IllustrationFAILURE OF INTAKE MANIFOLD GASKET CAUSING LOSS OF COOLANT AT 42000 MILES AND AGAIN AT 90008 MILES. *NM
1998 Chevrolet Express
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Express years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 23 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports2 fire reports0 injury reports
What owners actually said
23 reportsTHE PASSENGER SIDE DOOR HINGE BROKE COMPLETELY OFF WITHOUT EXCESSIVE FORCE BEING APPLIED. THE DEALERSHIP INDICATED THIS OCCURRED BECAUSE THE DOOR WAS NOT FREQUENTLY USED. IN AN ATTEMPT TO REPAIR THE HINGE, THE DEALERSHIP MADE THE PROBLEM WORSE. *AK THE DEALERSHIP STATED THE PIN SEIZED UP DUE TO NO LUBRICATION. *JB
THE DOOR HINGES FROZE UP AFTER A PERIOD OF TIME. THE CONSUMER HAD TO USE EXCESSIVE FORCE TO CLOSE THE DOOR WHICH CAUSED THE DOOR TO BE MISALIGNED. *JB PH *JB
CONSUMER STATED THAT WHILE DRIVING AND WITHOUT WARNING THE REAR AXLE FAILED CAUSING OIL TO LINK FROM THE VEHICLE. DEALER NOTIFIED TS
CONSUMER STATES THAT WHEN TRYING TO APPLY THE BRAKES THE BRAKE PEDAL WILL GO TO THE FLOOR CAUSING THE VEHICLE TO HAVE EXTENDED STOPPING DISTANCE. DEALER NOTIFIED TS
SMELLED GASOLINE AND SAW FUEL DRIPPING FROM SIDE AND BOTTOM OF VAN...VAN SPUTTERED TO STOP, LOST POWER STEERING BUT WAS ABLE TO COAST TO CLOSED GARAGE PARKING LOT...DETERMINED PLASTIC FUEL LINE WAS PUNCTURED--THEY TOLD ME PART(FUEL LINE) WAS DISCONTINUED!??
I NOTICED A CONTINUOUS TIRE THUMP" AND STOPPED THE VEHICAL AND CHECKED THE TIRES. THE LEFT FRONT TIRE HAD A FLAT SPOT IN THE CENTER OF THE TREAD, ABOUT 2IN X 1.5 IN. THERE WERE NO OTHER ABNORMATITIES. AFTER TRAVELING ABOUT 30 MORE MILES THE "THUMP" GOT ALOT MORE APPARENT AND I HEARD A LOUD "CLINKING" NOISE. I STOPPED AND INSPECT…
Read full complaint
I NOTICED A CONTINUOUS TIRE THUMP" AND STOPPED THE VEHICAL AND CHECKED THE TIRES. THE LEFT FRONT TIRE HAD A FLAT SPOT IN THE CENTER OF THE TREAD, ABOUT 2IN X 1.5 IN. THERE WERE NO OTHER ABNORMATITIES. AFTER TRAVELING ABOUT 30 MORE MILES THE "THUMP" GOT ALOT MORE APPARENT AND I HEARD A LOUD "CLINKING" NOISE. I STOPPED AND INSPECTED THE TIRE AND FOUND THE TREAD WAS SEPARATING FROM THE TIRE OVER ABOUT A 12 IN. OF LENGTH WHERE THE STEEL BELT STOPS AT THE SIDE WALL. THE TREAD WAS STILL INTACT. I BELEIVE THAT IF I HAD NOT STOPPED WHEN I DID THAT TOTAL SEPERATION OF THE TREAD WOULD HAVE OCCURED WITHIN THE NEXT MILE OR SO. I HAVE THE TIRE IF YOU NEED TO INSPECT IT AND/OR I CAN SEND YOU PHOTOS .*AK (DOT NUMBER: VN1181A098 TIRESIZE: LT 245/ 75)
AIR TEMPERATURE 100 DEGREES FAHRENHEIT, AIR PRESSURE IN TIRE CHECKED AT 80 PSI COLD, SPEED 60MPH. THIS IS THE THIRD TIRE OF THIS SIZE AND MAKE, MADE IN CANADA. THIS ONE AND OTHER TWO HAD ABOUT 9 TO 10 THOUSAND MILES ON THE ROAD. EACH SUFFERED A TREAD SEPARATION. OTHERS HAD ODI#735190. *AK (DOT NUMBER: TPC 2012MS TIRESIZE: 24575…
Read full complaint
AIR TEMPERATURE 100 DEGREES FAHRENHEIT, AIR PRESSURE IN TIRE CHECKED AT 80 PSI COLD, SPEED 60MPH. THIS IS THE THIRD TIRE OF THIS SIZE AND MAKE, MADE IN CANADA. THIS ONE AND OTHER TWO HAD ABOUT 9 TO 10 THOUSAND MILES ON THE ROAD. EACH SUFFERED A TREAD SEPARATION. OTHERS HAD ODI#735190. *AK (DOT NUMBER: TPC 2012MS TIRESIZE: 24575R16 E)
THE PROBLEM IS IN BUCKLE FAILURES AND RETRACTOR FAILURES. RIVERSIDE VANS (CONVERSION CO.) SAID THEY HAVE HAD NO PROBLEMS WITH THESE BELTS. I HAVE HAD 4 FAILURES. MFR. IS ATWOOD MOBILE PRODUCTS. *AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
Official recalls
198V033000 · Service Brakes, Hydraulic:foundation Components:disc:rotor
Feb 17, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. ONE OR BOTH FRONT BRAKE ROTOR/HUBS WERE BUILT WITH AN OUT-OF-SPECIFICATION GRAY IRON THAT CAN FAIL DURING THE LIFE OF THE VEHICLE.
Consequence & remedy
Consequence: IF A DRIVER CONTINUES TO DRIVE WITH A CRACKED ROTOR, THE CRACKS COULD CONTINUE AROUND THE WHEEL MOUNTING BOLT CIRCLE AND ULTIMATELY RESULT IN A WHEEL SEPARATION.
Remedy: DEALERS WILL INSPECT THE ROTORS FOR A CORE DATE OF "287" AND, IF FOUND, REPLACE THE ROTOR.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.