IllustrationCONSUMER ONCE APPLIED BRAKES AND THEY WENT TO FLOOR. YET AUTO DID NOT STOP.- HE HAS ALSO HAD THREE ACCIDENTS , AS A RESULTS OF FAULTY BRAKES IN THE SAME VEHICLE. *AK
1994 Chevrolet G20
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all G20 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 42 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports0 fire reports5 injury reports
What owners actually said
42 reportsSPLASH SHIELD IS PUSHED BACK WHEN VEHICLE IS IN MOTION AND RUBS ON THE INSIDE OF TIRE.
PCM MODULE FAILED.
ANTILOCK BRAKES FAILED 6 TIMES.
BRAKE ROTORS REPLACED.
WHILE DRIVING APPLIED THE BRAKES AND THE PEDAL WILL DROP ALMOST TO THE FLOOR AND THE VEHICLE HAS A DELAY IN STOPPING. THE BRAKES DO NOT ENGAGE WHEN APPLYING THEM, THIS DOES NOT HAPPEN ALL THE TIMES, JUST SOMETIMES. *AK
GENERAL TIRES BEGAN GOING BAD AT ABOUT 33,000 MILES. MADE A THUMPING SOUND AND CONTINUED TO GET WORSE UNTIL THEY CAUSED THE VEHICLE TO VIBRATE. *AK
REAR AXLE SEALS (BOTH SIDES) WERE LEAKING AND SOAKED THE BRAKE SHOES, NECESSETATING A REPLACEMENT OF BOTH SEALS AND BRAKE SHOES.
FAILURE OF THE ABS BRAKING SYSTEM, CONSUMER APPLIED FORCE TO THE BRAKE PEDAL AND THE VEHICLE CONTINUED TO MOVE AND THE VEHICLE SKIDDED TO A STOP. *AK
BRAKES PADS CONTINUALLY FAIL, CAUSING VIBRATION/PREMATURE TIRE WEAR.
Official recalls
394V177000 · Seats:front Assembly:head Restraint
Sep 14, 1994
THE FRONT DRIVER AND PASSENGER SEAT BACK HEIGHT DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 202, "HEAD RESTRAINTS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: SEAT OCCUPANTS ARE SUBJECT TO INCREASED RISK OF INJURY IN THE EVENT OF A SUDD STOP OR ACCIDENT.
Remedy: SHERRY DESIGNS WILL PROVIDE AN ATTACHABLE HEADREST FOR THE DEALER OR CUSTOMER TO ADD TO THE SEATS.
94V128000 · Interior Lighting
Jul 11, 1994
THE TRANSFORMER USED TO POWER THE NEON CENTER LIGHTBEAM CAN OVERHEAT AND CATCH ON FIRE.
Consequence & remedy
Consequence: THE OVERHEATING AND FIRES CAUSED BY THE NEON TRANSFORMER CAN RESULT IN DAMAGE TO THE LIGHTBEAM ASSEMBLY, THE ROOF OF THE VEHICLE, AND COULD RESULT IN A VEHICLE FIRE.
Remedy: MARK III DEALERS WILL MODIFY THE ASSEMBLIES TO ELIMINATE THE NEON LIGHTING FIXTURE IN THE VEHICLE AND REPLACE IT WITH INCANDESCENT LIGHTS OPERATING DIRECTLY FROM THE VEHICLE 12-VOLT BATTERY.
94V087000 · Equipment:other:labels
May 9, 1994
THE MANUFACTURER'S CERTIFICATION LABEL AND/OR THE DRIVER AIR BAG ADVISORY LABEL MAY BE MISSING FROM THE VEHICLES, WHICH DOES NOT CONFORM TO THE REQUIREMENTS OF 49 CFR 567.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: OWNERS OF VEHICLE WOULD BE UNAWARE OF THE LOAD CAPACITY OF THE VANS, THE VAN BUILD DATE, AND WOULD NOT HAVE ANY ASSURANCE THAT THE VANS MEET THE FEDERAL MOTOR VEHICLE SAFETY STANDARDS.
Remedy: THE LABELS WILL BE FURNISHED TO OWNER'S FOR INSTALLATION ON THE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.