ABS Valve Body / Pump Harness chafed through brake hydraulic line near transmission crossmember. This resulted in a hydraulic leak and loss of brake pedal feel / partial loss of brakes. Fortunately failure occurred in the driveway--I had 4500 Lbs of sailboat trailer hitched to the van and was about to go on a long trip. Design…
Read full complaint
ABS Valve Body / Pump Harness chafed through brake hydraulic line near transmission crossmember. This resulted in a hydraulic leak and loss of brake pedal feel / partial loss of brakes. Fortunately failure occurred in the driveway--I had 4500 Lbs of sailboat trailer hitched to the van and was about to go on a long trip. Design issue. Wiring harness should not be located so as to chafe on hydraulic lines. This is not the first chafe related failure on this vehicle.
NHTSA ODI #11755204
212,000 miles · Sep 12, 2015
Electrical System
ENGINE WAS AT IDLE HAD PULLED INTO GAS STATION . ALARMS WENT OFF CHECK ENGINE LIGHT CAME ON, STABLE TRACK ERROR, MULTIPLE TONES. AFTER 20 SECONDS ENGINE STALLED. WOULD NOT CRANK. AFTER TALKING TO PEOPLE AND COUPLE TRIES FIX TOOK TO DEALERSHIP AS IT WAS DIAGNOSED TO BE THE ENGINE CONTROL MODULE SHORTED. I HAD GONE THRU RAIN EAR…
Read full complaint
ENGINE WAS AT IDLE HAD PULLED INTO GAS STATION . ALARMS WENT OFF CHECK ENGINE LIGHT CAME ON, STABLE TRACK ERROR, MULTIPLE TONES. AFTER 20 SECONDS ENGINE STALLED. WOULD NOT CRANK. AFTER TALKING TO PEOPLE AND COUPLE TRIES FIX TOOK TO DEALERSHIP AS IT WAS DIAGNOSED TO BE THE ENGINE CONTROL MODULE SHORTED. I HAD GONE THRU RAIN EARLIER AND A COUPLE STORMS PASSED THRU WHILE AT STATION AND EATING. DEALER REPLACED ENGINE CONTROL MODULE AND PROGRAMMED IT. THIS COULD OF HAPPENED WHILE DRIVING AND WOULD OF LOST ENGINE POWER AND POWER STEERING. SINCE JUST MODULE REPLACED AND BEN TOLD IT IS KNOW TO SHORT OUT WHEN WET IT COULD HAPPEN AGAIN.
NHTSA ODI #10763324
47,000 miles · Jun 17, 2015
Electrical SystemSteering
TL* THE CONTACT OWNS A 2012 CHEVROLET EXPRESS. WHEN THE BRAKES WERE DEPRESSED AND RELEASED, THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE CONTACT MENTIONED THAT THE STABILITRAK ACTIVATED INDEPENDENTLY AFTER BEING TURNED OFF WITHOUT WARNING. THE VEHICLE WAS TAKEN TO DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUF…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET EXPRESS. WHEN THE BRAKES WERE DEPRESSED AND RELEASED, THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE CONTACT MENTIONED THAT THE STABILITRAK ACTIVATED INDEPENDENTLY AFTER BEING TURNED OFF WITHOUT WARNING. THE VEHICLE WAS TAKEN TO DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 47,000.
General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy: GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.
General Motors LLC (GM) is recalling certain model year 2011-2014 Chevrolet Express compressed natural gas (CNG)vehicles manufactured September 10, 2010, to April 28, 2014, and GMC Savana CNG vehicles manufactured May 23, 2011, to April 21, 2014. The affected vehicles may leak natural gas from the CNG high pressure regulator.
Consequence & remedy
Consequence: A natural gas leak in the presence of an ignition source increases the risk of a fire or explosion.
Remedy: GM will notify owners, and dealers will replace the high pressure regulator, free of charge. The recall began February 13, 2013. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 14321.
General Motors LLC (GM) is recalling certain model year 2009-2014 Chevrolet Express and GMC Savana vans manufactured January 27, 2009, through March 7, 2014 with a gross vehicle weight rating of 10,000 pounds and less and equipped with front passenger air bags. In the affected vehicles, during a frontal impact below the air bag deployment threshold, if an unbelted front passenger's head hits the instrument panel above where the passenger air bag is located, the panel may not sufficiently absorb the impact. As such, these vehicles fail to meet the requirements of Federal Motor Vehicle Safety Standard number 201, "Occupant Protection in Interior Impact."
Consequence & remedy
Consequence: In the event of a crash below the air bag deployment threshold, an unbelted front passenger seat occupant has an increased risk of injury.
Remedy: GM will notify owners, and dealers will modify the passenger instrument panel free of charge. Notices to the owners of the heavy duty vans were mailed on April 28, 2014. The recall began on May 19, 2014. Chevrolet owners may call 1-800-630-2438. GMC owners may call 1-866-996-9463. GM's number for this recall is 14082.
General Motors LLC (GM) and IMPCO Automotive Division of IMPCO Technologies, Inc. (IMPCO) are recalling certain model year 2011-2013 Chevrolet Express and GMC Savana Cargo vans that have a compressed natural gas (CNG) fuel system installed as original equipment by IMPCO. The fuel systems, manufactured February 14, 2011, through February 20, 2013, have a fuel shut-off solenoid connector to the CNG tank that may corrode and form a short.
Consequence & remedy
Consequence: A short at the connector may cause overheating, resulting in an increased risk of fire.
Remedy: GM will notify owners and GM dealers/fleets will perform the remedy which will include replacing the solenoid assemblies and fuel pump fuses and adjusting the wiring routing. The recall began on August 5, 2013. GM's number for this recall is 13139. Impco's number for this recall is FA13GM001. Owner's may contact GM Fleet Action Center at 1-800-353-3867.
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EXPRESS AND SUBURBAN VEHICLES, AND GMC SAVANA AND YUKON XL HEAVY DUTY VEHICLES. THE STEERING GEAR PITMAN SHAFT MAY NOT HAVE BEEN ADEQUATELY HARDENED AND COULD FRACTURE.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, A LOSS OF STEERING COULD RESULT, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE STEERING GEAR AND, IF NECESSARY, REPLACE THE STEERING GEAR PITMAN SHAFT. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON APRIL 4, 2012.
GM IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES MANUFACTURED FROM JUNE 2, 2011, THROUGH OCTOBER 17, 2011. THE SECOND STAGE OF THE DUAL-STAGE AIR BAG WILL NOT INFLATE IN A SEVERE FRONTAL IMPACT. ACCORDINGLY, THE AIR BAGS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: AN IMPROPERLY DEPLOYED AIR BAG WILL INCREASE THE RISK OF INJURY TO THE OCCUPANT.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSTALL A NEW FRONT PASSENGER AIR BAG FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 29, 2011. OWNERS MAY CONTACT GMC AT 1-800-462-8782 OR CHEVROLET AT 1-800-222-1020.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2012 Chevrolet Express Problems, Complaints & Recalls | Skip That Year
Illustration