45MPH OR MORE, THE STEERING WHEEL BEGINS SHAKING. I WAS TOLD THE BRAKE PADS NEEDED TO BE CHANGED. I DID AND THE PROBLEM STILL CONTINUED. LAST MONTH, THE POWER STEERING LIGHT CAME ON THE DASHBOARD. FOR A COUPLE OF DAYS, IT WENT AWAY BUT SOON THE STEERING WHEEL BECAME TOO HARD TO TURN. TOOK IT TO MECHANIC WHO CHANGED THE POWER STEERING MODULE AS INDICATED BY THE DIAGNOSTICS TEST. ONCE THE CHANGE WAS DONE, THE SERVICE ESC LIGHT CAME ON AND THE CAR HAS BEEN CRAZY EVER SINCE. I HAVE YET TO RESOLVE THE ISSUE AS NOBODY KNOWS WHAT IS WRONG WITH MY CAR. IT HAS BEEN ALMOST A MONTH ALREADY. I AM UNHAPPY WITH THIS CAR AND WOULD NOT RECOMMEND TO ANYBODY. AFTER LOOKING IT UP, I SEE THAT MANY HAVE THIS SAME ISSUE. IT IS VERY UNSAFE SINCE THIS CAN HAPPEN AT ANY MOMENT WHILE DRIVING! *TR
NHTSA ODI #10508394
54,000 miles · Aug 30, 2012
Electronic Stability Control (esc)Steering
I WAS DRIVING MY CAR TO THE DOLLAR STORE AND WAS STOPPED AT THE RED "LEFT TURN" ARROW, AND ALL OF A SUDDEN, THE "POWER STEERING" SIGN FLASHED ON MY DASHBOARD AND MY CAR MADE A "DING DING" NOISE. WHEN THE LIGHT TURNED GREEN, I TURNED LEFT AND IT WAS EXTREMELY HARD FOR ME TO TURN THE WHEEL. IT HAS BEEN HAPPENING SINCE. I WILL TURN…
Read full complaint
I WAS DRIVING MY CAR TO THE DOLLAR STORE AND WAS STOPPED AT THE RED "LEFT TURN" ARROW, AND ALL OF A SUDDEN, THE "POWER STEERING" SIGN FLASHED ON MY DASHBOARD AND MY CAR MADE A "DING DING" NOISE. WHEN THE LIGHT TURNED GREEN, I TURNED LEFT AND IT WAS EXTREMELY HARD FOR ME TO TURN THE WHEEL. IT HAS BEEN HAPPENING SINCE. I WILL TURN THE CAR OFF, AND WHEN I TURN THE CAR BACK ON, IT DRIVES FINE FOR THE FIRST FEW MINUTES, AND THEN THE "POWER STEERING" SIGN CAME BACK ON. THE "POWER STEERING" SIGN HAS ALSO APPEARED WHEN I WAS MAKING A RIGHT TURN WHICH CAUSED THE WHEEL TO LOCK UP IN THE MIDDLE OF A TURN. THE CAR JERKED AND I ALMOST CRASHED INTO A BLACK SEDAN. I HAVE A SMALL CHILD WHO SITS IN THE BACK SEAT. I DON'T HAVE MUCH MONEY, SO I CAN NOT AFFORD TO PAY THE DEALERSHIP TO GET THIS ISSUE FIXED. I TOOK IT TO A CHEAP REPAIR SHOP, AND THEY COULD NOT FIND THE ISSUE. I HAVE BEEN LOOKING ONLINE TO FIND WHAT WAYS I CAN FIX THIS WITHOUT IT COSTING ME A LOT OF MONEY. HAVE NOT BEEN ABLE TO FIND A SOLUTION, SO I AM CURRENTLY DRIVING WITH NO "POWER STEERING" WHICH CAN BE VERY DANGEROUS. IN ADDITION TO MY POWER STEERING GOING OUT, A COUPLE MONTHS AGO, I WENT OUT TO MY CAR TO GET IN MY CAR, AND PUT MY KEY IN THE IGNITION AND TURNED THE CAR ON. MADE IT TO THE STORE, AND WHEN I WAS GETTING READY TO GET OUT OF THE CAR, THE KEY WOULD NOT COME OUT OF THE IGNITION. I COULD NOT TURN IT, OR ANYTHING. THE CAR WOULD NOT TURN OFF. I HAD TO HAVE AAA DISCONNECT MY BATTERY SO THAT MY CAR DIDN'T HAVE TO STAY RUNNING UNTIL THE DEALERSHIP OPENED IN THE MORNING. MY KEY HAD TO SIT IN THE IGNITION OVER NIGHT, SOMEONE COULD HAVE STOLEN MY CAR. I TOOK IT TO THE DEALERSHIP THE NEXT MORNING AND THEY HAD TO REPLACE THE WHOLE IGNITION CYLINDER. *TR
NHTSA ODI #10473115
Official recalls
3Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration