I was driving and out of no where my brakes “ all four wheels “ locked up as if I was hauling a heavy load . I put on my hazard lights to warn the semi behind me. So I maintained control of my line until the cargo van slowed down to a safe speed for me to pull over . I thought the semi was going to run into the back of me, luck…
Read full complaint
I was driving and out of no where my brakes “ all four wheels “ locked up as if I was hauling a heavy load . I put on my hazard lights to warn the semi behind me. So I maintained control of my line until the cargo van slowed down to a safe speed for me to pull over . I thought the semi was going to run into the back of me, luckily the southbound line was clear so the semi took off pass me. So as I was coming to a safe stopping speed my brake pedal was stiff as well and when the cargo van slowed down to a safe speed, I pulled over to check my brakes with a warm liquid “ all four brakes were hot “ .
NHTSA ODI #11730511
Mileage unknown · Nov 24, 2025
Air BagsService BrakesInjury
I was in a front end Collison due to a brake failure and when I have a steel gate at about 30 mph no airbag deployed. Car was towed by the Upper Darby Police Department and it is totaled. I sustained injuries. There was no airbag light brake warning light came when I attempted to use the emergency brake when regular failed
NHTSA ODI #11701219
Mileage unknown · Sep 8, 2022
Electrical SystemService Brakes
Hole warn in front passenger side brake line from battery cable going to engine starter motor. The shielding on electrical cable rubbed and wore a hole in the brake line causing fluid to flow out and caused brakes to fail. No one was injured and no accident. I was backing out of the driveway the brakes failed, next I saw a l…
Read full complaint
Hole warn in front passenger side brake line from battery cable going to engine starter motor. The shielding on electrical cable rubbed and wore a hole in the brake line causing fluid to flow out and caused brakes to fail. No one was injured and no accident. I was backing out of the driveway the brakes failed, next I saw a large puddle of fluid on driveway, I just put it in park. The battery cable crosses over the break line and both are fastened to the frame near each other. I can provide break line and photo. The van has 60,000 miles on it, I purchased it new in 2005.
NHTSA ODI #11483591
115,060 miles · Dec 20, 2014
Exterior LightingService BrakesSuspension
THE BRAKES ON MY VEHICLE WERE INSPECTED AT HOMEWOOD CHEVROLET IN ILLINOIS AND THEY DID NOT NEED PADS OR ANYTHING, HOWEVER, THE BRAKES BRAKES RELEASE ON THEIR OWN WHEN YOU ARE DRIVING. THERE WAS A HYDRAULIC RECALL AND I NEVER RECEIVED ANY INFORMATION..THE HEADLIGHTS ON MY CAR ALSO KEEP BURNING OUT WITHIN WEEKS OF HAVING THEM CHA…
Read full complaint
THE BRAKES ON MY VEHICLE WERE INSPECTED AT HOMEWOOD CHEVROLET IN ILLINOIS AND THEY DID NOT NEED PADS OR ANYTHING, HOWEVER, THE BRAKES BRAKES RELEASE ON THEIR OWN WHEN YOU ARE DRIVING. THERE WAS A HYDRAULIC RECALL AND I NEVER RECEIVED ANY INFORMATION..THE HEADLIGHTS ON MY CAR ALSO KEEP BURNING OUT WITHIN WEEKS OF HAVING THEM CHANGED. THE VEHICLE HAS SOME SUSPENSION ISSUE AS WELL. THERE WAS ALSO A RECALL FOR THAT WHICH I RECEIVED NO NOTICE FOR.I HAVE NOT MOVED SINCE PURCHASING THIS VEHICLE.
CUSTOMIZERS IS RECALLING 3 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES," THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence & remedy
Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Remedy: CUSTOMIZERS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000.
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence & remedy
Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy: MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence & remedy
Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy: MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
MOBILITY IS RECALLING 86 MY 2005-2006 FORD E-SERIES AND CHEVROLET EXPRESS VAN EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence & remedy
Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy: MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY AT 714-674-0480.
MOBILITY IS RECALLING 43 MY 2005-2006 FORD E-SERIES AND CHEVROLET EXPRESS VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence & remedy
Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Remedy: MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY AT 714-674-0480.
ON CERTAIN FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS, THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE BUCKLES AND, IF FOUND TO BE INOPERATIVE, THE ENTIRE BUCKLE ASSEMBLY WOULD BE REPLACED. FOR BUCKLES FOUND TO BE OPERATIVE, DEALER WILL REPLACE ONLY THE UPPER BUCKLE COVER. THE RECALL WILL BE CONDUCTED IN PHASES. THE FIRST PHASE MAILING BEGAN DURING MARCH 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
CERTAIN CONVERSION VANS BUILT ON GMC/CHEVROLET CHASSIS FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT." THE HOUSING LENS OF THE CENTER HIGH MOUNTED STOP LAMP DOES NOT ALLOW ENOUGH LIGHT TO EMIT FROM THE LAMP.
Consequence & remedy
Consequence: FOLLOWING VEHICLES MAY NOT BE FULLY INFORMED OF VEHICLE BRAKING. REAR-END COLLISIONS AND INJURY TO OCCUPANTS MAY OCCUR.
Remedy: SANTA FE IS WORKING WITH AUDIOVOX TO REPLACE THE CENTER HIGH-MOUNTED BRAKE LAMP ASSEMBLY. OWNERS MAY CONTACT SANTA FE AT 1-800-274-1886 OR ASA AT 1-574-266-3172.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Chevrolet Express Problems, Complaints & Recalls | Skip That Year
Illustration