← New search

2004 Chevrolet Express 2500

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →

How this year compares

Owner complaints by model year

Other model years Selected year
Compare all Express 2500 years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

All reported categories

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 6 of 8 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine And Engine Cooling. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports0 fire reports0 injury reports

Power Train complaints

3 reports
Clear category filter
119,000 miles · Aug 2, 2013
Power Train

TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS 2500. THE CONTACT STATED WHENEVER AT AN IDLE A LOUD METAL TO METAL NOISE WOULD EMIT CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC ON TWO SEPARATE OCCASIONS WHERE THE CRACKED FLYWHEEL WAS REPLACED EACH TIME. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROX…

Read full complaint

TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS 2500. THE CONTACT STATED WHENEVER AT AN IDLE A LOUD METAL TO METAL NOISE WOULD EMIT CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC ON TWO SEPARATE OCCASIONS WHERE THE CRACKED FLYWHEEL WAS REPLACED EACH TIME. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 119,000.

NHTSA ODI #10533187

103,000 miles · Jun 14, 2010
Engine And Engine CoolingPower Train

MYSTERIOUS COOLANT LEAK. RESERVOIR IS LOW AND NEEDS REFILLING OFTEN. MECHANIC HAS PERFORMED PRESSURE TEST TO NO AVAIL. NO COOLANT ON GROUND AT ANY POINT. NO VISIBLE SIGNS OF LEAK. THIS BEGAN RIGHT AFTER 2ND CRACKED FLYWHEEL WAS REPLACED. AT THE SAME TIME A LIFTER KNOCK BEGAN AS WELL. 1ST FLYWHEEL WAS REPLACED AT 103K (3K …

Read full complaint

MYSTERIOUS COOLANT LEAK. RESERVOIR IS LOW AND NEEDS REFILLING OFTEN. MECHANIC HAS PERFORMED PRESSURE TEST TO NO AVAIL. NO COOLANT ON GROUND AT ANY POINT. NO VISIBLE SIGNS OF LEAK. THIS BEGAN RIGHT AFTER 2ND CRACKED FLYWHEEL WAS REPLACED. AT THE SAME TIME A LIFTER KNOCK BEGAN AS WELL. 1ST FLYWHEEL WAS REPLACED AT 103K (3K OUTSIDE OF EXTENDED WARRANTY). 2ND FLYWHEEL REPLACED AT 143K. VAN IS KEPT IN MINT CONDITION, OIL CHANGED EVERY 3K W/O FAIL. VEHICLE SEEMS TO BE IN OTHERWISE TERRIFIC CONDITION. 1ST AND ONLY OWNER. DATE REFERRED TO IS DATE OF 2ND FLYWHEEL CRACK. *TR

NHTSA ODI #10336168

Mileage unknown · Apr 15, 2010
Power Train

REPEATED CRACKED FLYWHEEL. ORIGINAL CRACKED JUST OVER 100K MILES. REPLACEMENT NOW CRACKED 40K MILES LATER. *TR

NHTSA ODI #10325828

Official recalls

1

05V559000 · Exterior Lighting

Dec 13, 2005

CERTAIN CONVERSION VANS BUILT ON GMC/CHEVROLET CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT." THE HOUSING LENS OF THE CENTER HIGH MOUNTED STOP LAMP DOES NOT ALLOW ENOUGH LIGHT TO EMIT FROM THE LAMP.

Consequence & remedy

Consequence: FOLLOWING VEHICLES MAY NOT BE FULLY INFORMED OF VEHICLE BRAKING. REAR-END CRASHES AND INJURY TO OCCUPANTS MAY OCCUR.

Remedy: QUALITY COACHES IS WORKING WITH AUDIOVOX TO REPLACE THE CENTER HIGH-MOUNTED BRAKE LAMP ASSEMBLY. OWNERS MAY CONTACT QUALITY COACHES AT 1-800-373-6357 OR ASA AT 1-800-274-1886.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.