IllustrationWITHOUT WARNING ALL HEADLAMPS WENT OUT DRL,LOW BEAMS AND HIGH BEAMS. ALL OTHER LIGHTS WORKED OK. NOT FUN AT NIGHT TO HAVE OCCUR. *TR
1999 Chevrolet Express
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Express years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 68 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports2 fire reports2 injury reports
What owners actually said
68 reportsTL* THE CONTACT OWNS A 1999 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE DOOR LOCKS WOULD NOT FUNCTION PROPERLY. SHE NOTICED THAT THE DOOR LOCK PINS WOULD FREEZE IN COLD WEATHER. THE DEALER WAS CONTACTED AND ADVISED OF THE PROCEDURE THAT WOULD HAVE TO BE PERFORMED IN ORDER TO MAKE REPAIRS. THERE WERE NO REPAIRS MADE TO THE VEH…
Read full complaint
TL* THE CONTACT OWNS A 1999 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE DOOR LOCKS WOULD NOT FUNCTION PROPERLY. SHE NOTICED THAT THE DOOR LOCK PINS WOULD FREEZE IN COLD WEATHER. THE DEALER WAS CONTACTED AND ADVISED OF THE PROCEDURE THAT WOULD HAVE TO BE PERFORMED IN ORDER TO MAKE REPAIRS. THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 200,000.
VEHICLE AIR BAG DIDN'T DEPLOY WHEN I CRASHED INTO ANOTHER VEHICLE DOING BETWEEN 30-40 MPH. IMPACT WAS MAINLY ON THE DRIVER SIDE FRONT END. I WAS DRIVING AN CHEVY 1999 EXPRESS 1500 VAN. *NM
DT : THE POWER STEERING PUMP SHAFT BROKE INSIDE THE PUMP ON JULY 14, 2000, THE DEALER REPLACED IT UNDER WARRANTY. ON SEPTEMBER 23, 2005 IT BROKE AGAIN, TOOK VEHICLE TO THE DEALER AGAIN, AND THEY DID REPLACE IT. HOWEVER, THEY CHARGED THE CONSUMER $636.00. THE STEERING LOCKED AND THAT WAS HOW CONSUMER DISCOVERED THE FAILURE…
Read full complaint
DT : THE POWER STEERING PUMP SHAFT BROKE INSIDE THE PUMP ON JULY 14, 2000, THE DEALER REPLACED IT UNDER WARRANTY. ON SEPTEMBER 23, 2005 IT BROKE AGAIN, TOOK VEHICLE TO THE DEALER AGAIN, AND THEY DID REPLACE IT. HOWEVER, THEY CHARGED THE CONSUMER $636.00. THE STEERING LOCKED AND THAT WAS HOW CONSUMER DISCOVERED THE FAILURE. THERE WAS NO PRIOR WARNING. THIS HAPPENED ON A DRY PAVED ROAD AND IN WARM WEATHER. *AK *NM
1999 CHEVROLET EXPRESS SPARE TIRE FELL OFF WHILE DRIVING. *TS THE SPARE TIRE WAS ATTACHED WITH A STEEL CABLE TO THE REAR UNDERSIDE OF THE VAN. WHEN THE STEEL CABLE BROKE THE TIRE BOUNCED UNDER THE TOW TRAILER BENDING IT'S AXLE. THE CONSUMER BELIEVES THE CABLE MAY NOT HAVE BEEN STRONG ENOUGH. *NM
DT: THE CONTACT OWNS A 1999 CHEVROLET EXPRESS 3500 VAN. THE HINGE ON THE DOUBLE DOORS ON THE SIDE FROZE, THEY WILL NOT OPEN ANYMORE. PREVIOUSLY, THEY WHERE HARD TO OPEN, AND NOW THEY ARE CRACKING. THE DEALERSHIP SAID THIS WAS BAD DESIGN. ALSO, DEALERSHIP TOLD HER THAT THERE WAS BACK ORDER ON THE HINGES. OBVIOUSLY A LOT OF P…
Read full complaint
DT: THE CONTACT OWNS A 1999 CHEVROLET EXPRESS 3500 VAN. THE HINGE ON THE DOUBLE DOORS ON THE SIDE FROZE, THEY WILL NOT OPEN ANYMORE. PREVIOUSLY, THEY WHERE HARD TO OPEN, AND NOW THEY ARE CRACKING. THE DEALERSHIP SAID THIS WAS BAD DESIGN. ALSO, DEALERSHIP TOLD HER THAT THERE WAS BACK ORDER ON THE HINGES. OBVIOUSLY A LOT OF PEOPLE WERE HAVING SIMILAR PROBLEMS. THE CONSUMER RAN A DAY CARE CENTER. IT WAS DIFFICULT FOR CHILDREN TO GO FROM THE FRONT OF THE VAN TO THE BACK. IN AN EMERGENCY IT WOULD BE IMPOSSIBLE TO GET THE CHILDREN OUT OF THE VAN FAST ENOUGH. *AK
DT: 1999 CHEVROLET EXPRESS. THE SHAFT ON THE POWER STEERING UNIT BROKE. THE CONSUMER STATES THE POWER STEERING INSTANTLY QUIT WORKING ON THE VEHICLE. THERE WAS NO WARNING. THEY TOOK THE VEHICLE TO A DEALERSHIP AND HAD IT REPAIRED. THE MECHANIC DID NOT TELL HIM WHY THE SHAFT BROKE. *JB
AFTER TRAVELING FOR LONG PERIODS OF TIME ON A HIGHWAY AND THEN SLOWING TO A STOP ON THE EXIT, THE VEHICLE HARD SHIFTS IN GEARS 1-2. IF YOU SHUT OFF THE ENGINE, IT APPEARS OK UNTIL THE NEXT TIME. TRANSMISSION FLUID IS OK. VEHICLE ONLY HAS 47500 MILES. HAD MECHANIC CHECK AND GETS COMPUTER CODE 1870, WITH ENGINE CHECK LIGHT ON.…
Read full complaint
AFTER TRAVELING FOR LONG PERIODS OF TIME ON A HIGHWAY AND THEN SLOWING TO A STOP ON THE EXIT, THE VEHICLE HARD SHIFTS IN GEARS 1-2. IF YOU SHUT OFF THE ENGINE, IT APPEARS OK UNTIL THE NEXT TIME. TRANSMISSION FLUID IS OK. VEHICLE ONLY HAS 47500 MILES. HAD MECHANIC CHECK AND GETS COMPUTER CODE 1870, WITH ENGINE CHECK LIGHT ON. NUMEROUS POSTS ON THE WEB HAVE SIMILAR COMPLAINTS ON CHEVY/GM VEHICLES WITH 4L60E TRANSMISSION, BUT NO RECALL TO DATE. MAY NOW HAVE TO REPLACE TRANSMISSION.
DT: VEHICLE WAS PARKED AND WHEN PLACED KEY IN IGNITION DRIVER'S SIDE AIR BAG DEPLOYED ONTO DRIVER. VEHICLE HAD BEEN ESTIMATED AT AN INSURANCE CLAIM AGENCY FOR INSPECTION OF PRIOR HAIL DAMAGE. NO LIGHTS WERE DISPLAYED TO WARN AND NO LIGHTS ILLUMINATED AFTERWARDS AS WELL. HAVE NOT YET TAKEN TO DEALER, PLANS TO CONTACT GENER…
Read full complaint
DT: VEHICLE WAS PARKED AND WHEN PLACED KEY IN IGNITION DRIVER'S SIDE AIR BAG DEPLOYED ONTO DRIVER. VEHICLE HAD BEEN ESTIMATED AT AN INSURANCE CLAIM AGENCY FOR INSPECTION OF PRIOR HAIL DAMAGE. NO LIGHTS WERE DISPLAYED TO WARN AND NO LIGHTS ILLUMINATED AFTERWARDS AS WELL. HAVE NOT YET TAKEN TO DEALER, PLANS TO CONTACT GENERAL MOTORS. *AK
PASSENGER DOORS HINGES ARE STICKING
Official recalls
100V085000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Mar 16, 2000
VEHICLE DESCRIPTION: PASSENGER VANS EQUIPPED WITH A BRAKE WARNING INDICATOR. SOME OF THESE VEHICLES HAVE A POWER STEERING COOLER HOSE THAT CAN SEPARATE FROM THE POWER BRAKE BOOSTER FLUID FLOW SWITCH ASSEMBLY.
Consequence & remedy
Consequence: IF THIS OCCURS, POWER STEERING FLUID COULD FLOW ONTO HOT ENGINE PARTS AND AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT FOR THREE SCREW CLAMPS TO THE POWER STEERING HOSE JOINTS. IF THE CLAMPS ARE NOT THE SCREW TYPE, DEALERS WILL REPLACE THE CLAMPS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.